'77 starter problems
Thread Starter
|
Fleet Mechanic
Joined: Jul 2000
Posts: 1,493
Likes: 346
From: SE Iowa
'77 starter problems
Hey guys, I have a little problem. I have gone through 3 starters in 2 years. The 3rd one was even a brand new one and not a reman. The problem is that they are getting really hot! What I cant figure out is, what is causing it??? The coolant temp stay pretty steady around 195/200 on my aftermarket gauge. I've noticed that after driving it for over an hour, the engine bay gets so hot that you cant touch anything. Any Ideas? I replaced the clutch fan for a full time belt driven one and it help the last starter last long than the other two. Im at my wits end. I need to sell this truck, but i cant in good conscience do it knowing there is this problem.
Thanks
Styder
:-X11
Thanks
Styder
:-X11
Junior User
Joined: Feb 2002
Posts: 57
Likes: 0
'77 starter problems
i'm no expert,
but have you tried looking for a short either in your starter relay/ power wire to starter? it could cause overheating of starter. as for your engine temp that sounds about right on your aftermarket gauge and the engine will most likely be too hot to touch fpr very long after an hour of driving! is your tranny getting really hot? i dunno if this helps but maybe its a place to start.
just my two cents,
nick.
but have you tried looking for a short either in your starter relay/ power wire to starter? it could cause overheating of starter. as for your engine temp that sounds about right on your aftermarket gauge and the engine will most likely be too hot to touch fpr very long after an hour of driving! is your tranny getting really hot? i dunno if this helps but maybe its a place to start.
just my two cents,
nick.
Posting Guru
Joined: Sep 2001
Posts: 1,531
Likes: 1
From: in the country
'77 starter problems
You didn't say whether or not you had headders , I'll assume you don't!!!The most obvious things to check\replace---thermostat , radiator cap , I believe I would just pull the radiator(assuming the truck is running o.k , neither too lean or other problems)and have it rodded out, new thermostat , cap , and possibly even hoses---and maybe even a new sending unit for your temp dash gauge--in addition to this Summit sells a very nice heat shield\wrap for your starter for about 30 or so...........I think autozone or somebody sells a diagnostic kit that is supposed to be very good in finding problems with cooling systems!!!fd 
Thread Starter
|
Fleet Mechanic
Joined: Jul 2000
Posts: 1,493
Likes: 346
From: SE Iowa
'77 starter problems
Thanks guys. I hadnt thought of checking for a short. With this last starter, I put all new battery cables and starter cable, but I didnt look at the I/S wires. Yeah, I had thought about the starter sheild, but was hoping i could track down teh culprit first. I'll probably get one anyway.
Thanks again!
Stryder
:-X11
Thanks again!
Stryder
:-X11
Thread
Thread Starter
Forum
Replies
Last Post
birchwoodford
1980 - 1986 Bullnose F100, F150 & Larger F-Series Trucks
8
Mar 22, 2012 12:16 PM
captain1997
1987 - 1996 F150 & Larger F-Series Trucks
6
Sep 13, 2011 10:25 AM
carnagez28
Pre-Power Stroke Diesel (7.3L IDI & 6.9L)
5
Aug 25, 2006 08:10 AM
