Fulltext TSBs

Technical Service Bulletins

06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-6-4

  • FALSE PARKING AID WARNINGS
05-4-17

  • INTERMITTENT ROUGH IDLE – NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
04-25-4

  • HARD START OR NO START – 7.3L
04-24-11

  • MOMENTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION – DIAGNOSTIC TROUBLE CODE (DTC) P0123 – 7.3L ENGINE
04-24-5

  • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
04-20-2

  • OIL LEAK – TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP) – 7.3L DIESEL
04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-18-5

  • AXLE – FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING
04-17-4

  • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED – SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S) – SERVICE TIPS
04-4-4

  • ENGINE – 7.3L DIESEL DI – HIGH PRESSURE OIL PUMP LEAK
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT – SERVICE TIPS
03-21-48

  • DRIVEABILITY – P0340 CAMSHAFT POSITION SENSOR FALSE DIAGNOSTIC TROUBLE CODE – VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE ONLY
  • TRANSMISSION – 4R100 – DELAYED 3-4 SHIFT – VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE ONLY
03-21-45

  • ENGINE – 7.3L – EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES
03-20-5

  • DRIVEABILITY – NO START/REPEAT STARTER FAILURE – REPEAT STARTER REPLACEMENT
  • ELECTRICAL – STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN
  • ENGINE – STARTING – STARTER STAYING ENGAGED AT START UP
03-20-3

  • DRIVEABILITY – MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY (RKE) – SERVICE TIPS
03-14-8

  • TRANSMISSION – NEW TRANSMISSION COOLER FLUSHER – SERVICE TIPS
03-14-3

  • SUSPENSION – 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT
  • AXLE – 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT
03-11-2

  • SUSPENSION – ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
  • AXLE – ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
03-9-11

  • DRIVEABILITY – ROUGH IDLE AND/OR HESITATION ON ACCELERATION – VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE ONLY
03-8-3

  • ENGINE – ENGINE OIL LEVEL INDICATOR MARKINGS – REPORTS OF LOW OIL LEVELS
03-4-5

  • DRIVEABILITY – “WAIT TO START” LAMP DOES NOT OPERATE PROPERLY
  • ELECTRICAL – LAMP – “WAIT TO START” LAMP DOES NOT OPERATE PROPERLY
03-4-1

  • FRONT LOCKING HUBS – SERVICE TIP
03-3-7

  • BODY – PAINT – NO CLEARCOAT BLENDING – COLLISION MANUAL CHANGE
02-25-2

  • ELECTRICAL – CDX6 RADIO DAMAGED DURING SERVICE SHIPPING – CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO – SERVICE TIPS
02-23-7

  • COOLING SYSTEM – MOTORCRAFT PREMIUM GOLD ENGINE COOLANT – SERVICE TIPS
02-21-13

  • ENGINE – STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
02-21-1

  • TRANSMISSION – 4R100/E4OD – TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
02-17-6

  • LAMP – BRAKE – INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
02-16-4

  • FUEL SYSTEM – FUEL PUMP “WHINING”/”BUZZING” NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER
  • RADIO – ENTERTAINMENT OR TWO-WAY COMMUNICATION – “WHINING”/”BUZZING” NOISE IN SPEAKERS CAUSED BY FUEL PUMP
  • NOISE – “WHINING”/”BUZZING” – COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
02-16-3

  • PAINT – NEW POLISHING PRODUCTS – SERVICE PROCEDURES
02-11-4

  • ENGINE – NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
02-5-6

  • SHEET METAL – PRIMED SERVICE PARTS – PREP PROCEDURE AND MSDS INFORMATION
02-1-9

  • ENGINE – ENGINE OIL – RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS – GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
01-24-7

  • BODY – TOP SURFACE OF REAR CARGO DOORS SCRATCHED
01-24-6

  • ENGINE – ENGINE OIL SYSTEM PRIMING
    PROCEDURES – SERVICE TIPS
01-23-6

  • ENGINE COOLANT – PROPYLENE GLYCOL – FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL
  • ENGINE COOLANT – PROPYLENE GLYCOL-BASED – FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
01-21-13

  • DRIVEABILITY – DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY – STICKING OR BINDING IGNITION LOCK CYLINDER – HIGH EFFORT WHEN TURNING IGNITION SWITCH
  • ELECTRICAL – STICKING OR BINDING IGNITION LOCK CYLINDER – HIGH EFFORT WHEN TURNING IGNITION SWITCH
01-15-6

  • CLIMATE CONTROL – REPEAT HEATER CORE
    FAILURE
  • COOLING SYSTEM – REPEAT HEATER CORE
    FAILURE
01-10-12

  • WIRING – WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-17-7

  • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS
06-14-4

  • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.