Fulltext TSBs

Technical Service Bulletins

06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY
    EYE – CHARGING SERVICE TIPS
05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A
    STOP
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON
    PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH
    RUNNING
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY
    TERMINAL
05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR
    WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING
    REPAIRS – SERVICE TIPS
05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS
    CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST
    MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR
    AXLE – 6.0L AND 7.3L DIESEL ENGINE

05-6-4

  • FALSE PARKING AID WARNINGS
05-5-4

  • USE OF STAINLESS STEEL EXHAUST STUDS
    IN SERVICE FOR 5.4L 2V ENGINE
05-4-17

  • INTERMITTENT ROUGH IDLE –
    NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
04-25-4

  • HARD START OR NO START – 7.3L
04-24-22

  • LOSS OF POWER OR STUMBLE WHILE DRIVING
    IN RAIN – 6.8L ENGINE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-11

  • MOMENTARY RETURN TO IDLE DURING
    AGGRESSIVE ACCELERATION – DIAGNOSTIC TROUBLE CODE
    (DTC) P0123 – 7.3L ENGINE
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL –
    LEATHER COMING LOOSE
04-23-9

  • WATER LEAK – ROOF FLANGE AREA – WATER
    ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
    PAN AREA
04-23-6

  • VEHICLE LEAN/SAG WHEN OBSERVED FROM
    REAR OF VEHICLE
04-20-2

  • OIL LEAK – TURBO PEDESTAL SEAL AT
    EXHAUST BACK PRESSURE ACTUATOR (EBP) – 7.3L DIESEL

04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-18-5

  • AXLE – FRONT HUBS NOT ENGAGING, NOT
    STAYING ENGAGED AND/OR UNLOCKING

04-17-4

  • MALFUNCTION INDICATOR LAMP (MIL)
    ILLUMINATED – SYSTEM LEAN DIAGNOSTIC TROUBLE CODES
    (DTC’S) – SERVICE TIPS
04-16-4

  • REAR AXLE POPPING/CHATTER NOISE – DANA
    80 MODEL DUAL REAR WHEEL (DRW)
04-11-2

  • SUSPENSION – VEHICLE SWAY/LEAN DURING
    LOW SPEED TURNING MANEUVERS
  • NOISE – SUSPENSION – POPPING NOISE IN
    FRONT END
04-4-4

  • ENGINE – 7.3L DIESEL DI – HIGH
    PRESSURE OIL PUMP LEAK
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS
    AND MOTOR REPLACEMENT – SERVICE TIPS

03-22-2

  • NOISE – DRIVESHAFT CENTER BEARING
    NOISE – VEHICLES BUILT AFTER 6/1/2002
  • DRIVESHAFT – DRIVESHAFT CENTER BEARING
    NOISE – VEHICLES BUILT AFTER 6/1/2002

03-21-48

  • DRIVEABILITY – P0340 CAMSHAFT POSITION
    SENSOR FALSE DIAGNOSTIC TROUBLE CODE – VEHICLES
    EQUIPPED WITH 7.3L DIESEL ENGINE ONLY
  • TRANSMISSION – 4R100 – DELAYED 3-4
    SHIFT – VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE ONLY

03-21-45

  • ENGINE – 7.3L – EXTERNAL OIL LEAK
    DIAGNOSIS FOR 7.3L DIT ENGINES
03-20-5

  • DRIVEABILITY – NO START/REPEAT STARTER
    FAILURE – REPEAT STARTER REPLACEMENT
  • ELECTRICAL – STICKING OR BINDING
    IGNITION LOCK CYLINDER BETWEEN START AND RUN
  • ENGINE – STARTING – STARTER STAYING
    ENGAGED AT START UP
03-20-3

  • DRIVEABILITY – MALFUNCTION INDICATOR
    LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456,
    P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
    DTC P0457
03-19-10

  • BRAKES – BRAKE PULL – 4X4 F-250/350
    AND 4X4 EXCURSION VEHICLES ONLY
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY
    (RKE) – SERVICE TIPS
03-17-4

  • STEERING – STEERING WHEEL FIGHT AFTER
    RIDING OVER BUMPS/RUTS
03-14-8

  • TRANSMISSION – NEW TRANSMISSION COOLER
    FLUSHER – SERVICE TIPS
03-14-3

  • SUSPENSION – 4X4 WHEEL HUB
    NON-ENGAGEMENT/DISENGAGEMENT
  • AXLE – 4X4 WHEEL HUB
    NON-ENGAGEMENT/DISENGAGEMENT
03-11-2

  • SUSPENSION – ON-VEHICLE FRONT
    INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
  • AXLE – ON-VEHICLE FRONT INTEGRATED
    HUB/BEARING ROCKING END-PLAY MEASUREMENT

03-9-11

  • DRIVEABILITY – ROUGH IDLE AND/OR
    HESITATION ON ACCELERATION – VEHICLES EQUIPPED WITH
    5.4L OR 6.8L ENGINE ONLY
03-8-3

  • ENGINE – ENGINE OIL LEVEL INDICATOR
    MARKINGS – REPORTS OF LOW OIL LEVELS

03-4-5

  • DRIVEABILITY – “WAIT TO START” LAMP
    DOES NOT OPERATE PROPERLY
  • ELECTRICAL – LAMP – “WAIT TO START”
    LAMP DOES NOT OPERATE PROPERLY
03-4-1

  • FRONT LOCKING HUBS – SERVICE TIP
03-3-7

  • BODY – PAINT – NO CLEARCOAT BLENDING –
    COLLISION MANUAL CHANGE
02-25-2

  • ELECTRICAL – CDX6 RADIO DAMAGED DURING
    SERVICE SHIPPING – CORRECT SHIPMENT PROCEDURES FOR
    CDX6 RADIO – SERVICE TIPS
02-23-7

  • COOLING SYSTEM – MOTORCRAFT PREMIUM
    GOLD ENGINE COOLANT – SERVICE TIPS

02-21-13

  • ENGINE – STRAIGHTEDGE PROCEDURE FOR
    CHECKING CYLINDER HEAD AND BLOCK FLATNESS

02-21-1

  • TRANSMISSION – 4R100/E4OD – TORQUE
    CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
    DISLODGED
02-17-12

  • MOTORHOME GENERATORS – SHUT OFF WHEN
    FUEL TANK READS 1/4 FULL
02-17-6

  • LAMP – BRAKE – INADVERTENT DISABLING
    OF BRAKE SHIFT INTERLOCK
02-16-4

  • FUEL SYSTEM – FUEL PUMP
    “WHINING”/”BUZZING” NOISE COMES THROUGH ENTERTAINMENT
    OR TWO-WAY RADIO SPEAKER
  • RADIO – ENTERTAINMENT OR TWO-WAY
    COMMUNICATION – “WHINING”/”BUZZING” NOISE IN SPEAKERS
    CAUSED BY FUEL PUMP
  • NOISE – “WHINING”/”BUZZING” – COMES
    THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO

02-16-3

  • PAINT – NEW POLISHING PRODUCTS –
    SERVICE PROCEDURES
02-14-1

  • SUSPENSION – SQUEAK NOISE FROM REAR
    LEAF SPRINGS – REPLACEMENT REAR LEAF SPRING TIP LINER
    – VEHICLES PRODUCED BEFORE 10/15/01
  • NOISE – SQUEAK NOISE FROM REAR LEAF
    SPRINGS – REPLACEMENT REAR LEAF SPRING TIP LINER –
    VEHICLES PRODUCED BEFORE 10/15/01

02-11-4

  • ENGINE – NEW GASKET REMOVER/CLEANER
    AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

02-10-8

  • DRIVEABILITY – 5.4L 2V – IDLE-AIR
    BYPASS FLOW INDUCED WHISTLE
  • ENGINE – 5.4L 2V – IDLE-AIR BYPASS
    FLOW INDUCED WHISTLE
  • NOISE – IDLE-AIR BYPASS FLOW INDUCED
    WHISTLE – VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY

02-10-4

  • DRIVEABILITY – BI-FUEL LPG – CRANK NO
    START, ROLLING IDLE, SURGING IDLE, AND/OR SURGE AT
    CRUISE IN LPG MODE WITH ALT FUEL GREEN LIGHT ON

02-7-2

  • CLIMATE CONTROL – A/C COMING OUT
    DEFROST OR PERCEIVED A/C CUTTING OUT ON LONG UPHILL
    GRADE
02-5-6

  • SHEET METAL – PRIMED SERVICE PARTS –
    PREP PROCEDURE AND MSDS INFORMATION

02-3-5

  • BODY – “SQUEAK” OR BIND FROM TAILGATE
  • NOISE – “SQUEAK” OR BIND FROM TAILGATE
02-1-9

  • ENGINE – ENGINE OIL – RECOMMENDED
    APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS –
    GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY

01-24-6

  • ENGINE – ENGINE OIL SYSTEM PRIMING
    PROCEDURES – SERVICE TIPS
01-23-6

  • ENGINE COOLANT – PROPYLENE GLYCOL –
    FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
    FROM PROPYLENE GLYCOL
  • ENGINE COOLANT – PROPYLENE
    GLYCOL-BASED – FORD MOTOR COMPANY POSITION ON
    PROPYLENE GLYCOL-BASED ENGINE COOLANTS

01-21-13

  • DRIVEABILITY – DIAGNOSTIC TROUBLE
    CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
    MODELS ONLY – STICKING OR BINDING IGNITION LOCK
    CYLINDER – HIGH EFFORT WHEN TURNING IGNITION SWITCH
  • ELECTRICAL – STICKING OR BINDING
    IGNITION LOCK CYLINDER – HIGH EFFORT WHEN TURNING
    IGNITION SWITCH
01-20-6

  • DRIVEABILITY – BI-FUEL WIRING
    CONNECTOR CROSS-REFERENCE CHART
  • ELECTRICAL – BI-FUEL WIRING CONNECTOR
    CROSS-REFERENCE CHART
01-17-3

  • VIBRATION – DRIVELINE DRONE OR
    VIBRATION – FELT AT 80-96 KM/H (50-60 MPH) – VEHICLES
    EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY

01-15-6

  • CLIMATE CONTROL – REPEAT HEATER CORE
    FAILURE
  • COOLING SYSTEM – REPEAT HEATER CORE
    FAILURE
01-10-12

  • WIRING – WIRE HARNESS TERMINAL REPAIR
    KIT AND WIRE SPLICE PROCEDURE