Fulltext TSBs

Technical Service Bulletins

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
07-1-4

  • LACK OF COOLING FAN OPERATION – 6.0L
06-25-14

  • 6.0L – COKING DEPOSIT DIAGNOSTICS – SERVICE TIP
06-24-4

  • 6.0L – SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
06-24-1

  • 6.0L DIESEL ENGINE – OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
06-23-2

  • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS – LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P0478, P2262, AND/OR P2263
06-22-15

  • HEATER CORE LEAKS – 6.0L ENGINE
06-22-12

  • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
06-22-11

  • POWER STEERING FLUID LEAK AT JUMPER LINE TO HYDROBOOST CONNECTION – VEHICLES BUILT BEFORE 5/25/2006
06-22-3

  • WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-10

  • 6.0L – REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION
06-21-2

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-19-6

  • 6.0L – MIL ON – P0401, P0402, P0404, P1335, LACK OF POWER, OR SURGE. EGR VALVE CLEANING PROCEDURE.
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-18-2

  • SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING
06-17-12

  • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
06-17-7

  • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS
06-17-6

  • HIGH PRESSURE SYSTEM DIAGNOSTICS – 6.0L
06-15-11

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
06-13-11

  • 6.0L – MIL ON WITH DTC P0460
06-13-3

  • MISFIRE, LACK OF POWER, BUCK / JERK, EXCESSIVE SMOKE, CRANK / NO START – 6.0L ENGINE – DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS
06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-2-4

  • EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS – 6.0L
05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-25-11

  • BUMPER COVER WAVY/WARPED
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-22-3

  • LOW POWER – COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED – OIL LEAK AT CAC CONNECTIONS – 6.0L ENGINE – VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR – 6.0L
05-19-12

  • TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM – 6.0L BUILT AFTER 9/29/2003
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-17-16

  • DTC P0488 AND/OR P1334 WITH NO DRIVEABILITY SYMPTOMS, HARSH SHIFT AND/OR TRANSMISSION ENGAGEMENTS
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L ENGINE
05-13-16

  • FEAD BELT FRAYED/SHREDDED/BROKEN – 6.0L DIESEL ENGINE – VEHICLES BUILT THROUGH 1/1/2005
05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L ENGINE
05-12-3

  • CRANK NO START, HARD START, RUNS ROUGH AT IDLE – 6.0L
05-12-1

  • ENGINE QUITS UPON DRIVE OR REVERSE ENGAGEMENT, OR WHEN COMING TO A STOP – TORQSHIFT TRANSMISSION
05-11-4

  • VARIOUS DRIVEABILITY SYMPTOMS – CALIBRATION UPDATE RELEASE – 6.0L DIESEL ENGINE
05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
05-6-4

  • FALSE PARKING AID WARNINGS
05-4-17

  • INTERMITTENT ROUGH IDLE – NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
04-24-5

  • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL – INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION