Fulltext TSBs

Technical Service Bulletins

TSB
10-25-7
  • 6.2L ENGINE – ENGINE TICK NOISE WITH ENGINE MISFIRE CODES P030X/P0316 – BUILT 1/18/2010 THRU 9/7/2010
Publication Date: December 16, 2010

FORD:
2010 F-150
2011 F-250, F-350

ISSUE:

Some 2010 F-150 Raptor and 2011 F-Super Duty 250/350 vehicles equipped with a 6.2L engine and built 1/18/2010 through 9/7/2010 may exhibit an engine tick noise accompanied with engine misfire codes P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 and/or P0316.

ACTION:

Follow the Service Procedure steps to correct the condition.

SERVICE PROCEDURE

  1. Inspect the coil-on-plugs and/or ignition wires. Refer to Workshop Manual (WSM), Section 303-07A.
    1. If any coil-on-plugs wires and/or ignition wires were disconnected, reinstall and confirm noise is resolved.
    2. If coil-on-plugs and/or ignition wires are not source of noise, proceed to Step 2.
  2. Remove RH/LH valve covers. Refer to WSM, Section 303-10A.3.
  3. Inspect RH/LH rocker shaft rollers for signs of surface deformation or fatigue. (Figure 1)


    Figure 1 – Article 10-25-7

    1. If damage is found, replace RH and/or LH rocker shaft. Refer to WSM, Section 303-01A4.
  4. Inspect RH/LH camshaft lobes for damage.
    1. If damage is found, replace RH and/or LH camshaft. Refer to WSM, Section 303-01A.

PART NUMBERPART NAME
AL3Z-6564-BRocker Shaft Asy LH Exhaust
AL3Z-6564-CRocker Shaft Asy LH Intake
AL3Z-6564-DRocker Shaft Asy RH Exhaust
AL3Z-6564-ERocker Shaft Asy RH Intake
AL3Z-6250-DCamshaft RH Raptor
AL3Z-6250-CCamshaft LH Raptor
BC3Z-6250-BCamshaft LH
BC3Z-6250-CCamshaft RH

WARRANTY STATUS:

Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.

OPERATIONDESCRIPTIONTIME
102507A2011 F-Super Duty 250/350 6.2L: Inspect Coil On Plug And Wires For Correct Installation, Repair As Necessary (Do Not Use With Any Other Labor Operations)0.7 Hr.
102507B2011 F-Super Duty 250/350 6.2L: Inspect Coil On Plug And Wires For Correct Installation, Repair As Necessary, Concern Still Present, Replace One Or Both Rocker Shaft(s) On One (1) Cylinder Head (Do Not Use With Any Other Labor Operations)2.8 Hrs.
102507C2011 F-Super Duty 250/350 6.2L: Inspect Coil On Plug And Wires For Correct Installation, Repair As Necessary, Concern Still Present, Replace One Or Both Rocker Shaft(s) On Both Cylinder Head (Do Not Use With Any Other Labor Operations)3.3 Hrs.
102507D2011 F-Super Duty 250/350 6.2L: Inspect Coil On Plug And Wires For Correct Installation, Repair As Necessary, Concern Still Present, Replace One (1) Cam Shaft (Do Not Use With Any Other Labor Operations)7.4 Hrs.
102507E2011 F-Super Duty 250/350 6.2L: Inspect Coil On Plug And Wires For Correct Installation, Repair As Necessary, Concern Still Present, Replace Both Cam Shafts (Do Not Use With Any Other Labor Operations)7.9 Hrs.
MT1025072010 F-150 Raptor 6.2L: Claim As Actual Time Actual Time

DEALER CODING

BASIC PART NO.CONDITION CODE
625030

NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources.

Copyright © 2010 Ford Motor Company