E4OD Problem, I think.

Reply Subscribe

Thread Tools

Search this Thread

Nov 5, 2014 | 05:55 PM

terrylamar

Thread Starter

Senior User

Joined: Jan 2010

Posts: 136

Likes: 0

E4OD Problem, I think.

I think my E4OD transmission is acting up. It shifts "normally" as far as I am concerned through third gear. When shifting into overdrive, it started out by stuttering a bit. This has, progressively, gotten worse. Now, not only does it stutter, but between 50 mph and 59 mph, it feels like something is out of balance. It improves, slightly, at 60 mph. When slowing down, at times you can feel the entire truck pitching and yawing.

If it isn't the transmission, something is out of balance and I can't find it. I don't think it is the engine, I can rev. it while in neutral and everything seems fine.

I'm thinking now may be the time to switch over to a manual transmission rather than rebuilding this one.

But, what do I know, I'm not a mechanic!

Nov 5, 2014 | 07:32 PM

madMatador78

Cargo Master

Joined: Dec 2011

Posts: 2,750

Likes: 4

From: Pecatonica, IL

How about u joints? Carrier bearing? My first thought was torque converter, but don't quote me on that. Hopefully someone else will chime in soon.

Nov 5, 2014 | 07:55 PM

terrylamar

Thread Starter

Senior User

Joined: Jan 2010

Posts: 136

Likes: 0

The U joints and Carrier Bearing seem fine. I have examined them visually and tried to move them.

Nov 5, 2014 | 08:30 PM

Mark Kovalsky

Frmr Ford Trans Engr

Joined: Aug 1999

Posts: 24,705

Likes: 2,626

From: SE Florida

If you didn't remove the driveshaft to check the carrier bearing and ujoints you have no idea if they are good or about to fail. It is impossible to check them with the driveshaft installed in the truck.