Fulltext TSBs

Technical Service Bulletins

06-7-6

  • ABS LIGHT ON AND POSSIBLE DTCS C1175,
    C1236, P0500, P0503
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT
    REQUIREMENTS
06-6-6

  • BANGING/CLUNKING NOISE WHEN DRIVING –
    FRONT SUSPENSION BOTTOMS OUT
06-6-5

  • WATER-IN-FUEL (WIF) LAMP ON
06-6-1

  • DIAGNOSTIC PROCEDURE FOR TRAILER TOW
    LIGHTS – SERVICE TIP
06-5-11

  • BUCK/JERK STEADY THROTTLE OR SLIGHT
    TIP IN – 6.0L
06-5-10

  • MIL ON WITH DTC P0460 – 6.0L
06-5-8

  • SIDE GLASS SCRATCHED DUE TO COLLECTION
    OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING

06-4-12

  • COKING DEPOSIT DIAGNOSTICS AND SERVICE
    TIPS – 6.0L DIESEL
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW
    FREON – SHAFT SEAL LEAKS
06-4-8

  • 5.4L 3V MALFUNCTION INDICATOR LAMP ON
    WITH P0455 – LOW SPEED ENGINE SURGE – CALIBRATION
    UPDATE
06-4-7

  • TICKING AND/OR KNOCKING NOISE FROM
    ENGINE – 4.6L/5.4L 3V
06-4-6

  • HIGH PRESSURE SYSTEM DIAGNOSTICS –
    6.0L
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY
    EYE – CHARGING SERVICE TIPS
06-3-9

  • SERVICE CALIBRATION UPDATE – LOSS OF
    RPM ON DECELERATION – 6.8L 3V
06-3-8

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-3-3

  • 5.4L 3V WITH P030X AND/OR P0316
    ACCOMPANIED BY SPARK KNOCK
06-2-13

  • WHITE SMOKE, LACKS POWER, EXHAUST
    ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L

06-2-9

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V
    AND 5.4L 3V
06-2-4

  • EXHAUST SMOKE AND/OR SMELL, HARSH
    TRANSMISSION SHIFTS – 6.0L
05-26-25

  • MISFIRE, LACK OF POWER, BUCK/JERK,
    EXCESSIVE SMOKE, CRANK/NO START – 6.0L ENGINE –
    DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS

05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL
    RUNOUT
05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A
    STOP
05-25-11

  • BUMPER COVER WAVY/WARPED
05-23-15

  • 6.0L ENGINE OVERHEATING WITH A SNOW
    PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY
    INSTALLED SNOW PLOW PACKAGE
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON
    PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH
    RUNNING
05-22-3

  • LOW POWER – COLD SIDE CHARGE AIR
    COOLER (CAC) DISCONNECTED – OIL LEAK AT CAC
    CONNECTIONS – 6.0L ENGINE – VEHICLES BUILT 4/1/2004
    THROUGH 2/20/2005
05-22-1

  • STEERING WHEEL OSCILLATION
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY
    TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY
    DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR –
    6.0L
05-19-12

  • TURBO-INDUCED EXHAUST MOAN/DRONE AT
    1500-2000 RPM – 6.0L BUILT AFTER 9/29/2003

05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR
    WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING
    REPAIRS – SERVICE TIPS
05-18-6

  • MIL, DTCS P0172, P0175, P2106,
    HESITATION, SURGE, HARSH DRIVE ENGAGEMENTS

05-18-2

  • DTC P2106, HARSH DRIVE ENGAGEMENTS,
    TRANSMISSION SHUDDER – 5.4L 3V ENGINE

05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS
    CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST
    MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW
    CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L
    ENGINE
05-14-9

  • LACK OF A/C COOLING – CLIMATE CONTROL
    MODE SELECTION NOT WORKING
05-14-4

  • WRENCH LIGHT ON WITH BOTH DTC P2106
    AND P2135 – VEHICLES BUILT 11/29/2004 AND PRIOR

05-13-16

  • FEAD BELT FRAYED/SHREDDED/BROKEN –
    6.0L DIESEL ENGINE – VEHICLES BUILT THROUGH 1/1/2005

05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR
    AXLE – 6.0L AND 7.3L DIESEL ENGINE

05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L
    ENGINE
05-13-7

  • INSTRUMENT PANEL SCRATCH AND MAR –
    SERVICE TIP
05-13-5

  • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
    SIDE CHARGE AIR COOLER (CAC) DUCT – 6.0L DIESEL ENGINE

05-13-4

  • HARD START/LONG CRANK, ROUGH IDLE,
    ENGINE IDLE MISFIRE – MIL – DTCS P0300 THROUGH P0308,
    P0171, P0172, P0174, P0175, P0316, P2195, P2196,
    P2197, P2198
05-12-4

  • REAR AXLE LEAK – DANA S-110 REAR AXLE
05-12-3

  • CRANK NO START, HARD START, RUNS ROUGH
    AT IDLE – 6.0L
05-12-1

  • ENGINE QUITS UPON DRIVE OR REVERSE
    ENGAGEMENT, OR WHEN COMING TO A STOP – TORQSHIFT
    TRANSMISSION
05-11-14

  • VARIOUS ELECTRICAL AND/OR DRIVEABILITY
    SYMPTOMS AND/OR DTCS – PDB MINI FUSE LOOSE – VEHICLES
    BUILT BEFORE 05/11/2005
05-11-4

  • VARIOUS DRIVEABILITY SYMPTOMS –
    CALIBRATION UPDATE RELEASE – 6.0L DIESEL ENGINE

05-10-14

  • MIL ON AND DTCS P035X – 5.4L OR 6.8L
    ENGINE
05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH
    AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION
    PROMOTER USAGE INSTRUCTIONS
05-6-13

  • STEERING GEAR NOISE – 6.0L DIESEL
    ENGINE – VEHICLES BUILT BEFORE 11/24/2004

05-6-4

  • FALSE PARKING AID WARNINGS
05-5-7

  • LOW BATTERY VOLTAGE – SNOW PLOW
    EQUIPPED VEHICLES – 6.0L DIESEL WITH SINGLE GENERATOR

05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
05-3-6

  • 4X4 TRANSFER CASE JUMP OUT OF 4H OR 4L
    – MANUAL SHIFT TRANSFER CASE
05-1-2

  • TEMPERATURE GAUGE READS HOT
04-26-16

  • WELD BONDING PROCEDURE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL –
    LEATHER COMING LOOSE
04-23-9

  • WATER LEAK – ROOF FLANGE AREA – WATER
    ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
    PAN AREA
04-23-6

  • VEHICLE LEAN/SAG WHEN OBSERVED FROM
    REAR OF VEHICLE
04-20-10

  • TORQSHIFT TRANSMISSION AND PTO
    OPERATION – PTO LINE PRESSURE INSUFFICIENT – POSSIBLE
    TRANSMISSION DAMAGE
04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL –
    INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION