Fulltext TSBs

Technical Service Bulletins

06-8-15

  • INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS – C1979 AND C1980
06-8-2

  • UN-COMMANDED TCC APPLY ON THE 1-2
    SHIFT CAUSING HESITATION AND/OR PERCEPTION OF LACK OF
    POWER DURING SHIFT
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT REQUIREMENTS
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-2-5

  • POWER FOLDING MIRROR OPERATION
05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-26-7

  • RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES
05-24-3

  • NOISE FROM BACK GLASS – POWER SLIDING
    REAR WINDOW ONLY
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-21-18

  • SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-16-12

  • SERVICE WIRING HARNESS REPLACEMENT
    GUIDELINES – SERVICE TIPS
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-9-23

  • STEERING COLUMN RATTLE/CLUNKING WHILE DRIVING OVER ROUGH SURFACES AND WHEN TURNING THE STEERING WHEEL
05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-25-15

  • ALUMINUM BODY PANELS – CORROSION – SERVICE TIP
06-23-6

  • NOISE FROM BACK GLASS – POWER SLIDING REAR WINDOW ONLY
06-22-7

  • UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-7

  • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-20-5

  • PARKING AID SPEAKER INOPERATIVE – DTCS C1742 AND C1743
06-19-16

  • SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION
06-19-14

  • NO CRANK / STARTER TERMINAL FATIGUE
06-19-13

  • RATTLE FROM TIP OUT ASHTRAY – VEHICLES BUILT PRIOR TO 1/1/2006
06-19-4

  • 4.6L AND 5.4L MIL ON WITH DTC P0606 AND/OR HIGH IDLE SPEED AND 5.4L INTERMITTENT HARD START
06-19-3

  • SERVICE CALIBRATION UPDATE – HESITATION ON ACCELERATION ON DOWNSHIFT – 5.4L 3V
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-17-8

  • SERVICE WIRING HARNESS REPLACEMENT GUIDELINES – SERVICE TIPS
06-15-8

  • KEYPAD DIAGNOSTICS – DEALER INSTALLED ACCESSORY
06-12-10

  • 5.4L MIL ON WITH DTC P0607
06-12-3

  • VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS
06-12-2

  • VEHICLE / STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER – STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER
06-11-12

  • 4X4 FRONT DIFFERENTIAL BRACKET REPAIR
06-10-9

  • FRAME REPLACEMENT MATRIX – SERVICE TIP
06-9-11

  • LOUD TICKING NOISE – 3-VALVE ENGINES – STUCK LASH ADJUSTER
06-9-8

  • INOPERATIVE ESOF 4X4 SYSTEM WITH DTC P1867
07-2-6

  • POWER WINDOW SLOW UPWARD TRAVEL

07-4-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
07-5-8

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
07-6-5

  • LOBO – REAR AXLE TUBE FRACTURE AT CENTER CARRIER (MEXICO ONLY)
07-10-9

  • VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS
07-12-1

  • POWER SLIDING REAR WINDOW MOTOR REPLACEMENT
07-12-3

  • RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS) – SERVICE TIPS
07-13-5

  • PASSENGER FRONT FLOOR WATER LEAK – A/C CONDENSATION LEAKING
07-16-13

  • WRENCH LAMP ON – DTC P0731 – 4.2L AND 4R75E ONLY
07-16-17

  • SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION – 3.8L, 3.9L, AND 4.2L – SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)
07-21-2

  • 4.6L 2V, 5.4L 2V, OR 6.8L 2V – SPARK PLUG THREAD REPAIR PROCEDURE – NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY
07-21-3

  • HIGH PRESSURE POWER STEERING LINE SEEPAGE – COLD CLIMATES ONLY (EXCLUDING HERITAGE F-150)
07-22-7

  • PAINT – INSTRUMENT PANEL – SCRATCH/MAR REPAIR TIPS
07-25-2

  • TAILGATE STRIKER – NOISE/RATTLE
07-25-13

  • FRAME REPLACEMENT MATRIX – SERVICE TIP
08-2-9

  • ERRATIC FUEL GAUGE OPERATION – MIL ON – DTCS P0460/P0463 OR INSTRUMENT CLUSTER MODULE DTC B1201 – VEHICLES BUILT BEFORE 12/3/2007
08-7-6

  • SPARK PLUG REMOVAL INSTRUCTIONS – 4.6L 3V/5.4L 3V/6.8L 3V
08-8-9

  • GRINDING NOISE FROM CLIMATE CONTROL – CHANGING AIR DISTRIBUTION MODES – BUILT AFTER 11/29/2005
08-11-1

  • INTERMITTENT VEHICLE VIBRATION – PARKING BRAKE DISENGAGEMENT CONCERNS
08-18-2

  • MIL ON – P0506 AND/OR P0505 – HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM
08-21-11

  • 4 WHEEL DRIVE/ALL WHEEL DRIVE – WITH CONTROL TRAC – SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS
08-23-6

  • EATC – INTERMITTENT WARM AIR OUTPUT TEMPERATURE SET 68-72 F (18-22 C)EMTC – INABILITY TO CONTROL TEMPERATURE OUTPUT
08-24-8

  • WATER LEAKS – ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH
08-25-5

  • DRIVERS SIDE COWL PANEL POPPED-UP
09-20-14

  • UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT
08-24-2

  • VIBRATION DIAGNOSTICS – STEERING WHEEL NIBBLE – TIRE WHEEL RUNOUT AND BALANCE