Fulltext TSBs

Technical Service Bulletins

06-20-5

  • PARKING AID SPEAKER INOPERATIVE – DTCS C1742 AND C1743
07-18-4

  • 6.0L – INTERMITTENT MIL ON AND/OR INTERMITTENT DTC P0470 – TEMPERATURES BELOW FREEZING
06-15-5

  • SLIDING POWER WINDOW (BACK GLASS) SERVICE PROCEDURE
06-16-1

  • CHROME TOW HOOKS RUSTING PREMATURELY – VEHICLES BUILT PRIOR TO 7/17/2006
06-16-2

  • FRONT WHEEL BEARING NOISE – F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006
06-17-7

  • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS
06-21-7

  • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-21-15

  • MIL ON – DTC P1285 / P1299 – 5.4L 3V / 6.8L 3V – FALSE OVERHEAT
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-22-9

  • 6.0L – MIL ON WITH DTC P2138, P2139, AND P2140
06-22-12

  • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
06-22-15

  • HEATER CORE LEAKS – 6.0L ENGINE
06-23-4

  • DRIVE-AWAY SHUDDER OR VIBRATION
06-23-9

  • HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-26-5

  • KING RANCH CREW CAB MODEL ONLY – WHITE CORROSION ON RUNNING BOARDS
07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
07-2-7

  • 6.0L – REDUCED ENGINE PERFORMANCE – HIGH ALTITUDE
07-3-10

  • LACK OF COOLING FAN OPERATION – 6.0L
07-4-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
07-5-8

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
07-5-11

  • VIBRATION/HOP AT 40-48 MPH (68-77 KM/H) – (8.0 HZ) – TRAILER HITCH EQUIPPED VEHICLES ONLY
07-5-15

  • 6.0L – OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
07-6-9

  • 6.0L DIESEL ENGINE – BUCK/JERK WHEN PULLING LARGE/HEAVY GOOSE NECK TRAILERS
07-7-2

  • REAR OF VEHICLE IS TOO HIGH/LOW – 5TH WHEEL AND GOOSE NECK APPLICATIONS – 4X4 VEHICLES ONLY
07-9-8

  • ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503
07-10-4

  • 6.0L – SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
07-10-5

  • FRONT DOOR SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW MOLDING
07-10-10

  • STEERING WHEEL OSCILLATION
07-11-2

  • BRAKE PEDAL KICKBACK OR GRABBING
07-11-5

  • DIESEL ENGINE – OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE
07-11-11

  • 5.4L AND 6.8L ENGINES – EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE – VEHICLES BUILT ON OR BEFORE 9/8/2006
07-13-7

  • DRIVELINE NOISE UNDER LIGHT LOAD – 40-50 MPH (64-80 KM/H) – 6.0L REGULAR CAB 4X2 WITH 137 INCH WHEELBASE
07-14-8

  • ERRATIC SHIFTS – SPEEDS ABOVE 50 MPH (80 KM/H) AND/OR ENGAGEMENT SHUDDER
07-21-7

  • 5.4L GAS ENGINES – DTC P0171, P0172, P0174, P0175 WITH OR WITHOUT DRIVABILITY CONCERNS – CRUISE CONTROL SURGE
07-23-17

  • ENGINE KNOCK ON 6.8L 3V ENGINES WITH ENGINE BUILD DATES BETWEEN 6/26/2007 AND 8/30/2007
07-24-8

  • ENGINE MISFIRE DURING CRUISE WITH OR WITHOUT DTCS (MEXICO ONLY)
07-25-2

  • TAILGATE STRIKER – NOISE/RATTLE
07-26-1

  • BELT CHIRP – POWER STEERING PUMP PULLEY ALIGNMENT – 6.0L – VEHICLES BUILT BETWEEN 1/1/2006 – 8/31/2006
08-7-6

  • SPARK PLUG REMOVAL INSTRUCTIONS – 4.6L 3V/5.4L 3V/6.8L 3V
08-12-6

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
08-13-5

  • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
08-18-2

  • MIL ON – P0506 AND/OR P0505 – HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM
08-23-1

  • 6.0L DIESEL COOLING SYSTEM CONTAMINATION FLUSH PROCEDURE
08-24-2

  • VIBRATION DIAGNOSTICS – STEERING WHEEL NIBBLE – TIRE WHEEL RUNOUT AND BALANCE
08-24-8

  • WATER LEAKS – ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH
08-26-12

  • 6.0L – COKING DEPOSITS DIAGNOSTIC – EGR DTCS P0401, P0402, P0404, P1335

09-8-3

  • COOLANT LOSS – 6.0L
09-8-5

  • DIESEL COOLANT MAINTENANCE – SERVICE TIPS
09-16-5

  • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS
09-18-12

  • COOLING SYSTEM DIAGNOSTICS – OIL IN ENGINE COOLANT – 6.0L
09-20-12

  • SLOW FUEL FILL – 5.4 AND 6.8 ENGINES
09-22-1

  • 4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES
09-22-8

  • STAINLESS STEEL EXHAUST STUDS – 5.4L AND 6.8L 2V ENGINES
09-22-16

  • 6.0L DIESEL-DRIVEABILITY-NO START/HARD START/LONG CRANK/MISFIRE/RUNS ROUGH/LACK OF POWER/BUCK/JERK OR EXCESSIVE EXHAUST SMOKE DIAGNOSIS
09-24-3

  • 6.0L DIESEL CALIBRATION UPDATE – VARIOUS ISSUES
09-26-1

  • 6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS – BUILT ON OR BEFORE 9/30/2008
10-1-11

  • 4X4 ONLY – BANGING/CLUNKING NOISE WHEN DRIVING – CONTACT WITH JOUNCE BUMPER – COLD TEMPERATURES