Fulltext TSBs

Technical Service Bulletins

09-20-5

  • SHUDDER OR VIBRATION ON ACCELERATION – ESPECIALLY WHEN LOADED
09-16-2

  • 6.4L DIESEL ENGINE TICKING/TAPPING NOISE
09-14-4

  • WIF LIGHT ON – NO DRIVABILITY SYMPTOMS WATER IN AFT FUEL TANK DUE TO SNOW AND ICE BUILD UP IN FUEL TANK VENT AREA – 6.4L, 6.0L, AND 7.3L DIESEL ENGINE
09-20-12

  • SLOW FUEL FILL – 5.4 AND 6.8 ENGINES
09-22-1

  • 4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES
09-22-8

  • STAINLESS STEEL EXHAUST STUDS – 5.4L AND 6.8L 2V ENGINES
09-23-1

  • 6.4L DIESEL ENGINES – REPEAT RADIATOR LEAK – BUILT ON OR BEFORE 9/14/2009
09-26-7

  • 5.4L / 4.0L – DTC P0607
10-1-6

  • 5.4L ENGINE – DIAGNOSTIC TROUBLE CODE (DTC) P2135
10-1-11

  • 4X4 ONLY – BANGING/CLUNKING NOISE WHEN DRIVING – CONTACT WITH JOUNCE BUMPER – COLD TEMPERATURES
10-1-13

  • 6.4L / 6 SPEED MANUAL TRANSMISSION / 3.55 AXLE – SPEED CONTROL DEACTIVATES IN OVERDRIVE (OD) – BUILT ON OR BEFORE 12/4/2009
10-2-1

  • 6.8L – CREW CAB – SINGLE REAR WHEEL (SRW) – DRONE/MOAN AT HIGHWAY SPEEDS – BUILT ON OR AFTER 3/18/2009
10-2-2

  • 6.4L AIR INDUCTION SYSTEM RESTRICTION – SNOW
10-2-8

  • SYNC SYSTEM DEFAULTS TO OR STAYS IN PRIVACY MODE, MULTIPLE VEHICLE LINES
10-5-8

  • 6.4L – DIESEL HOT-SIDE CHARGE AIR COOLER TUBE REPAIR PROCEDURE
10-7-5

  • 6.4L DIESEL COOLING SYSTEM CONTAMINATION FLUSH PROCEDURE
10-13-4

  • SYNC NON-NAVIGATION – NO TURN-BY-TURN DIRECTIONS AND/OR UNABLE TO PIN POINT VEHICLE LOCATION – BUILT ON OR BEFORE 6/14/2010
10-18-4

  • LOW FREQUENCY ENGINE KNOCKING NOISE AT HOT IDLE
10-20-2

  • 6.4L – NEW ENHANCED SHORT BLOCK – BUILD UP/REPAIR ROBUSTNESS PROCEDURES – INFORMATION ONLY
10-20-10

  • 6.4L – FRONT END SHEET METAL BODY BOLT REMOVAL – SPUN CAGE NUT
10-20-11

  • SIRIUS RADIO WITH NAVIGATION – UPDATE PROCESS FAILURE – BUILT ON OR BEFORE 3/8/2010
10-23-6

  • 6.4L ENGINE – LACKS POWER, MIL ON WITH DTCS P20E2, P20E3, P20E4, P2080, P2084, P242B, P0544, P2031, P242A, OR P200E
10-25-3

  • CLUNK/POP NOISE HEARD/FELT UNDER FLOOR PAN WHILE TURNING – BUILT ON OR BEFORE 11/15/2010
10-25-12

  • SYNC – CALL SOUND QUALITY/BACKGROUND NOISE ISSUES AND/OR VOICE RECOGNITION DIFFICULTIES WHILE DRIVING
11-1-3

  • 4.0L / 5.4L / 6.8L – CALIBRATION UPDATE – VARIOUS ISSUES
11-1-7

  • 6.4L DIESEL ENGINES – RADIATOR LEAK DUE TO HYPER-EXTENDED BYPASS THERMOSTAT
11-2-2

  • 6.4L DIESEL – WHITE SMOKE IN DAMP WEATHER CONDITIONS WHEN ACCELERATING