Technical Service Bulletins
|Publication Date: February 21, 2006|
2003-2006 Focus, Mustang, Taurus
2003 Explorer Sport, Windstar
2003-2005 Excursion, Explorer Sport Trac
2003-2006 Escape, F-150, F-Super Duty, Ranger
2006 Low Cab Forward
2006 Mark LT
Some 2002-2006 vehicles equipped with an FS-10 A/C compressor may experience a non operational A/C compressor due to a low freon level caused by a leaking shaft seal.
Replace the A/C compressor shaft seal following the Service Procedure.
If the shaft seal on the front of the A/C compressor is leaking, replace the shaft seal (F1VY-19D665-A) and not the compressor assembly. Replacing the shaft seal should correct the leaking condition. When replacing the seal, follow the procedure outlined in Workshop Manual, Section 412-03.
|PART NUMBER||PART NAME|
|F1VY-19D665-A||A/C Compressor Seal Kit|
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
|MT060409||Use Standard Labor Operation For Compressor Removal And Installation If Available, And Claim Additional Labor Required As Actual Time||Actual Time|
|BASIC PART NO.||CONDITION CODE|
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.
Copyright © 2006 Ford Motor Company