Technical Service Bulletins
|Publication Date: February 10, 2006|
This article supersedes TSB 05-22-20 to update the Service Procedure.
Some owners of 2004-2005 F-150’s may desire an alternative tire for off road use. Ford engineering has approved the replacement of the original equipment Passenger rated tires with LT245/70R17D Light Truck rated tires on vehicles with a gross vehicle weight (GVW) of 7200 lbs or less, equipped with specific 17″ wheels.
Verify the vehicle has a GVW of 7200 lbs or less, and has the appropriate wheels installed. If so, the original Passenger rated tires may be replaced with LT245/70R17D Light Truck rated tires at customer expense. The Light Truck rated tires are a different size and will require a different air pressure setting, so a new certification label will also need to be installed. Refer to the following Service Procedure.
|NOTE:||THIS TIRE CHANGE SHOULD NOT SIGNIFICANTLY AFFECT SPEEDOMETER ACCURACY. TIRE REVOLUTIONS PER MILE ON THE NEW TIRES IS 424. TIRE REVOLUTIONS PER MILE FOR THE ORIGINAL EQUIPMENT TIRES IS 404-434, DEPENDING ON BRAND AND STYLE.|
- Verify the vehicle has a GVW of 7200 lbs or less. If over 7200 lbs, do not continue with this TSB.
- Verify the vehicle is equipped with one (1) of the following wheels. If not, install one of the wheels listed with the new tires. Do not use any other wheels. The engineering number can be found on the wheel which may require the wheel and tire assembly to be removed from the vehicle.
Service Number Engineering Number 4L3Z-1007-AA 4L34-1007-AE 4L3Z-1015-CA 4L34-1015-CE 4L1Z-1015-AA 4L14-1015-AB 5L3Z-1015-DA (Spare) 5L34-1015-DA
- Replace original equipment Passenger rated tires with Light Truck rated LT245/70R17D tires. All four (4) tires and the spare tire must be converted to the same light truck tire at the same time. Tread type should be the same on all tires.
- Install the new tire certification label on the B-pillar, below the original certification label. The new label needs to be filled in to list the change in tire pressure which is required for the LT tires. The appropriate specifications are listed in Figure 1.
Figure 1 – Article 06-4-3
NOTE: THE CERTIFICATION LABEL MUST BE ORDERED FROM THE DEALERESTORE USING PART NUMBER FD-327. ACCESS THE ESTORE VIA THE LINK ON FMCDEALER (SALES > MARKETING & ADVERTISING > DEALER ESTORE) OR AT WWW.DEALERESTORE.COM.
Information Only – Not Warrantable
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.
Copyright Â© 2006 Ford Motor Company