Fulltext TSBs

Technical Service Bulletins

TSB
06-22-11
  • POWER STEERING FLUID LEAK AT JUMPER LINE TO HYDROBOOST CONNECTION – VEHICLES BUILT BEFORE 5/25/2006
Publication Date: October 24, 2006

FORD:
2005 Excursion
2005-2006 F-Super Duty

ISSUE:

Some 2005-2006 F-Super Duty vehicles built before 5/25/2006 and 2005 Excursions, equipped with a hydro boost brake system, may exhibit a power steering leak at the junction where the jumper line connects to the hydro boost unit.

ACTION:

Refer to the instructions in the Hose Assembly Kit to resolve this concern. Do not attempt to tighten the fitting to stop the leak.


PART NUMBERPART NAME
6C3Z-3F887-CHose Assembly Kit

WARRANTY STATUS:

Eligible Under Provisions Of New Vehicle Limited Warranty Coverage

OPERATIONDESCRIPTIONTIME
062211A2005-2006 F-Super Duty, 2005 Excursion With Hydroboost Brakes: Replace The Steering Jumper Line, Includes Time To Fill Power Steering Fluid0.7 Hr.

DEALER CODING

BASIC PART NO.CONDITION CODE
3N99942

NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.

Copyright 2006 Ford Motor Company