Blow-by causing IAC problems?
Thread Starter
|
Senior User
Joined: May 2010
Posts: 473
Likes: 0
Blow-by causing IAC problems?
My truck ('92 F-150 302EFI) periodically goes into an extremely high idle. I think the IAC needs cleaned. I don't have any carb cleaner, but i took the IAC and the other part it attaches to off to look at them. When I took the hoses from the airbox off, they had oil dripping out of them. The inside of the IAC and the other part had oil in/on them and the back piece had what looked like oil crud in it. Could blow-by cause this? If not, then what is it?
Thanks in advance.
Thanks in advance.
Fleet Owner
Joined: Oct 2005
Posts: 20,789
Likes: 1,753
From: Kentucky
It is not common for this vintage truck to have some oil deposits in the intake. As the engine gets some miles on it the problem can be amplified. Check/replace your PCV valve and the breather element in the airbox.
Your case does appear to be more than what I would expect. Clean the intake tract out, start with the new PCV and filter. Keep an eye on it. If the build up comes back quickly, it may be time for a leak down test.
Your case does appear to be more than what I would expect. Clean the intake tract out, start with the new PCV and filter. Keep an eye on it. If the build up comes back quickly, it may be time for a leak down test.
Fleet Owner
Joined: Oct 2005
Posts: 20,789
Likes: 1,753
From: Kentucky
The PCV (Positive Crankcase Ventilation) is located on the passenger side valve cover underneath the upper intake. Not a very good design IMHO. The fresh air intake filter is located underneath the engine air filter. There should be a tube running from the driver's side oil fill tube to the air filter box.
A few have tried using the breather filter you mentioned. It should work, but if you have emissions testing they may not be too keen on that setup.
A few have tried using the breather filter you mentioned. It should work, but if you have emissions testing they may not be too keen on that setup.
Thread Starter
|
Senior User
Joined: May 2010
Posts: 473
Likes: 0
so, I need to remove the upper intake? Great!lol. We don't even have the crap where they plug the truck in for emissions here. Most people run straights or glasspacks and my smog system's comin off.
Fleet Owner
Joined: Oct 2005
Posts: 20,789
Likes: 1,753
From: Kentucky
It is darn near impossible on my 5.8L engine to pull the PCV without removing the upper intake, the 5.0L is a little easier like the previous reply indicates.
Trending Topics
Thread Starter
|
Senior User
Joined: May 2010
Posts: 473
Likes: 0
FTE Stories
Ford Trucks for Ford Truck Enthusiasts
3 Best / 3 Worst Parts of Modern Ford Ownership
Brett Foote
10 Amazing Upgrades That Solve Common Ford Truck Owner Headaches
Pouria Savadkouei
Every 2026 Ford Engine Explained
Brett Foote
10 Ugly Ford Trucks That We Still Kinda Love
Joe Kucinski
10 Things Every Truck Owner NEEDS (2026 Edition)
Michael S. Palmer
Rezvani's Latest Post-Apocalyptic Monster Is a Ford F-150 Raptor Underneath
Verdad Gallardo
Top 10 Most Expensive Ford Trucks Ever Sold on Bring a Trailer
Joe Kucinski
2027 Ford Super Duty Buyer's Guide (Every Model, Engine, & Package)
Brett Foote
