Fulltext TSBs

Technical Service Bulletins

TSB
05-10-14
  • MIL ON AND DTCS P035X – 5.4L OR 6.8L ENGINE
Publication Date: May 13, 2005

FORD:
2005 F-Super Duty

ISSUE:

Some 2005 F-Series Super Duty vehicles equipped with the 5.4L or 6.8L engine, may exhibit a malfunction indicator lamp (MIL) on with multiple ignition coil related diagnostic trouble codes (DTCs) P0351 through P0360, and no driveability symptoms. The DTCs are typically set during deceleration.

ACTION:

Do not replace ignition components for this condition. Reprogram the powertrain control module (PCM) to the latest calibration using WDS release B37.5 or higher. Calibration files may also be obtained at www.motorcraft.com.

WARRANTY STATUS:

Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage

OPERATIONDESCRIPTIONTIME
051014A2005 F-Series Super Duty 5.4L/6.8L Engines: Check For Diagnostic Trouble Codes And Reprogram The Powertrain Control Module (Do Not Use With 12650D, 12650D84)0.4 Hr.

DEALER CODING

BASIC PART NO.CONDITION CODE
RECALEM04

NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.

Copyright © 2005 Ford Motor Company