Fulltext TSBs

Technical Service Bulletins

TSB
05-12-1
  • ENGINE QUITS UPON DRIVE OR REVERSE ENGAGEMENT, OR WHEN COMING TO A STOP – TORQSHIFT TRANSMISSION
Publication Date: June 2, 2005

FORD:
2005 E-Series, Excursion, F-Super Duty

ISSUE:

Some 2005 Super Duty, Excursion, or E-Series vehicles built between 10/1/2004 and 11/30/2004 and equipped with the Torqshift transmission, may exhibit an engine quits upon engagement into drive or reverse, or when coming to a stop. Diagnostic trouble codes (DTCs) P1744, P0740, P0741, P0743, or P0744 may also be present. This may be due to a stuck torque converter clutch (TCC) solenoid.

ACTION:

Verify the condition exists. Replace the TCC solenoid following Workshop Manual procedures. Clean the fluid pan and magnet. Flush the cooler lines and replace the remote filter element. Verify cooler flow. Clear codes, if any, and verify repair. Do not replace the torque converter or the pump assembly for this concern.


PART NUMBERPART NAME
3C3Z-7J136-BATCC Solenoid

WARRANTY STATUS:

Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage

OPERATIONDESCRIPTIONTIME
051201A2005 Excursion/Super Duty/Econoline: Verify Concern, Replace The TCC Solenoid, Flush The Cooler Lines, Replace The Remote Filter, Verify Cooler Flow, Clear Diagnostic Trouble Codes And Verify Effectiveness Of The Repair (Do Not Use With 7000F, 7000A11, 7000A43, 7191A, 7191A13, 7191AZG, 7191AXQ)2.8 Hrs.

DEALER CODING

BASIC PART NO.CONDITION CODE
7J13649

NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.

Copyright 2005 Ford Motor Company