Notices
1999 - 2003 7.3L Power Stroke Diesel  
Sponsored by:
Sponsored by: DP Tuner

DP reinstall problems

Old Feb 19, 2012 | 11:51 AM
  #1  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
DP reinstall problems

Sorry if this is a repost, I got the dreaded "connection problems" popup the first time. I just reinstalled my DP and all the dash lights and vac pump are turning on and off like I keep cycling the key over and over. Any suggestions? Thanks!
 
Reply
Old Feb 19, 2012 | 12:29 PM
  #2  
PaysonPSD's Avatar
PaysonPSD
Post Fiend
Joined: Nov 2007
Posts: 9,549
Likes: 14
From: Payson, AZ
Pull the PCM and take a real good look at all the pins. Make sure none are loose or bent. Also make sure the DP chip is installed correctly and there are no shorts between the connecting contacts where the chip plugs up.

Also check all PCM related fuses.

Hate to ask, but have to. You didn't have the key in the ignition did you?

Edit: Bolt holding the PCM connector must be tight to ensure all PCM pins have good connection.
 
Reply
Old Feb 19, 2012 | 01:10 PM
  #3  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
I had the key out and both batteries disconnected. Will go pull and inspect everything.
 
Reply
Old Feb 19, 2012 | 01:31 PM
  #4  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
Appears to be a problem with the cable. At the cable connector to the chip I have a little pigtail of the RED wire with the drain soldered to it. At the switch connector it appears this connection is severed. Can someone verify the drain hits the red wire at both cable connectors? Thanks!
 
Reply
Old Feb 19, 2012 | 02:07 PM
  #5  
DP-Tuner's Avatar
DP-Tuner
PREMIUM SPONSOR
20 Year Member
Joined: Mar 2005
Posts: 1,863
Likes: 19
From: Hoschton,GA
Originally Posted by 01PS
Sorry if this is a repost, I got the dreaded "connection problems" popup the first time. I just reinstalled my DP and all the dash lights and vac pump are turning on and off like I keep cycling the key over and over. Any suggestions? Thanks!
Mike, We were at the movies when you emailed me. I haven't had a chance to respond to you so I am glad you posted on this forum because you will be in good hands. Lots a dirty pool going around on other forums. Diane
 
__________________
Jody & Diane Tipton- DP-Tuner®
FTE Legacy Sponsors since 2006
Custom tuning for 7.3l, 6.0l, 6.4l,6.7l, Ecoboost,
Get Tuned! 828-221-0076 ext. 802
Become our Facebook Fan
Reply
Old Feb 19, 2012 | 02:12 PM
  #6  
PaysonPSD's Avatar
PaysonPSD
Post Fiend
Joined: Nov 2007
Posts: 9,549
Likes: 14
From: Payson, AZ
Diane,

What about this red wire Mike is talkig about.

Also, Big Thanks for posting on a Sunday.

Originally Posted by 01PS
Appears to be a problem with the cable. At the cable connector to the chip I have a little pigtail of the RED wire with the drain soldered to it. At the switch connector it appears this connection is severed. Can someone verify the drain hits the red wire at both cable connectors? Thanks!
 
Reply
Old Feb 19, 2012 | 02:19 PM
  #7  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
Originally Posted by DP-Tuner
Mike, We were at the movies when you emailed me. I haven't had a chance to respond to you so I am glad you posted on this forum because you will be in good hands. Lots a dirty pool going around on other forums. Diane
My network connection sucks, so sorry if this re-posted. Thank you for getting back to me on your weekend. That's a shame to hear. This is the only forum I use. To much attitude and too little help on most of the others.

I soldered the drain to the red wire sticking out of the switch connector. I used heat shrink and am waiting for the liquid electrical tape to dry. Will reinstall shortly and post results. I can only blame myself for poor switch mounting.

EDIT: Will be sure and ring the cable out before it gets hooked up.
 
Reply
Old Feb 19, 2012 | 02:21 PM
  #8  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
Originally Posted by PaysonPSD
Diane,

What about this red wire Mike is talkig about.

Also, Big Thanks for posting on a Sunday.
Thank you for thanking them for me. I'm having to compose replies two and three times today for some reason.
 
Reply
FTE Stories

Ford Trucks for Ford Truck Enthusiasts

story-0

Every 2026 Ford Engine Explained

 Brett Foote
story-1

10 Ugly Ford Trucks That We Still Kinda Love

 Joe Kucinski
story-2

10 Things Every Truck Owner NEEDS (2026 Edition)

 Michael S. Palmer
story-3

Rezvani's Latest Post-Apocalyptic Monster Is a Ford F-150 Raptor Underneath

 Verdad Gallardo
story-4

Top 10 Most Expensive Ford Trucks Ever Sold on Bring a Trailer

 Joe Kucinski
story-5

2027 Ford Super Duty Buyer's Guide (Every Model, Engine, & Package)

 Brett Foote
story-6

Top 10 Ford Truck Tragedies

 Joe Kucinski
story-7

AEV FXL Super Duty - the Super Duty Raptor Ford Doesn't Make

 Brett Foote
story-8

Lobo Vs Lobo: Proof the F-150 Lobo Should Be Even Lower!

 Michael S. Palmer
story-9

Ford's 2001 Explorer Sportsman Concept Looks For a New Home

 Verdad Gallardo
Old Feb 19, 2012 | 02:45 PM
  #9  
DP-Tuner's Avatar
DP-Tuner
PREMIUM SPONSOR
20 Year Member
Joined: Mar 2005
Posts: 1,863
Likes: 19
From: Hoschton,GA
Originally Posted by 01PS
Thank you for thanking them for me. I'm having to compose replies two and three times today for some reason.
If this is what's happening you just need a new cable. Email me your last name and I'll get one out to you. Oh before you ask,there's no charge. It's covered under our lifetime manufactures warranty. Diane
 
__________________
Jody & Diane Tipton- DP-Tuner®
FTE Legacy Sponsors since 2006
Custom tuning for 7.3l, 6.0l, 6.4l,6.7l, Ecoboost,
Get Tuned! 828-221-0076 ext. 802
Become our Facebook Fan
Reply
Old Feb 19, 2012 | 02:52 PM
  #10  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
Do you think it's a bad idea to use my repaired cable for now? Cable rang out fine after repair. I want to put a new one on, but impatience is getting the better of me.
 
Reply
Old Feb 19, 2012 | 03:02 PM
  #11  
DP-Tuner's Avatar
DP-Tuner
PREMIUM SPONSOR
20 Year Member
Joined: Mar 2005
Posts: 1,863
Likes: 19
From: Hoschton,GA
Go ahead and try it. I will still send you a new cable. Diane
 
__________________
Jody & Diane Tipton- DP-Tuner®
FTE Legacy Sponsors since 2006
Custom tuning for 7.3l, 6.0l, 6.4l,6.7l, Ecoboost,
Get Tuned! 828-221-0076 ext. 802
Become our Facebook Fan
Reply
Old Feb 19, 2012 | 03:37 PM
  #12  
PaysonPSD's Avatar
PaysonPSD
Post Fiend
Joined: Nov 2007
Posts: 9,549
Likes: 14
From: Payson, AZ
Diane,

Great costumer service.
 
Reply
Old Feb 19, 2012 | 03:41 PM
  #13  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
Well, in my haste I overlooked the obvious. Dirty battery connections. This key cycling thing happened after I pulled the tuner again. I thought I cooked the PCM, then had a look at my battery cables......filthy. Truck acted fine after I cleaned connections without tuner. Just finished reinstalling and am headed out for a test drive. Thanks for all the help folks.
 
Reply
Old Feb 19, 2012 | 04:18 PM
  #14  
01PS's Avatar
01PS
Thread Starter
|
Elder User
Joined: Jun 2007
Posts: 705
Likes: 1
From: Sandia Park, NM
Runs great, thanks folks.
 
Reply
Old Feb 19, 2012 | 04:20 PM
  #15  
PaysonPSD's Avatar
PaysonPSD
Post Fiend
Joined: Nov 2007
Posts: 9,549
Likes: 14
From: Payson, AZ
Originally Posted by 01PS
Runs great, thanks folks.
Good News. Always nice to read good news.
 
Reply

Thread Tools
Search this Thread

All times are GMT -5. The time now is 03:22 PM.

story-0
Every 2026 Ford Engine Explained

Here's everything you need to know about every Ford engine available for the 2026 model year.

By Brett Foote | 2026-06-05 12:58:01


VIEW MORE
story-1
10 Ugly Ford Trucks That We Still Kinda Love

Slideshow: 10 ugly Ford trucks that we still kinda love.

By Joe Kucinski | 2026-06-03 09:51:16


VIEW MORE
story-2
10 Things Every Truck Owner NEEDS (2026 Edition)

Slideshow: the best gifts for dads & grads

By Michael S. Palmer | 2026-06-03 15:43:58


VIEW MORE
story-3
Rezvani's Latest Post-Apocalyptic Monster Is a Ford F-150 Raptor Underneath

Slideshow: Called the Fortress, the 850-horsepower pickup combines Raptor underpinnings with military-inspired features, survival equipment, and a starting price of $285,000.

By Verdad Gallardo | 2026-06-03 11:38:36


VIEW MORE
story-4
Top 10 Most Expensive Ford Trucks Ever Sold on Bring a Trailer

Slideshow: 10 most expensive Ford trucks ever sold on Bring a Trailer.

By Joe Kucinski | 2026-05-27 16:24:34


VIEW MORE
story-5
2027 Ford Super Duty Buyer's Guide (Every Model, Engine, & Package)

Here's everything that has changed for the latest model year.

By Brett Foote | 2026-05-27 16:17:28


VIEW MORE
story-6
Top 10 Ford Truck Tragedies

Slideshow: Top 10 Ford truck tragedies.

By Joe Kucinski | 2026-05-18 19:34:33


VIEW MORE
story-7
AEV FXL Super Duty - the Super Duty Raptor Ford Doesn't Make

And it might be even better than that.

By Brett Foote | 2026-05-18 19:26:42


VIEW MORE
story-8
Lobo Vs Lobo: Proof the F-150 Lobo Should Be Even Lower!

Slideshow: Does lowering an F-150 Lobo RUIN the ride quality?

By Michael S. Palmer | 2026-05-18 19:20:37


VIEW MORE
story-9
Ford's 2001 Explorer Sportsman Concept Looks For a New Home

Slideshow: Ford's bizarre fishing-themed Explorer concept has resurfaced after spending decades largely forgotten.

By Verdad Gallardo | 2026-05-12 18:07:46


VIEW MORE