Fulltext TSBs

Technical Service Bulletins

05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A STOP
05-23-3

  • REAR AXLE NOISE REPAIR
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-5-4

  • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
05-4-17

  • INTERMITTENT ROUGH IDLE – NON-COMMANDED EGR FLOW
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-20-6

  • TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS
04-18-11

  • BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE – REPAIR PROCEDURE
04-5-7

  • BODY – FRONT WINDOW(S) – POP/THUMP NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER’S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT – SERVICE TIPS
03-21-27

  • FUEL SYSTEM – 7.3L DIRECT INJECTION (DI) TURBO DIESEL – NO RETURN FUEL FLOW TO FUEL TANK – BEGINNING WITH VEHICLES BUILT 2/9/94
  • LOW PERFORMANCE/LACK OF POWER – 7.3L DIRECT INJECTION (DI) TURBO DIESEL – NO RETURN FUEL FLOW TO FUEL TANK – BEGINNING WITH VEHICLES BUILT 2/9/94
03-21-25

  • WIRING – AFTERMARKET WIRING ALTERATIONS – SERVICE TIP
03-21-23

  • DRIVEABILITY – LOW RPM – NO START – RUNS POORLY – STALL – 7.3L DIT ENGINE
03-21-21

  • LEAK – OIL LEAK AT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP – VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE
03-21-20

  • ENGINE – 7.3L DIT – GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE – SERVICE TIP
03-20-6

  • DRIVEABILITY – DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES – 4.6L AND 5.4L ENGINE – ROUGH IDLE, HARD START OR NO START WHEN COLD – LOSS OF POWER – LEAN FUEL DTC’S – RESTRICTED CATALYTIC CONVERTER
  • ENGINE – DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES – 4.6L AND 5.4L ENGINE – ROUGH IDLE, HARD START OR NO START WHEN COLD – LOSS OF POWER – LEAN FUEL DTC’S – RESTRICTED CATALYTIC CONVERTER
03-20-3

  • DRIVEABILITY – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
03-18-3

  • DRIVEABILITY – DEDICATED COMPRESSED NATURAL GAS (CNG) – ROUGH IDLE OR NO START WHEN COLD – VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY (RKE) – SERVICE TIPS
03-15-13

  • STEERING – TIE ROD END INSPECTION PROCEDURE
03-14-8

  • TRANSMISSION – NEW TRANSMISSION COOLER FLUSHER – SERVICE TIPS
03-10-3

  • DRIVEABILITY – BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
  • DRIVEABILITY – CRANK NO START – BI-FUEL CNG/LPG VEHICLES – LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
03-10-2

  • DRIVEABILITY – COMPRESSED NATURAL GAS (CNG) – ROUGH IDLE OR NO START WHEN COLD – VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
03-4-2

  • FUEL – BI-FUEL – CNG FUEL LEAK AT FILL VALVE – E-SERIES AND F-SERIES CNG FILL VALVE – REVISED SERVICE PARTS
02-22-1

  • DRIVEABILITY – SURGE/ROLLING IDLE – GEAR DRIVEN SYNCHRONIZERS – INCORRECT INSTALLATION – CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
  • ENGINE – GEAR DRIVEN SYNCHRONIZERS – INCORRECT INSTALLATION – CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
02-21-13

  • ENGINE – STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
02-21-11

  • RIDE – HARSH RIDE – CAB/BODY OSCILLATION/BOUNCE – HIGHWAY SPEEDS – 4X2 MODELS ONLY
02-21-4

  • ROOF DITCH MATERIAL CRACKING – SERVICE TIPS
02-21-1

  • TRANSMISSION – 4R100/E4OD – TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
02-19-3

  • DRIVEABILITY – IDLE – HIGH IDLE SPEEDS – THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES – VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
  • 4.6L – IDLE – HIGH IDLE SPEEDS – THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES – VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
02-17-6

  • LAMP – BRAKE – INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
02-16-4

  • FUEL SYSTEM – FUEL PUMP “WHINING”/”BUZZING” NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER
  • RADIO – ENTERTAINMENT OR TWO-WAY COMMUNICATION – “WHINING”/”BUZZING” NOISE IN SPEAKERS CAUSED BY FUEL PUMP
  • NOISE – “WHINING”/”BUZZING” – COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
02-11-4

  • ENGINE – NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
02-3-5

  • BODY – “SQUEAK” OR BIND FROM TAILGATE
  • NOISE – “SQUEAK” OR BIND FROM TAILGATE
02-1-9

  • ENGINE – ENGINE OIL – RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS – GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
01-24-6

  • ENGINE – ENGINE OIL SYSTEM PRIMING
    PROCEDURES – SERVICE TIPS
01-23-6

  • ENGINE COOLANT – PROPYLENE GLYCOL – FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL
  • ENGINE COOLANT – PROPYLENE GLYCOL-BASED – FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
01-21-8

  • DRIVEABILITY – NO CRANK, NO START – CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID
  • STARTING – NO CRANK, NO START – CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID
01-21-6

  • ELECTRICAL – REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
01-21-5

  • IDLE – HIGH IDLE SPEEDS – THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES – VEHICLES BUILT THROUGH 11/01/01 EQUIPPED WITH 5.4L ENGINE
  • ENGINE – 5.4L – PCV SYSTEM ICING – VEHICLES BUILT THROUGH 11/01/01
01-20-1

  • IDLE – HIGH IDLE AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES – VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000
  • ENGINE – 4.2L – PCV SYSTEM ICING – AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES – VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000
01-19-2

  • BRAKES – REAR DRUM – GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
01-18-2

  • BODY – COSMETIC CRACK IN OUTER DOOR PANEL – LOWER REAR CORNER OF WINDOW OPENING – INSPECTION AND REPAIR PROCEDURE
01-16-6

  • LAMP – 4X4 “LOW RANGE” LIGHT DIMLY LIT
  • SWITCHES – TRANSFER CASE MODE SWITCH – 4X4 HI/LOW SWITCH SHORTED OUT
  • WINDSHIELD WIPERS – INTERMITTENT WIPERS ERRATIC OR INOPERABLE
  • TRANSFER CASE – WATER PRESENT IN TRANSFER CASE
01-15-6

  • CLIMATE CONTROL – REPEAT HEATER CORE
    FAILURE
  • COOLING SYSTEM – REPEAT HEATER CORE
    FAILURE
01-15-2

  • DRIVEABILITY – BI-FUEL – NO START IN BI-FUEL MODE – ALT FUEL LIGHT ON – VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY
01-10-12

  • WIRING – WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
01-10-11

  • DRIVEABILITY – BI-FUEL COMPONENT IDENTIFICATION CHART – BI-FUEL ENGINES ONLY
01-10-6

  • DRIVEABILITY – BI-FUEL – COMPUVALVE PRE-REPLACEMENT CHECK LIST – SERVICE TIPS
01-9-7

  • DRIVEABILITY – HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS – SERVICE TIPS – OBD II VEHICLES ONLY
01-9-3

  • VIBRATION – FROM DRIVELINE – 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE
  • TRANSMISSION – 4R70W – FLUID LEAK FROM EXTENSION HOUSING SEAL – 4X2 VEHICLES WITH 139 INCH WHEELBASE
01-8-7

  • DRIVEABILITY – BI-FUEL – INTERMITTENT STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS – IN BI-FUEL OR GASOLINE MODE – BI-FUEL VEHICLES ONLY
01-7-4

  • DRIVEABILITY – BI-FUEL VEHICLE COMMUNICATION LINK (VCL) AND ALTERNATIVE FUEL CONTROL MODULE (AFCM) TERMINOLOGY CLARIFICATION – BI-FUEL VEHICLES ONLY
01-1-11

  • WATER LEAK – SLIDING REAR WINDOW – VEHICLES BUILT THROUGH 4/1999
00-26-1

  • ENGINE – ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) – VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
  • NOISE – FROM ENGINE – ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) – VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
00-23-10

  • TRANSMISSION – FLUID IN-LINE FILTER KIT – REPEAT REPAIRS OF TRANSMISSION – SERVICE TIPS
00-23-9

  • DRIVEABILITY – COMPUVALVE REPLACEMENT PROCEDURE – SERVICE TIP – BI-FUEL VEHICLES ONLY
  • ELECTRICAL – COMPUVALVE REPLACEMENT PROCEDURE – SERVICE TIP – BI-FUEL VEHICLES ONLY
  • ENGINE – COMPUVALVE REPLACEMENT PROCEDURE – SERVICE TIP – BI-FUEL VEHICLES ONLY
00-23-8

  • DRIVEABILITY – NO CRANK/NO START – MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F)
  • ELECTRICAL – NO CRANK/NO START – MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F)
00-9-5

  • INNER FENDER WELL – DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL
00-9-1

  • LEAK – TRANSMISSION FLUID LEAKS AT RADIATOR – VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK
00-6-11

  • CALIBRATION – RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT – SERVICE TIP – ALTERNATE FUEL VEHICLES ONLY
00-1-7

  • DETONATION – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY – VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
  • HESITATION/STUMBLE – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY – VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
  • MALFUNCTION INDICATOR LAMP (MIL) – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY – VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
  • ROUGH IDLE – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY – VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
  • STALL/NEAR STALL – AT IDLE AND/OR LOW SPEEDS – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY – VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY – VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
99-25-6

  • BRAKES – INCORRECT ROTOR THICKNESS STAMPED ON ROTOR – F-150 4X2 ONLY
  • BRAKES – INCORRECT WORKSHOP MANUAL ROTOR DISCARD THICKNESS SPECIFICATION
99-24-2

  • LOCKS – REPLACE AND/OR REPAIR ANY LOCK COMPONENT – AVAILABILITY OF INDIVIDUAL LOCKS
99-23-4

  • MALFUNCTION INDICATOR LAMP (MIL) – DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 – NO DRIVEABILITY CONCERNS
99-20-7

  • COOLING SYSTEM – 3.8L – UNDETERMINED LOSS OF COOLANT
  • COOLING SYSTEM – 4.2L – UNDETERMINED LOSS OF COOLANT
  • ENGINE – 3.8L – ENGINE OIL CONTAMINATED WITH COOLANT
  • ENGINE – 4.2L – ENGINE OIL CONTAMINATED WITH COOLANT
99-18-8

  • INDUCTION BACKFIRE – ON ACCELERATION – ALL AMBIENT TEMPERATURES – VEHICLES WITH 4.2L ENGINE – CANADIAN VEHICLES ONLY
99-18-5

  • TRANSMISSION CONTROL INDICATOR LAMP (TCIL) – TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0782 STORED IN MEMORY – VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION
  • TRANSMISSION – 4R70W – DELAYED OR NO 2-3 UPSHIFT – VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998
99-16-4

  • IGNITION KEY – HARD TO REMOVE FROM IGNITION CYLINDER
  • IGNITION KEY – HARD TO TURN
99-15-2

  • TRANSMISSION – NEW TRANSMISSION FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA
99-14-4

  • NOISE – “MOANING” AT 1100 RPM WITH A/C COMPRESSOR ENGAGED – VEHICLES WITH 4.2L ENGINE
99-14-3

  • NOISE – “MOANING” FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE – VEHICLES BUILT THROUGH 4/15/1999
  • AXLE – “MOANING” NOISE FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE – VEHICLES BUILT THROUGH 4/15/1999
99-13-13

  • ANTI-LOCK BRAKE SYSTEM (ABS) – ABS LAMP ILLUMINATED – 4X2 ONLY
  • ANTI-LOCK BRAKE SYSTEM (ABS) – FALSE ABS CYCLING AT LOW SPEEDS – 4X2 ONLY
  • ANTI-LOCK BRAKE SYSTEM (ABS) – INCREASED BRAKE PEDAL EFFORT AT LOW SPEEDS – 4X2 ONLY
  • LAMP – ANTI-LOCK BRAKE LAMP ILLUMINATION – INCREASED BRAKE PEDAL EFFORT AND/OR FALSE ABS CYCLING AT LOW SPEEDS – 4X2 ONLY
99-12-8

  • AIR CONDITIONING – “WHISTLING” NOISE HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
  • NOISE – “WHISTLING” HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
99-11-1

  • NOISE – TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
  • VIBRATION – TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
99-8-15

  • INTERIOR TRIM – DOOR TRIM PANEL REPLACEMENT – SERVICE TIP
99-6-5

  • WINDNOISE – AROUND SIDE DOOR(S) – SERVICE TIPS
99-5-4

  • FRAME – FRAME SERVICE KITS – NEW SERVICE PARTS RELEASED FOR REPAIRING FRAME DAMAGE
99-5-3

  • TRANSMISSION – CHECKING TRANSMISSION FLUID LEVEL COLD – SERVICE TIP
99-4-3

  • REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS) – OUT-OF-VEHICLE – EEC V VEHICLES ONLY
99-3-2

  • TRANSMISSION – M5OD – VEHICLE WILL NOT GO INTO REVERSE – VEHICLES BUILT THROUGH 11/1/1998
99-2-3

  • WATER LEAKS – WINDSHIELD SEALING – SERVICE TIP
  • WINDSHIELD – SEALING – SERVICE TIP
99-2-2

  • NOISE – “BUZZING” – UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION
98-26-6

  • ROOF – DEPRESSION IN ROOF – REARWARD OF FRONT DOORS – SUPERCAB ONLY
98-26-2

  • FUEL – INFORMATION ON GASOLINE – TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
98-25-9

  • INTERIOR TRIM – REPAIRS TO VINYL COVERED SURFACES – SERVICE TIP
98-24-6

  • ELECTRICAL – NEW TERMINAL GREASE RELEASED FOR SERVICE
98-23-25

  • MALFUNCTION INDICATOR LAMP (MIL) – MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0455 STORED IN MEMORY – VEHICLES BUILT THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L ENGINE
  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) – MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0455 STORED IN MEMORY – VEHICLES BUILT THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L ENGINE
98-23-12

  • TRANSMISSION – 4R44E – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
  • TRANSMISSION – 4R55E – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
  • TRANSMISSION – 4R70W – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
  • TRANSMISSION – 5R55E – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
  • TRANSMISSION – AX4N – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
  • TRANSMISSION – AX4S – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
  • TRANSMISSION – E4OD – DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
98-23-10

  • MASS AIR FLOW (MAF) – SENSOR CONTAMINATION – SERVICE TIP
98-23-1

  • GENERIC ELECTRONIC MODULE (GEM) – WATER INTRUSION INTO GEM MODULE – SERVICE TIP
98-21-21

  • IDLE – FAST IDLE SPEED AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY – VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
  • MALFUNCTION INDICATOR LAMP (MIL) – MIL ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY – VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY – VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
98-21-17

  • BRAKES – PARKING BRAKE CONTROL RUBBER BUMPER STOP – SERVICE PART NOW AVAILABLE
98-21-10

  • IDLE – HIGH IDLE SPEEDS – THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES – VEHICLES BUILT THROUGH 12/1/97 EQUIPPED WITH 4.6L ENGINE
98-20-10

  • EXHAUST SYSTEM – LOOSE CATALYST OR MUFFLER HEAT SHIELDS
  • NOISE – “BUZZING” OR “RATTLING” – LOOSE CATALYST OR MUFFLER HEAT SHIELDS
98-18-2

  • PAINT – EXTERIOR – WORLDWIDE RECOMMENDED PAINT MATERIALS FOR WARRANTY AND AFTER WARRANTY REPAIRS
98-16-18

  • FLOOR MAT – INSTALLATION OF VINYL FLOOR MATS – SERVICE TIP
98-16-17

  • FLOOR MAT – PRODUCTION FLOOR MAT INSTALLATION PROCEDURE – SERVICE TIP
98-16-12

  • FUEL SYSTEM – FUEL LEAKING FROM SPRING LOCK COUPLINGS AT FUEL RAIL – AMBIENT TEMPERATURES BELOW -40 DEGREES CELSIUS (-40 DEGREES FAHRENHEIT)
98-16-10

  • SEAT – SEAT BACK RECLINER INOPERATIVE – MEMORY LATCH DOES NOT ENGAGE
98-16-9

  • STEERING – ALIGNMENT – TOE SET PROCEDURE – SERVICE TIP
98-16-8

  • TRANSMISSION – E4OD/4R100 – 1989-99 – MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART
98-15-17

  • SEAT – CHILD TETHER KIT FOR INSTALLING CHILD SEAT IN REAR SEAT – SUPER CAB VEHICLES
  • CHILD TETHER KIT – SERVICE TIP FOR INSTALLING CHILD SAFETY SEAT IN REAR SEAT – SUPER CAB VEHICLES
98-14-5

  • STEERING – “CLUNKING” FELT WHILE ROCKING STEERING WHEEL SIDE-TO-SIDE
98-12-12

  • HEATER – “MOAN” AT 1400-1800 RPM OR “HOOTING” NOISE HEARD AT 1200-2000 RPM ACCELERATION OR DECELERATION – VEHICLES WITH 4.6L ENGINE
  • NOISE – “MOAN” AT 1400-1800 RPM OR “HOOTING” AT 1200-2000 RPM ACCELERATION OR DECELERATION – VEHICLES WITH 4.6L ENGINE
98-12-5

  • AIR CONDITIONING – FILTERING REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT – SERVICE TIPS
98-10-15

  • NOISE – “BUZZING” NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS – VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD OR 4R100 TRANSMISSION AND “MANUAL SHIFT-ON-THE-FLY,” AND 5.4L ENGINE
  • TRANSMISSION – E4OD OR 4R100 – NOISE – “BUZZING” NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS – VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD AND 4R100 TRANSMISSION AND “MANUAL SHIFT-ON-THE-FLY,” AND 5.4L ENGINE
98-9-20

  • TRANSMISSION – E4OD – 4-1 DOWNSHIFT DURING A FORCED 4-2 DOWNSHIFT BETWEEN 88-105 KM/H (55-65 MPH) – VEHICLES BUILT THROUGH 12/22/97
98-9-15

  • BRAKES – 4WABS – ABS LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL – VEHICLES BUILT THROUGH 2/12/98
  • LAMP – ABS LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL – VEHICLES BUILT THROUGH 2/12/98
98-9-13

  • WATER LEAKS – VARIOUS AREAS OF VEHICLE
  • ELECTRICAL – ACCESSORIES FUNCTIONING IMPROPERLY DUE TO WATER LEAKS
  • LAMPS – WARNING LAMPS ILLUMINATED DUE TO WATER LEAKS
98-9-9

  • FUEL INJECTORS – NON-WARRANTY REIMBURSEMENT TESTING INFORMATION
98-8-10

  • TRAILER WIRING – CONVERTING A 4-WAY TRAILER CONNECTOR SYSTEM TO A 7-WAY HEAVY DUTY SYSTEM – SERVICE TIP
98-6-13

  • AIR CONDITIONING – COLD AIR FELT ON PASSENGER SIDE FLOOR WHILE IN HEAT MODE – F-SERIES AND EXPEDITION WITHOUT CONSOLE BLOWER OPTION – VEHICLES BUILT THROUGH 8/31/97
98-6-11

  • HESITATION/SURGE – INCORRECT AIR CLEANER AND MASS AIR FLOW (MAF) SENSOR
  • MALFUNCTION INDICATOR LAMP (MIL) – MIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171 AND/OR P0174 STORED IN MEMORY
  • REDUCED POWER – INCORRECT AIR CLEANER AND MASS AIR FLOW (MAF) SENSOR
  • STALL – INCORRECT AIR CLEANER AND MASS AIR FLOW (MAF) SENSOR
  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) – MIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171 AND/OR P0174 STORED IN MEMORY
98-5A-11

  • BRAKES – ELIMINATION OF SANDING ROTORS AND DRUMS – SERVICE TIP
98-5A-5

  • BRAKES – AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
  • BRAKE ROTOR MACHINING – AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
98-5A-4

  • BRAKES – PREVENTING BRAKE VIBRATION – SERVICE TIP
  • WHEELS – PROPER LUG TORQUE PROCEDURES – SERVICE TIP
98-5-8

  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – DIAGNOSTIC TROUBLE CODE (DTC) P0503 STORED IN MEMORY – 4X4 VEHICLES ONLY
  • TRANSMISSION – SHIFT CONCERNS AND/OR ERRATIC SPEEDOMETER OPERATION – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – 4X4 VEHICLES ONLY
98-5-2

  • TIRE – TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE
98-3-18

  • DEFROSTER – PERFORMANCE ENHANCEMENT
98-1-13

  • BUMPER – RUST STAIN – EDGES OF CENTER VENT AND FOG LAMP OPENINGS
97-26-19

  • HESITATION/SURGE – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED IN MEMORY – VEHICLES BUILT THROUGH 11/97
  • MALFUNCTION INDICATOR LAMP (MIL) – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED – VEHICLES BUILT THROUGH 11/97
  • ROUGH IDLE – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED IN MEMORY – VEHICLES BUILT THROUGH 11/97
  • STALL – LOW SPEEDS AND OR IDLE – MIL ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 IN MEMORY – VEHICLES BUILT THROUGH 11/97
  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED – VEHICLES BUILT THROUGH 11/97
97-26-13

  • WHEELS – RIGHT REAR WHEEL AND WHEEL COVER DISCOLORED AND/OR PITTED FROM EXHAUST
  • EXHAUST – EXHAUST FLOWS ON RIGHT REAR WHEEL – RIGHT REAR WHEEL AND/OR WHEEL COVER DISCOLORED AND/OR PITTED
97-25-8

  • RUNS ROUGH – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY – VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE
  • LAMP – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY – VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE
  • ENGINE – ROLLER FINGER FOLLOWERS DISLODGE – DURING AMBIENT TEMPERTURES LESS THAN -18 DEGREES C (0 DEGREES F) – VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE
97-25-5

  • BLOWER MOTOR – “CHIRPING” OR “SQUEAKING” FROM BLOWER MOTOR AT LOW SPEEDS
  • NOISE – “CHIRPING” OR “SQUEAKING” FROM BLOWER MOTOR AT LOW SPEEDS
97-24-23

  • STALL – ENGINE STALL DURING TRANSMISSION ENGAGEMENT – VEHICLES EQUIPPED WITH E4OD TRANSMISSION
  • TRANSMISSION – E4OD – ENGINE STALL DURING ENGAGEMENT
97-24-21

  • IDLE – ROLLING IDLE SPEED – VEHICLES OVER 8500 LBS EQUIPPED WITH 5.8L ENGINE
97-24-13

  • REMOTE KEYLESS ENTRY (RKE) – DIAGNOSTIC SERVICE TIPS
97-23-13

  • TRANSMISSION – E4OD – NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING – TRANSMISSIONS BUILT AFTER 7/24/97
97-22-17

  • CLUTCH – HARD TO DISENGAGE OR FREQUENT REPLACEMENT OF CLUTCH SLAVE CYLINDER – EARLY WEAR-OUT OF SLAVE CYLINDER
97-22-7

  • WHEEL – HUB O-RING – SERVICE TIP
97-22-1

  • DELTA PRESSURE FEEDBACK EGR (DPFE) – DIAGNOSTIC TIPS
97-20-15

  • DRIVESHAFT – U-JOINT – AVAILABILITY OF GREASEABLE SERVICE PARTS
  • DRIVESHAFT – U-JOINT – IDENTIFICATION OF SERVICE PARTS BY MEASUREMENT
  • DRIVESHAFT – U-JOINTS – IDENTIFICATION OF SERVICE PARTS BY MEASUREMENT
97-19A-1

  • EVAPORATIVE EMISSIONS
97-19-20

  • TRANSMISSION – E4OD – MAIN REGULATOR BOOSTER VALVE AND SLEEVE SERVICE KIT – SERVICE TIP
97-19-19

  • AIR CONDITIONING – NO AIRFLOW FROM FLOOR
  • HEATER – NO AIRFLOW FROM FLOOR
97-19-11

  • COOLING SYSTEM – “ON-VEHICLE” HEATER CORE PRESSURE TEST REQUIRED FOR WARRANTY CLAIM
97-17-25

  • TRANSMISSION – E4OD – NEW DESIGN REVERSE CLUTCH ASSEMBLY – TRANSMISSION BUILT FROM 3/26/97
97-17-23

  • NOISE – “BUZZING” OR “GROWLING” NOISE FROM TRANSFER CASE SHIFT LEVER – VEHICLES BUILT THROUGH 9/1/97
  • TRANSFER CASE – “BUZZING” OR “GROWLING” NOISE FROM TRANSFER CASE SHIFT LEVER – VEHICLES BUILT THROUGH 9/1/97
97-17-2

  • REAR VIEW MIRROR – NEW PROCEDURE FOR PREFERRED REATTACHMENT METHOD
97-16-11

  • AIR CONDITIONING – CONDENSATE DRIPS ONTO PASSENGER FLOOR DURING HUMID CONDITIONS
97-15-24

  • NOISE – “BOOMING” – VIBRATION OR BOOM
    OFF IDLE AT ENGINE SPEEDS BETWEEN 650 RPMS AND 1100
    RPMS AT VERY LOW VEHICLE SPEEDS
  • VIBRATION – VIBRATION OR BOOM OFF IDLE
    AT ENGINE SPEEDS BETWEEN 650 RPMS AND 1100 RPMS AT
    VERY LOW VEHICLE SPEEDS
97-15-5

  • AIR CONDITIONING – OIL REFILL CAPACITY
    CHART – SERVICE TIP
97-13-23

  • TRANSMISSION – E4OD – INCORRECT
    SEPARATOR PLATE – 4X4 VEHICLES BUILT FROM 4/18/97
    THROUGH 4/21/97
  • TRANSMISSION – E4OD – SLIP/BUMP 1-2
    UPSHIFTS – 4X4 VEHICLES BUILT FROM 4/18/97 THROUGH
    4/21/97
97-13-21

  • NOISE – “CLUNKING” OR “GRUNTING” FROM
    DRIVELINE DURING ACCELERATION OR BRAKING – 4X4
    VEHICLES BUILT THROUGH 5/15/97
  • DRIVELINE – NOISE – “CLUNKING” OR
    “GRUNTING” FROM DRIVELINE DURING ACCELERATION OR
    BRAKING – 4X4 VEHICLES BUILT THROUGH 5/15/97

97-13-20

  • ENGINE – 7.3L DIT – 1997 ENGINE
    CONTENT REVISIONS – SERVICE TIP
97-13-18

  • RADIO – “WHINING” IN AM RADIO BAND
    WHILE DRIVING – VEHICLES BUILT THROUGH 5/30/97
  • NOISE – “WHINING” IN AM RADIO BAND –
    VEHICLES BUILT THROUGH 5/30/97
97-12-13

  • TRANSMISSION – C6, E4OD, AOD, 4R70W –
    LOW TRANSMISSION FLUID LEVEL AND/OR SHIFT AND/OR
    ENGAGEMENT CONCERNS – 4X4 AND AWD VEHICLES ONLY

97-12-9

  • ENGINE MISFIRE – MIL LAMP ILLUMINATION
    – DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0306
    STORED IN MEMORY – NO DRIVEABILITY CONCERNS PRESENT –
    VEHICLES BUILT THROUGH 4/15/97
  • HARD START – AT ALL AMBIENT
    TEMPERATURES – VEHICLES WITH 4.2L ENGINE
  • INDUCTION BACKFIRE – AFTER COLD START
    – AT ALL AMBIENT TEMPERATURES – VEHICLES WITH 4.2L
    ENGINE
  • MALFUNCTION INDICATOR LAMP (MIL)
    ILLUMINATION – DIAGNOSTIC TROUBLE CODES (DTCS) P0300
    THROUGH P0306 STORED IN MEMORY – NO DRIVEABILITY
    CONCERNS PRESENT – VEHICLES BUILT THROUGH 4/15/97
  • STALL – ROUGH IDLE –
    HESITATION/STUMBLE – AFTER COLD START – AT ALL AMBIENT
    TEMPERATURES – VEHICLES WITH 4.2L ENGINE
  • LAMP – MALFUNCTION INDICATOR LAMP
    (MIL) ILLUMINATION – DIAGNOSTIC TROUBLE CODES (DTCS)
    P0300 THROUGH P0306 STORED IN MEMORY – NO DRIVEABILITY
    CONCERNS PRESENT – VEHICLES BUILT THROUGH 4/15/97

97-11-21

  • NOISE – FIRST GEAR “TICKING” NOISE –
    E4OD TRANSMISSIONS – 4X4 VEHICLES WITH 5.4L ENGINE AND
    TRANSMISSION BUILT PRIOR TO 3/11/97 AND 4X2 VEHICLES
    WITH TRANSMISSION BUILT PRIOR TO 4/8/97 – SERVICE TIP
  • E4OD – FIRST GEAR “TICKING” NOISE –
    4X4 VEHICLES WITH 5.4L ENGINE AND TRANSMISSION BUILT
    PRIOR TO 3/11/97 AND 4X2 VEHICLES WITH TRANSMISSION
    BUILT PRIOR TO 4/8/97 – SERVICE TIP

97-11-11

  • TRANSMISSION – 4R70W – ERRATIC OR
    PROLONGED 1-2 SHIFT
  • TRANSMISSION – AODE – ERRATIC OR
    PROLONGED 1-2 SHIFT
97-11-5

  • REMOTE ANTI-THEFT PERSONALITY (RAP)
    TRANSMITTERS – REPROGRAMMING INFORMATION

97-10-10

  • AXLE – FRONT – LUBRICANT LEAKING FROM
    FRONT AXLE TUBE VENT HOSE
97-10-5

  • AIR CONDITIONING – COMPRESSOR FAILURE
    – INSUFFICIENT AMOUNT OF REFRIGERANT OIL
  • AIR CONDITIONING – LACK OF COOLING –
    INSUFFICIENT AMOUNT OF REFRIGERANT OIL MAY CAUSE
    COMPRESSOR FAILURE
97-9-17

  • CLIMATE CONTROL – LOSS OF TEMPERATURE
    CONTROL – VEHICLES BUILT THROUGH 2/18/97

97-9-8

  • POWERTRAIN CONTROL MODULE – REPROGRAM
    POWERTRAIN CONTROL MODULE (PCM) – SERVICE PROCEDURES –
    SERVICE TIP
97-9-1

  • PAINT – “RAPGARD” PAINT PROTECTION –
    SERVICE TIP
97-8-6

  • MALFUNCTION INDICATOR LAMP (MIL) –
    DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302,
    P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED
    IN MEMORY
  • LAMP – MALFUNCTION INDICATOR LAMP
    (MIL) ILLUMINATES – DIAGNOSTIC TROUBLE CODES (DTCS)
    P0300, P0301, P0302, P0303, P0304, P0305, P0306,
    P0307, AND/OR P0308 STORED IN MEMORY

97-6-29

  • TRANSMISSION – E4OD – HARSH/DELAYED
    2-3 UPSHIFTS – VEHICLES WITH 7.3L DIESEL AND 49-STATE
    CALIBRATION – F-SERIES BUILT THROUGH 2/3/97 AND ALL
    1996 E-350
97-4-10

  • TRANSMISSION – E4OD – COOLER BYPASS
    VALVE SERVICE DURING TRANSMISSION OVERHAUL – SERVICE
    TIP
97-4-7

  • FRAME – RIVET REPLACEMENT WITH BOLTS –
    SERVICE TIPS
97-3-5

  • AIR CONDITIONING – R-134A TRACER DYE
    INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK
    COUPLERS – SERVICE TIP
96-26-18

  • FUEL – LOCKING GASOLINE CAPS – NEW
    PART AVAILABILITY
  • LOCKING FUEL CAPS – NEW PART
    AVAILABILITY
96-26-12

  • TRANSAXLE – TORQUE CONVERTER
    REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE
    COOLING SYSTEM CLEANING PROCEDURES – SERVICE TIP
  • TRANSMISSION – TORQUE CONVERTER
    REPLACEMENT GUIDELINES AND TORQUE
    CONVERTER/TRANSMISSION COOLING SYSTEM CLEANING
    PROCEDURES – SERVICE TIP
96-25-25

  • NOISE – “RATTLE” – SUMMARY OF CONCERNS
    – SERVICE TIPS
  • NOISE – “SQUEAK” – SUMMARY OF CONCERNS
    – SERVICE TIPS
96-25-23

  • RUNS ROUGH – MALFUNCTION INDICATOR
    LAMP (MIL) ON – DIAGNOSTIC TROUBLE CODES (DTCS) P0300
    THROUGH P0308 STORED IN MEMORY – VEHICLES BUILT
    THROUGH 10/14/96 WITH 4.6L ENGINE
  • LAMP – MALFUNCTION INDICATOR LAMP
    (MIL) ON – RUNS ROUGH – DIAGNOSTIC TROUBLE CODES
    (DTCS) P0300 THROUGH P0308 STORED IN MEMORY – VEHICLES
    BUILT THROUGH 10/14/96 WITH 4.6L ENGINE

96-25-21

  • STEERING – “CLUNK” NOISE FROM STEERING
    COLUMN ON ACCELERATING AND BRAKING
  • NOISE – “CLUNK” – FROM STEERING COLUMN
    ON ACCELERATING AND BRAKING
96-25-18

  • DOOR – POWER POINT ACCESS DOOR BREAKS
    – VEHICLES BUILT THROUGH 8/31/96

96-24-10

  • TRANSMISSION – E4OD – 4R70W – 4R44E –
    5R55E – NEW DIGITAL TRANSMISSION RANGE SENSOR –
    DIAGNOSIS SERVICE TIP
96-24-9

  • TORQUE CONVERTER – LEAK TEST PROCEDURE
    – SERVICE TIP
96-24-6

  • WIRING – ELECTRICAL DIODE
    IDENTIFICATION AND SERVICE REPLACEMENTS

96-22-10

  • WINDSHIELD WASHERS – WASHER HOSE TOO
    SHORT AND/OR IS TRAPPED BY THE HOOD – VEHICLES BUILT
    THROUGH 4/15/96
96-22-5

  • MASS AIR FLOW SENSOR – REPLACEMENT AS
    AN ASSEMBLY – SERVICE TIP
96-22-1

  • WINDSHIELD AND INTERIOR GLASS –
    FOG/FILM
96-21-15

  • TRANSMISSION – E4OD – NEW DESIGN
    OVERDRIVE CLUTCH PISTON ASSEMBLY FOR SOME 1996-97
    VEHICLES – VEHICLES BUILT FROM 12/5/95 THROUGH 6/15/96

96-21-14

  • LEAK – 4R70W TRANSMISSION – EXTENSION
    HOUSING GASKET
96-21-13

  • NOISE – “CLICKING” AND “GRINDING”
    DURING 4X4 ENGAGEMENT
  • NOISE – “CLICKING” WHILE DRIVING
    STRAIGHT OR DURING LEFT HAND TURN – 4X2
  • AXLE – “CLICKING” AND “GRINDING” NOISE
    DURING 4X4 ENGAGEMENT
  • AXLE – NON-ENGAGEMENT OF FRONT AXLE
96-21-7

  • WEATHERSTRIP – LOOSE OR DETACHED –
    FRONT DOOR OUTER
96-20-12

  • DOORS/TAILGATE – NEW SERVICE PART
    RELEASED FOR DOOR LOCK ROD MECHANISM – VEHICLES BUILT
    THROUGH 7/15/96
96-20-8

  • AIR CONDITIONING – NEW O-RING
    APPLICATIONS – THICKER O-RINGS FOR SPRING LOCK
    FITTINGS – SERVICE TIP
  • AIR CONDITIONING – SPRING LOCK
    COUPLING CLEANING PROCEDURE – SERVICE TIP

96-17-18

  • LAMPS – INTERIOR – INTERMITTENT OR
    INOPERATIVE – FUSE 14 “OPEN” – VEHICLES BUILT THROUGH
    5/14/96
  • LOCKS – POWER DOOR – INTERMITTENT OR
    INOPERATIVE – FUSE 14 “OPEN” – VEHICLES BUILT THROUGH
    5/14/96
  • WINDOW – POWER – INTERMITTENT OR
    INOPERATIVE – FUSE 14 “OPEN” – VEHICLES BUILT THROUGH
    5/14/96
96-17-16

  • BUMPER – FRONT – PREMATURE SIGNS OF
    WEAR AND/OR CHROME CRACKING – VEHICLES BUILT THROUGH
    2/11/96
96-17-9

  • MALFUNCTION INDICATOR LAMP (MIL)
    ILLUMINATION – DIAGNOSTIC TROUBLE CODES (DTCS) P0300,
    P0301, P0302, P0303, P0304, P0305, P0306, P0307, OR
    P0308 IN MEMORY – NO DRIVEABILITY CONCERNS PRESENT –
    VEHICLES BUILT WITH 3.8L, 4.2L, OR 4.6L ENGINE
  • LAMP – MALFUNCTION INDICATOR LAMP
    (MIL) ILLUMINATION – DIAGNOSTIC TROUBLE CODES (DTCS)
    P0300, P0301, P0302, P0303, P0304, P0305, P0306,
    P0307, OR P0308 IN MEMORY – NO DRIVEABILITY CONCERNS –
    VEHICLES BUILT WITH 3.8L, 4.2L, OR 4.6L ENGINE

96-16-6

  • INSTRUMENT CLUSTER – RECALIBRATING
    SPEEDOMETER FOR TIRE SIZE CHANGE
  • INSTRUMENT CLUSTER – SERVICE TIPS
96-14-9

  • FRONT END ACCESSORY DRIVE (FEAD)
    “SQUEAL/HOOT” – DURING COLD START-UP AFTER COLD SOAK
    BELOW -18 DEGREES C (0 DEGREES F)
  • NOISE – “SQUEAL/HOOT” FROM FRONT END
    ACCESSORY DRIVE (FEAD) AREA – DURING COLD START-UP
    AFTER COLD SOAK BELOW -18 DEGREES C (0 DEGREES F)

96-13-8

  • BLOWER MOTOR – INOPERATIVE OR NOISY
    OPERATION – VEHICLES BUILT THROUGH 2/9/96

96-12-16

  • LAMP – ABS MALFUNCTION INDICATOR LAMP
    (MIL) ILLUMINATED – DIAGNOSTIC TROUBLE CODES (DTC)
    C1145, C1148, C1155, C1158, C1233, C1234 – 4X2 WITH
    4-WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) – VEHICLES
    BUILT THROUGH 2/26/96
96-12-9

  • NOISE – “CHATTER” DURING TIGHT TURNS
    OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY DRIVING –
    TRACTION-LOK DIFFERENTIAL – 7.5 AND 8.8 INCH RING GEAR
    REAR AXLES
  • AXLE – NEW SERVICE KIT AVAILABLE FOR
    TRACTION-LOK DIFFERENTIAL – 7.5 AND 8.8 INCH RING GEAR
  • AXLE – TRACTION-LOK DIFFERENTIAL – 7.5
    AND 8.8 INCH RING GEAR – “CHATTER” NOISE DURING TIGHT
    TURNS OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY
    DRIVING
96-8-16

  • NOISE – “WHISTLE” WHILE DRIVING WITH
    BLOWER MOTOR OPERATING – VEHICLES BUILT THROUGH
    1/20/96
96-8-6

  • ENGINE – 4.6L – DIFFERENCES BETWEEN
    ROMEO AND WINDSOR BUILT ENGINES – SERVICE TIP
07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-14-4

  • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
07-16-17

  • SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION – 3.8L, 3.9L, AND 4.2L – SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)