Fulltext TSBs

Technical Service Bulletins

06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT
    REQUIREMENTS
06-6-5

  • WATER-IN-FUEL (WIF) LAMP ON
06-6-1

  • DIAGNOSTIC PROCEDURE FOR TRAILER TOW
    LIGHTS – SERVICE TIP
06-4-12

  • COKING DEPOSIT DIAGNOSTICS AND SERVICE
    TIPS – 6.0L DIESEL
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW
    FREON – SHAFT SEAL LEAKS
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY
    EYE – CHARGING SERVICE TIPS
06-3-8

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-2-13

  • WHITE SMOKE, LACKS POWER, EXHAUST
    ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L

05-26-25

  • MISFIRE, LACK OF POWER, BUCK/JERK,
    EXCESSIVE SMOKE, CRANK/NO START – 6.0L ENGINE –
    DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS

05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL
    RUNOUT
05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A
    STOP
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON
    PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH
    RUNNING
05-22-3

  • LOW POWER – COLD SIDE CHARGE AIR
    COOLER (CAC) DISCONNECTED – OIL LEAK AT CAC
    CONNECTIONS – 6.0L ENGINE – VEHICLES BUILT 4/1/2004
    THROUGH 2/20/2005
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY
    TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY
    DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR –
    6.0L
05-19-12

  • TURBO-INDUCED EXHAUST MOAN/DRONE AT
    1500-2000 RPM – 6.0L BUILT AFTER 9/29/2003

05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR
    WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING
    REPAIRS – SERVICE TIPS
05-17-16

  • DTC P0488 AND/OR P1334 WITH NO
    DRIVEABILITY SYMPTOMS, HARSH SHIFT AND/OR TRANSMISSION
    ENGAGEMENTS
05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS
    CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST
    MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW
    CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L
    ENGINE
05-13-16

  • FEAD BELT FRAYED/SHREDDED/BROKEN –
    6.0L DIESEL ENGINE – VEHICLES BUILT THROUGH 1/1/2005

05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR
    AXLE – 6.0L AND 7.3L DIESEL ENGINE

05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L
    ENGINE
05-13-5

  • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
    SIDE CHARGE AIR COOLER (CAC) DUCT – 6.0L DIESEL ENGINE

05-11-10

  • BUCK/JERK, SURGE, HESITATION – 5.4L OR
    6.8L ENGINES – MANUAL TRANSMISSION ONLY

05-11-5

  • VARIOUS DIRVEABILITY CONDITIONS – 6.0L
    DIESEL – VEHICLES BUILT BEFORE 9/30/2003

05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH
    AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION
    PROMOTER USAGE INSTRUCTIONS
05-9-1

  • STEERING GEAR NOISE – 5.4L AND 6.8L
    ENGINE – SINGLE REAR WHEEL
05-6-4

  • FALSE PARKING AID WARNINGS
05-5-7

  • LOW BATTERY VOLTAGE – SNOW PLOW
    EQUIPPED VEHICLES – 6.0L DIESEL WITH SINGLE GENERATOR

05-5-4

  • USE OF STAINLESS STEEL EXHAUST STUDS
    IN SERVICE FOR 5.4L 2V ENGINE
05-4-17

  • INTERMITTENT ROUGH IDLE –
    NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
05-3-6

  • 4X4 TRANSFER CASE JUMP OUT OF 4H OR 4L
    – MANUAL SHIFT TRANSFER CASE
04-25-16

  • MIL ILLUMINATED WITH DTC P0756, P0761
    OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005
    TORQSHIFT TRANSMISSION
04-24-22

  • LOSS OF POWER OR STUMBLE WHILE DRIVING
    IN RAIN – 6.8L ENGINE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL –
    LEATHER COMING LOOSE
04-23-9

  • WATER LEAK – ROOF FLANGE AREA – WATER
    ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
    PAN AREA
04-23-8

  • STEERING GEAR NOISE – 6.0L DIESEL
    ENGINE
04-23-6

  • VEHICLE LEAN/SAG WHEN OBSERVED FROM
    REAR OF VEHICLE
04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-18-6

  • DRIVEABILITY – NO START OR CONSTANT
    ENGINE MISFIRE – FUEL INJECTION CONTROL MODULE (FICM)
    DIAGNOSIS – 6.0L DIESEL
04-18-5

  • AXLE – FRONT HUBS NOT ENGAGING, NOT
    STAYING ENGAGED AND/OR UNLOCKING

04-17-13

  • HARD START OR NO START – GPCM
    CONNECTOR SERVICE KIT AVAILABLE – 6.0L ENGINE

04-17-4

  • MALFUNCTION INDICATOR LAMP (MIL)
    ILLUMINATED – SYSTEM LEAN DIAGNOSTIC TROUBLE CODES
    (DTC’S) – SERVICE TIPS
04-16-5

  • HIGH ENGINE RPM BETWEEN DOWNSHIFTS –
    LACK OF ENGINE BRAKING – 5.4L ENGINE AND MANUAL
    TRANSMISSION
04-16-4

  • REAR AXLE POPPING/CHATTER NOISE – DANA
    80 MODEL DUAL REAR WHEEL (DRW)
04-15-10

  • OVERHEAD TRIP COMPUTER (OTC) DISTANCE
    TO EMPTY (DTE) INCORRECT
04-14-12

  • FRONT END ACCESSORY DRIVE (FEAD) BELT
    NOISE – VEHICLES BUILT PRIOR TO 6/1/2004 – 6.0L ENGINE

04-13-8

  • 6.0L ENGINE – LOW RPM, BUCK/JERK,
    MISS, STUMBLE – AFTER DECELERATION DOWN LONG GRADE
    WITH THE CRUISE CONTROL ENGAGED
04-11-2

  • SUSPENSION – VEHICLE SWAY/LEAN DURING
    LOW SPEED TURNING MANEUVERS
  • NOISE – SUSPENSION – POPPING NOISE IN
    FRONT END
04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL –
    INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION

04-9-4

  • ENGINE – EXHAUST – TURBO-INDUCED
    EXHAUST MOAN/DRONE AT 1600-1800 RPM – 6.0L BUILT PRIOR
    TO 9/29/2003
  • NOISE – VIBRATION – TURBO-INDUCED
    EXHAUST MOAN/DRONE AT 1600-1800 RPM – 6.0L BUILT PRIOR
    TO 9/29/2003
04-9-3

  • DRIVEABILITY – RUNS ROUGH AND/OR LOW
    POWER – 6.0L DIESEL ENGINE ONLY
  • ENGINE – FUEL IN OIL – 6.0L DIESEL –
    INJECTOR DIAGNOSTICS
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS
    AND MOTOR REPLACEMENT – SERVICE TIPS

03-20-12

  • DRIVEABILITY – VARIOUS DRIVEABILITY
    CONDITIONS – 6.0L DIT ENGINE – VEHICLES BUILT BEFORE
    9/29/03 – CALIBRATION UPDATE – RUNNING CHANGE

03-20-10

  • DRIVEABILITY – FUEL SYSTEM – INJECTOR
    COMBUSTION SEAL – INSTALLATION PROCEDURE – SERVICE TIP
    – 6.0L ENGINE
  • ENGINE – FUEL SYSTEM – INJECTOR
    COMBUSTION SEAL – INSTALLATION PROCEDURE – SERVICE TIP
    – 6.0L ENGINE
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY
    (RKE) – SERVICE TIPS
03-17-4

  • STEERING – STEERING WHEEL FIGHT AFTER
    RIDING OVER BUMPS/RUTS
03-11-2

  • SUSPENSION – ON-VEHICLE FRONT
    INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
  • AXLE – ON-VEHICLE FRONT INTEGRATED
    HUB/BEARING ROCKING END-PLAY MEASUREMENT