Fulltext TSBs

Technical Service Bulletins

TSB
11-1-5
  • RUNS ROUGH, HARD START AFTER REFUELING, AUDIBLE CLICKING NOISE UNDER HOOD, AND/OR DTCS P0316, P144A, P1450, P017X, P044X, P045X, BUILT ON OR BEFORE 11/1/2010
Publication Date: January 14, 2011

FORD:
2010-2011 Fusion
2009-2010 F-150
2009-2011 E-Series, Escape, Expedition
2011 F-250, F-350
LINCOLN:
2011 MKZ
2009-2011 Navigator
MERCURY:
2010-2011 Milan
2009-2011 Mariner

ISSUE:

Some 2009-2010 F-150, 2009-2011 Expedition, Navigator, E-Series, Escape Hybrid, Mariner Hybrid, 2010-2011 Fusion Hybrid, Milan Hybrid, 2011 MKZ Hybrid and F-Super Duty 250/350 equipped with a 6.2L enigne and built on or before 11/1/2010, may exhibit a running rough concern, hard start after refueling, audible clicking noise under the hood and/or diagnostic trouble codes (DTCs) P0316, P144A, P1450, P017X, P044X, P045X.

ACTION:

Follow the Service Procedure to correct the condition.

SERVICE PROCEDURE

Replace the Evaporative Emission Canister Purge Valve. Refer to Workshop Manual, Section 303-13.

PART NUMBERPART NAME
9L3Z-9E730-CCanister Purge Valve (2009-2010 F150 5.4L/2009-2011 Expedition/Navigator)
9L3Z-9E730-FCanister Purge Valve (2009-2010 F160 4.6L 2V)
9L3Z-9E730-GCanister Purge Valve (2009-2010 F150 4.6L 3V)
9C2Z-9C915-CCanister Purge Valve (2009-2011 Econoline 4.6L)
9C2Z-9C915-ACanister Purge Valve (2009-2011 Econoline 5.4L)
9C2Z-9C915-ECanister Purge Valve (2009-2011 Econoline 6.8L)
9U5Z-9C915-BECanister Purge Valve (2009-2011 Escape/Mariner 2.5L Hybrid/2010-2011 Fusion/ Milan/MKZ 2.5L hybrid/2010-2011 F150 6.2L/2011 F-250/F-250 6.2L)

WARRANTY STATUS:

Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.

OPERATIONDESCRIPTIONTIME
110105A2009-2011 Expedition, Navigator, And Econoline 2009-2010 F-150: Check DTCs, And Replace The Evaporative Emission Canister Purge Valve (Do Not Use With Any Other Labor Operations)0.6 Hr.
110105A2009-2011 Escape Hybrid, Mariner Hybrid, 2010-2011 Fusion Hybrid, Milan Hybrid, 2011 MKZ Hybrid, And 2011 F-Super Duty 6.2L: Check DTCs, And Replace The Evaporative Emission Canister Purge Valve (Do Not Use With Any Other Labor Operations)0.7 Hr.
110105A2009-2011 Econoline: Check DTCs, And Replace The Evaporative Emission Canister Purge Valve (Do Not Use With Any Other Labor Operations)0.9 Hr.

DEALER CODING

BASIC PART NO.CONDITION CODE
9C91542

NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources.

Copyright © 2011 Ford Motor Company