Fulltext TSBs

Technical Service Bulletins

06-8-15

  • INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS – C1979 AND C1980
06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT REQUIREMENTS
06-5-9

  • SPARK PLUG REMOVAL INSTRUCTIONS – 5.4
    3V
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-7

  • TICKING AND/OR KNOCKING NOISE FROM
    ENGINE – 4.6L/5.4L 3V
06-4-4

  • LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS
06-4-3

  • ALTERNATE TIRES APPROVED FOR OFF ROAD USE
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-3-4

  • PICK UP BOX TO FRAME INTERFERENCE FOLLOWING FRAME REPLACEMENT – 133 INCH SUPERCAB AND 139 INCH SUPERCREW WHEELBASE VEHICLES W/5.5 FOOT BOX
06-3-3

  • 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK
06-2-9

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V
    AND 5.4L 3V
06-2-5

  • POWER FOLDING MIRROR OPERATION
05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-26-11

  • DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP
05-26-7

  • RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES
05-26-6

  • RAPID FEATHERING WEAR OF FRONT TIRES
05-24-3

  • NOISE FROM BACK GLASS – POWER SLIDING
    REAR WINDOW ONLY
05-23-18

  • ROUGH IDLE – 5.4L 3V 4X2 SUPERCAB AND SUPERCREW
05-23-3

  • REAR AXLE NOISE REPAIR
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-21-19

  • FRONT BRAKE ROUGHNESS – SHUDDER WHILE BRAKING
05-21-18

  • SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-16-12

  • SERVICE WIRING HARNESS REPLACEMENT
    GUIDELINES – SERVICE TIPS
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-15-1

  • CLICKING/TICKING NOISE FROM STEERING COLUMN – VEHICLES BUILT BEFORE 5/31/2005
05-14-4

  • WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 – VEHICLES BUILT 11/29/2004 AND PRIOR
05-14-2

  • HEADLINER BUFFETING/RATTLE NOISE – VEHICLES EQUIPPED WITH ROOF-OPENING PANEL AND BUILT PRIOR TO 6/1/2005
05-13-1

  • SHUDDER/VIBRATION ON MODERATE TO HARD
    ACCELERATION
05-11-9

  • REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS – SERVICE TIP
05-10-11

  • WHITE FLAKES COMING FROM A/C VENTS
05-10-9

  • MIL ON AND DTC P0172 AND/OR P0175 IN MEMORY – 4.6L 2V ENGINE
05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
05-6-10

  • SPEED CONTROL INOPERATIVE/INTERMITTENT OPERATION – VEHICLES BUILT BEFORE 5/17/2004
05-6-4

  • FALSE PARKING AID WARNINGS
05-5-15

  • ROUGH IDLE – 5.4L AND 4.6L ENGINES
05-5-6

  • ALTERNATIVE FUEL VEHICLE – COMPRESSED NATURAL GAS FUEL TANK INSPECTION
05-5-5

  • KEYLESS ENTRY KEYPAD INOPERATIVE
05-4-17

  • INTERMITTENT ROUGH IDLE – NON-COMMANDED EGR FLOW
05-4-3

  • COOLING FAN CLUTCH NOISE – VEHICLES BUILT PRIOR TO 10/1/2004 – 5.4L AND 4.6L ENGINES
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
05-3-1

  • MAF DIAGNOSTIC SERVICE TIP – VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)
04-26-18

  • FRONT DOOR TRIM APPLIQUE REMOVAL
04-25-17

  • MAGNESIUM ALLOY RADIATOR CORE SUPPORT – UNIQUE HANDLING AND REPAIR PROCEDURES – SERVICE TIPS
04-25-8

  • 1ST ORDER VIBRATION FROM THE DRIVELINE
    AT HIGHWAY SPEEDS
04-25-7

  • VEHICLE/STEERING WHEEL VIBRATION AT 50
    MPH (80 KM/H) OR HIGHER – STEERING WHEEL NIBBLE AT 65
    MPH (105 KM/H) OR HIGHER
04-25-1

  • ALUMINUM CORROSION – SERVICE TIP
04-24-24

  • CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE – 5.4L 3V ENGINE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-5

  • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
04-21-20

  • WATER LEAK AT PASSENGER SIDE LOWER A-PILLAR
04-21-14

  • HESITATION ON ACCELERATION AND/OR ERRATIC IDLE WHEN COMING TO A STOP
04-21-10

  • MIL ON WITH DTC P0354
04-20-5

  • WATER LEAK FROM HIGH MOUNT STOP LAMP
04-18-8

  • HOOD FLUTTER AT HIGHWAY SPEEDS
04-18-7

  • FRONT END ACCESSORY DRIVE NOISE
04-17-4

  • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S) – SERVICE TIPS
04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL – INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION
04-8-3

  • ELECTRICAL – SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS – SERVICE PROCEDURE
04-1-6

  • NOISE – DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
  • TRANSMISSION – DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
03-26-4

  • BODY – REAR DOOR PANEL – WAVY APPEARANCE IN COLD WEATHER – LOUD RINGING UPON CLOSING DOOR – RATTLE INSIDE OF DOOR – VEHICLES BUILT BEFORE 11/12/2003
  • NOISE – REAR DOOR PANEL – WAVY APPEARANCE IN COLD WEATHER – LOUD RINGING UPON CLOSING DOOR – RATTLE INSIDE OF DOOR – VEHICLES BUILT BEFORE 11/12/2003
03-25-6

  • ENGINE – ROMEO BUILT 4.6L 2V – TICK NOISE FROM ENGINE – ENGINES BUILT BEFORE 9/17/2003
03-23-5

  • BODY – BED EXTENDER – COMPONENT REPLACEMENT – SERVICE TIP
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT – SERVICE TIPS
03-22-4

  • WHEEL – CORRECT LUG NUT TORQUE SPECIFICATIONS – INCREASED WHEEL NUT AND STUD SIZE – SERVICE TIP
03-20-8

  • STEERING – STEERING WHEEL NIBBLE AT OR
    ABOVE 100 KM/H (60 MPH) – VEHICLES BUILT PRIOR TO
    8/20/2003
  • VIBRATION – STEERING WHEEL NIBBLE AT
    OR ABOVE 100 KM/H (60 MPH) – VEHICLES BUILT PRIOR TO
    8/20/2003
03-20-4

  • BODY – INTERIOR DOOR HANDLE REPAIR – REAR DOORS ON CREW CAB AND FRONT DOORS ON REGULAR AND SUPER CAB (STX / XL)
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY (RKE) – SERVICE TIPS
03-15-4

  • PAINT – INSTRUMENT PANEL – SCRATCH/MAR REPAIR TIPS

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-25-15

  • ALUMINUM BODY PANELS – CORROSION – SERVICE TIP
06-23-6

  • NOISE FROM BACK GLASS – POWER SLIDING REAR WINDOW ONLY
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-20-5

  • PARKING AID SPEAKER INOPERATIVE – DTCS C1742 AND C1743
06-19-16

  • SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION
06-19-14

  • NO CRANK / STARTER TERMINAL FATIGUE
06-19-13

  • RATTLE FROM TIP OUT ASHTRAY – VEHICLES BUILT PRIOR TO 1/1/2006
06-19-12

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V AND 5.4L 3V
06-19-8

  • TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE – 4.6L / 5.4L 3V
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-17-8

  • SERVICE WIRING HARNESS REPLACEMENT GUIDELINES – SERVICE TIPS
06-15-11

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
06-15-8

  • KEYPAD DIAGNOSTICS – DEALER INSTALLED ACCESSORY
06-15-2

  • SPARK PLUG REMOVAL INSTRUCTIONS – 5.4 3V
06-12-4

  • STEERING WHEEL NIBBLE AT OR ABOVE 60 MPH (100 KM/H) – VEHICLES BUILT PRIOR TO 8/20/2003
06-12-3

  • VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS
06-12-2

  • VEHICLE / STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER – STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER
06-11-12

  • 4X4 FRONT DIFFERENTIAL BRACKET REPAIR
06-10-9

  • FRAME REPLACEMENT MATRIX – SERVICE TIP