Looking for better mileage.
Thread Starter
|
Elder User
Joined: Jul 2012
Posts: 947
Likes: 0
From: Glen Rose, Texas
Looking for better mileage.
I have a 00 F250 7.3 4x4 and I am looking to get better mileage out of it since it is now a dedicated work truck for towing. The two options I have in mind I think will work, but just wanted some clarification and if one is even possible.
First I will be taking the lift off and dropping back down to 33 inch tires or so. This should give me a little, but if not it should be easier on the truck for towing.
And this truck mostly see's highway miles, so I was thinking about disengaging the 4wd. I heard 4wd trucks get worse mileage, so this is the one I didn't even know if it was possible.
Any input on how and if would even work would be grateful. This is just the basics for now, and not digging in to the computer and injectors quite yet.
First I will be taking the lift off and dropping back down to 33 inch tires or so. This should give me a little, but if not it should be easier on the truck for towing.
And this truck mostly see's highway miles, so I was thinking about disengaging the 4wd. I heard 4wd trucks get worse mileage, so this is the one I didn't even know if it was possible.
Any input on how and if would even work would be grateful. This is just the basics for now, and not digging in to the computer and injectors quite yet.
Cargo Master
Joined: Jan 2015
Posts: 2,824
Likes: 39
From: Boise
On a Ford, when your hubs are unlocked and the Tcase is in 2wd, your 4x4 is totally disengaged. You only are carrying more weight than a 2wd.
Tuners are the best way to increase mpg's once you go back down to closer to a stock height.
On my 7.3's, I opened up the exhaust and ran the open air filter known as the Napa 6637, neither of which are too expensive.
Tuners are the best way to increase mpg's once you go back down to closer to a stock height.
On my 7.3's, I opened up the exhaust and ran the open air filter known as the Napa 6637, neither of which are too expensive.
Postmaster
Joined: Jul 2015
Posts: 4,392
Likes: 22
From: very South Texas
gas mileage, a large frontal area. high off the ground and weighting over 7,000 pounds.
very small improvements are possible.. very small
even removing the front drive and transfer case.. may give you 1/2 of 1... almost nothing.
stock size tires and wheels or Smaller, lower truck, lower air dam. maybe 2 miles per gallon. . my opinion... and go real soft on the throttle pedal ..
maybe consider a compact car.
.
very small improvements are possible.. very small
even removing the front drive and transfer case.. may give you 1/2 of 1... almost nothing.
stock size tires and wheels or Smaller, lower truck, lower air dam. maybe 2 miles per gallon. . my opinion... and go real soft on the throttle pedal ..
maybe consider a compact car.
.
Lead Driver
Joined: Oct 2014
Posts: 5,943
Likes: 1,357
From: NY/Canada border
Had a 1997 F Super Duty (450 before they called them a 450) with 7.3. Went with a DP Tuner 4 position chip and a K&N breather kit. I used the hardware but ditched the K&N filter and went with a Donaldson water resistant (marine) paper filter. Basically the same as NAPA 6637.
It woke the truck up some, because it was a slug. But better mileage was never realized. I think you're in basically the same boat. Like Chuck says, any gains will be minimal.
When I contacted 5 Star about improving the mileage on the F450 V10 in my signature, they told me to save my money. Because again, gains - if any would be minimal.
It woke the truck up some, because it was a slug. But better mileage was never realized. I think you're in basically the same boat. Like Chuck says, any gains will be minimal.
When I contacted 5 Star about improving the mileage on the F450 V10 in my signature, they told me to save my money. Because again, gains - if any would be minimal.
Cargo Master
Joined: Feb 2015
Posts: 2,338
Likes: 255
From: Livermore Ca.
Taking the lift off will be a good start. Going back to the stock tire size will also be another place to go. Change all your gear lub to synthetic including differential engine transmission will also help. 2 MPG will equate to a 52 mile per tank increase. How many tanks a month do we use. over the year that adds up fast. If you have a bigger tank than it's even more.
Also correct tire pressure is a must. Stay away from tunes and CAI's. to go faster you need more fuel and air not economical at all. More fun but not what you want. Maintain the motor. Keep the air cleaner clean
Also correct tire pressure is a must. Stay away from tunes and CAI's. to go faster you need more fuel and air not economical at all. More fun but not what you want. Maintain the motor. Keep the air cleaner clean
Trending Topics
Laughing Gas
Joined: Sep 2013
Posts: 1,031
Likes: 13
The only way I was able to achieve better fuel mileage was through gearing. You must gear the truck appropriately for the load. I was towing 15k with 3.73s. That's a recipe for terrible MPG. I went to 4.56 and my mileage climbed 4 mpg. Also, in combination with this, slowing the hell down helps immensely. There's a sticker on your engine that has the fuel burn rate at a specific RPM listed. The closer you can get your final drive RPM to that with a corresponding lower load on the engine at that speed, you can effectively increase the MPG.
FTE Stories
Ford Trucks for Ford Truck Enthusiasts
Top 10 Most Expensive Ford Trucks Ever Sold on Bring a Trailer
Joe Kucinski
2027 Ford Super Duty Buyer's Guide (Every Model, Engine, & Package)
Brett Foote
Top 10 Ford Truck Tragedies
Joe Kucinski
AEV FXL Super Duty - the Super Duty Raptor Ford Doesn't Make
Brett Foote
Lobo Vs Lobo: Proof the F-150 Lobo Should Be Even Lower!
Michael S. Palmer
Ford's 2001 Explorer Sportsman Concept Looks For a New Home
Verdad Gallardo
10 Best Ford Truck Engines We Miss the Most!
Joe Kucinski
2026 Shelby F-150 Off-Road: Better Than a Raptor R?
Brett Foote
2027 Super Duty Carhartt Package First Look: 12 Things You NEED to Know!
Michael S. Palmer
Thread
Thread Starter
Forum
Replies
Last Post