Fulltext TSBs

Technical Service Bulletins

06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-6-5

  • WATER-IN-FUEL (WIF) LAMP ON
06-4-12

  • COKING DEPOSIT DIAGNOSTICS AND SERVICE
    TIPS – 6.0L DIESEL
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-3-8

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-2-13

  • WHITE SMOKE, LACKS POWER, EXHAUST
    ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L

05-26-25

  • MISFIRE, LACK OF POWER, BUCK/JERK,
    EXCESSIVE SMOKE, CRANK/NO START – 6.0L ENGINE –
    DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS

05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-22-3

  • LOW POWER – COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED – OIL LEAK AT CAC CONNECTIONS – 6.0L ENGINE – VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR – 6.0L
05-19-12

  • TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM – 6.0L BUILT AFTER 9/29/2003
05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-17-16

  • DTC P0488 AND/OR P1334 WITH NO DRIVEABILITY SYMPTOMS, HARSH SHIFT AND/OR TRANSMISSION ENGAGEMENTS
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L ENGINE
05-13-16

  • FEAD BELT FRAYED/SHREDDED/BROKEN – 6.0L DIESEL ENGINE – VEHICLES BUILT THROUGH 1/1/2005
05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L ENGINE
05-13-5

  • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
    SIDE CHARGE AIR COOLER (CAC) DUCT – 6.0L DIESEL ENGINE

05-11-5

  • VARIOUS DIRVEABILITY CONDITIONS – 6.0L
    DIESEL – VEHICLES BUILT BEFORE 9/30/2003

05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
05-9-1

  • STEERING GEAR NOISE – 5.4L AND 6.8L ENGINE – SINGLE REAR WHEEL
05-6-4

  • FALSE PARKING AID WARNINGS
05-4-17

  • INTERMITTENT ROUGH IDLE – NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
04-25-16

  • MIL ILLUMINATED WITH DTC P0756, P0761 OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005 TORQSHIFT TRANSMISSION
04-24-5

  • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
04-23-8

  • STEERING GEAR NOISE – 6.0L DIESEL ENGINE
04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-18-6

  • DRIVEABILITY – NO START OR CONSTANT ENGINE MISFIRE – FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS – 6.0L DIESEL
04-18-5

  • AXLE – FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING
04-17-13

  • HARD START OR NO START – GPCM CONNECTOR SERVICE KIT AVAILABLE – 6.0L ENGINE
04-17-4

  • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S) – SERVICE TIPS
04-14-12

  • FRONT END ACCESSORY DRIVE (FEAD) BELT NOISE – VEHICLES BUILT PRIOR TO 6/1/2004 – 6.0L ENGINE
04-13-8

  • 6.0L ENGINE – LOW RPM, BUCK/JERK, MISS, STUMBLE – AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED
04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL – INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION
04-9-4

  • ENGINE – EXHAUST – TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM – 6.0L BUILT PRIOR TO 9/29/2003
  • NOISE – VIBRATION – TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM – 6.0L BUILT PRIOR TO 9/29/2003
04-9-3

  • DRIVEABILITY – RUNS ROUGH AND/OR LOW POWER – 6.0L DIESEL ENGINE ONLY
  • ENGINE – FUEL IN OIL – 6.0L DIESEL – INJECTOR DIAGNOSTICS
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT – SERVICE TIPS
03-20-12

  • DRIVEABILITY – VARIOUS DRIVEABILITY CONDITIONS – 6.0L DIT ENGINE – VEHICLES BUILT BEFORE 9/29/03 – CALIBRATION UPDATE – RUNNING CHANGE
03-20-10

  • DRIVEABILITY – FUEL SYSTEM – INJECTOR COMBUSTION SEAL – INSTALLATION PROCEDURE – SERVICE TIP – 6.0L ENGINE
  • ENGINE – FUEL SYSTEM – INJECTOR COMBUSTION SEAL – INSTALLATION PROCEDURE – SERVICE TIP – 6.0L ENGINE
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY (RKE) – SERVICE TIPS
03-11-2

  • SUSPENSION – ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
  • AXLE – ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
07-1-4

  • LACK OF COOLING FAN OPERATION – 6.0L
06-25-14

  • 6.0L – COKING DEPOSIT DIAGNOSTICS – SERVICE TIP
06-24-4

  • 6.0L – SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
06-24-1

  • 6.0L DIESEL ENGINE – OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
06-23-2

  • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS – LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P0478, P2262, AND/OR P2263
06-22-15

  • HEATER CORE LEAKS – 6.0L ENGINE
06-22-12

  • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
06-22-3

  • WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-10

  • 6.0L – REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION
06-21-2

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-19-6

  • 6.0L – MIL ON – P0401, P0402, P0404, P1335, LACK OF POWER, OR SURGE. EGR VALVE CLEANING PROCEDURE.
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-17-12

  • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
06-17-7

  • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS
06-14-4

  • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
06-13-3

  • MISFIRE, LACK OF POWER, BUCK / JERK, EXCESSIVE SMOKE, CRANK / NO START – 6.0L ENGINE – DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS