Fulltext TSBs

Technical Service Bulletins

07-4-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
07-7-2

  • REAR OF VEHICLE IS TOO HIGH/LOW – 5TH WHEEL AND GOOSE NECK APPLICATIONS – 4X4 VEHICLES ONLY
07-7-7

  • 6.4L – EXHAUST SMOKE FROM FRONT OF VEHICLE – EXHAUST ODOR INSIDE VEHICLE
07-9-1

  • 2008 F-SUPER DUTY- LIGHTING ON SNOW PLOW EQUIPPED VEHICLES – BUILT BEFORE 04/18/2007
07-10-5

  • FRONT DOOR SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW MOLDING
07-11-5

  • DIESEL ENGINE – OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE
07-11-10

  • BRAKE PEDAL KICKBACK OR GRABBING
07-12-8

  • SERVICE TIP – CAGE NUT SPINNING – CAB OFF SERVICE PROCEDURE
07-16-6

  • LIGHTING ON AMBULANCE PACKAGES (US ONLY)
07-19-2

  • 5.4L AND 6.8L – SRW – POWER STEERING PUMP NOISE, LEAK, OR HOT FLUID
07-20-7

  • MOAN/DRONE AT 1500-2000 RPM – DANA 80 DUAL REAR WHEEL AXLE
07-23-9

  • 6.4L DIESEL – COLD WEATHER BELT CHIRP
07-23-17

  • ENGINE KNOCK ON 6.8L 3V ENGINES WITH ENGINE BUILD DATES BETWEEN 6/26/2007 AND 8/30/2007
07-24-8

  • ENGINE MISFIRE DURING CRUISE WITH OR WITHOUT DTCS (MEXICO ONLY)
07-24-2

  • 6.4L ENGINE BUILT BEFORE 06/18/2007 – HEATER CORE NOISE – ALSO DESCRIBED AS GURGLING, RATTLE, OR SCRAPING NOISE
07-25-2

  • TAILGATE STRIKER – NOISE/RATTLE
07-26-2

  • 6.4L – INTERMITTENT NO START / LACK OF POWER – DTC P0003 AND/OR BLOWN FUSE 74 – BUILT PRIOR – 8/20/2007
07-26-5

  • BLOWER MOTOR INOPERATIVE OR STUCK ON HIGH
08-2-3

  • 6.4L – CHARGE AIR COOLER (CAC) PAINT PROCEDURE – BUILT BEFORE 8/1/2007
08-3-9

  • WHEEL LIP MOULDINGS LOOSE/WARPED (EXCLUDES KING RANCH) – BUILT BEFORE 10/5/2007
08-4-9

  • ASH TRAY BROKEN OR LOOSE – BUILT BEFORE 09/17/2007
08-5-1

  • SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS), MAY NOT SEEK ALL SIRIUS SATELLITE RADIO CHANNELS
08-5-3

  • AXLE WHINE NOISE BETWEEN 50-60 MPH (80-97 KM/H) – WIDE FRAME WITH PICKUP BOX – DANA S110
08-5-14

  • 6.4L – DTC P0528 AND/OR P0529
08-7-6

  • SPARK PLUG REMOVAL INSTRUCTIONS – 4.6L 3V/5.4L 3V/6.8L 3V
08-11-5

  • POWER WINDOW NOISE – BUILT BEFORE 7/31/2007
08-12-6

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
08-12-9

  • INOPERATIVE RKE TRANSMITTER (KEY FOB) – DISCHARGED KEY FOB BATTERY
08-12-10

  • CONTAMINATED POWER STEERING FLUID – APPEARANCE – STRAWBERRY MILK SHAKE
08-14-4

  • LACK OF HEAT WHEN – SNOWPLOW AND/OR WINTER GRILL COVER – EATC EQUIPPED VEHICLES ONLY
08-15-3

  • UNIQUE STEERING GEAR/PITMAN ARM ASSEMBLY
08-16-2

  • 6.4L – VEHICLES BUILT BEFORE 4/23/2007 – ELECTRONIC THROTTLE CONTROL PEDAL REPLACEMENTS
08-16-6

  • MANUAL TRANSMISSION – DIFFICULT TO SHIFT COLD – 0 TO 40 DEGREES F (-18 TO 4 DEGREES C)
08-16-7

  • CYLINDER CONTRIBUTION DIAGNOSTICS – 6.4L DIESEL ENGINE – SERVICE TIP
08-19-7

  • A/C SLOW TO COOL – DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) – BUILD DATE BEFORE 6/28/2007
08-23-10

  • DUAL REAR WHEEL (DRW) REAR FENDER SIDE MARKER LAMPS LOOSE
08-24-2

  • VIBRATION DIAGNOSTICS – STEERING WHEEL NIBBLE – TIRE WHEEL RUNOUT AND BALANCE
08-24-8

  • WATER LEAKS – ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH
08-25-1

  • 6.4L DIESEL – WHITE SMOKE IN DAMP WEATHER CONDITIONS WHEN ACCELERATING – VEHICLES BUILT BEFORE 10/1/2008
08-26-4

  • 5R110W COLD WEATHER TRANSMISSION FAILURE IN VEHICLES BUILT BETWEEN 5/18/2007 AND 11/1/2008
09-4-1

  • A/C COMPRESSOR THUMP UPON ENGAGEMENT – BUILT BEFORE 07/20/2007
09-7-8

  • COMPASS INTERMITTENTLY LOSES CALIBRATION – BUILD BEFORE 3/1/2009
09-7-12

  • 5.4L AND 6.8L GAS ENGINE CALIBRATION UPDATE
09-8-5

  • DIESEL COOLANT MAINTENANCE – SERVICE TIPS
09-9-1

  • WIRING FAULT ON TRAILER DISPLAYED IN MESSAGE CENTER – DTC C2806
09-9-8

  • 6.4L DIESEL – COLD WEATHER BELT CHIRP
09-10-12

  • 6.4L DIESEL ENGINE – LACKS POWER, LEAKS FLUID FROM EXHAUST PIPE, ABNORMAL TAILPIPE SEDIMENT, WHITE SMOKE, EXHAUST SMELL AND MIL ON
09-11-16

  • SEAT SIDE TRIM PANEL – LOOSE / BROKEN / CRACKED – BUILT BEFORE 8/1/2008
09-12-1

  • EXTERIOR DOOR HANDLE LOOSE – BUILT BEFORE 11/1/2008
09-12-15

  • LARGE TEMPERATURE DIFFERENCES – BUILD BEFORE 11/6/2008
09-15-11

  • SLIDING POWER WINDOW (BACK GLASS) INOPERATIVE OR BINDING – BUILT BEFORE 6/20/2009
09-16-2

  • 6.4L DIESEL ENGINE TICKING/TAPPING NOISE
09-16-9

  • 6.4L – VEHICLES BUILT PRIOR TO 8/2/2007 – MODULE REPROGRAMMING
09-18-15

  • 6.4L – VEHICLES BUILT BETWEEN 1/3/2008 AND 9/15/2008 – DTCS P0128, P0196, P1335, P0404, P0406, P246C AND P2463
09-19-10

  • 6.4L – VEHICLES BUILT BETWEEN 8/3/2007 AND 1/2/2008 – MODULE REPROGRAMMING
09-20-5

  • SHUDDER OR VIBRATION ON ACCELERATION – ESPECIALLY WHEN LOADED
09-20-10

  • SPEAKER POP AND/OR RADIO INOPERATIVE/BLANK/LOCKED UP
09-20-12

  • SLOW FUEL FILL – 5.4 AND 6.8 ENGINES
09-22-1

  • 4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES
09-22-8

  • STAINLESS STEEL EXHAUST STUDS – 5.4L AND 6.8L 2V ENGINES
09-23-1

  • 6.4L DIESEL ENGINES – REPEAT RADIATOR LEAK – BUILT ON OR BEFORE 9/14/2009
09-26-7

  • 5.4L / 4.0L – DTC P0607
10-1-6

  • 5.4L ENGINE – DIAGNOSTIC TROUBLE CODE (DTC) P2135
10-1-11

  • 4X4 ONLY – BANGING/CLUNKING NOISE WHEN DRIVING – CONTACT WITH JOUNCE BUMPER – COLD TEMPERATURES
10-2-2

  • 6.4L AIR INDUCTION SYSTEM RESTRICTION – SNOW