Technical Service Bulletins
|Publication Date: March 4, 2005|
|2003-2005 F-Super Duty|
Some 2003-2005 Super Duty F-Series equipped with a 6.0L diesel engine and a single generator, may exhibit low battery voltage when plowing for an extended period, and while using a salt spreader and/or other lighting accessories added on by the customer.
If the charging system only exhibits the condition with all of the aftermarket accessories in use, there is a 140 AMP service generator available for customer purchase. This is the same generator used in the factory installed snow plow package.
|NOTE:||THIS REPAIR MAY NOT BE 100% EFFECTIVE ON ALL VEHICLES FOR VARIOUS REASONS. EXAMPLES: AS SNOW PLOW, SANDER/SALTER AND OTHER EQUIPMENT AGE, THEIR ELECTRICAL LOAD DEMAND MAY INCREASE. ALSO, THE TYPE OF PLOWING (SHORT DISTANCE PLOWING) MAY IMPACT THE ABILITY OF THE CHARGING SYSTEM TO COMPENSATE FOR THE DRAW.|
|PART NUMBER||PART NAME|
|4C3Z-10346-BA||Generator – 140 Amp|
Information Only – Not Warrantable
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.
Copyright © 2005 Ford Motor Company