Fulltext TSBs

Technical Service Bulletins

06-8-5

  • SPEED CONTROL DIAGNOSTICS – W/O SCP
06-6-5

  • WATER-IN-FUEL (WIF) LAMP ON
06-6-1

  • DIAGNOSTIC PROCEDURE FOR TRAILER TOW
    LIGHTS – SERVICE TIP
06-4-12

  • COKING DEPOSIT DIAGNOSTICS AND SERVICE
    TIPS – 6.0L DIESEL
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW
    FREON – SHAFT SEAL LEAKS
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY
    EYE – CHARGING SERVICE TIPS
06-3-8

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-2-13

  • WHITE SMOKE, LACKS POWER, EXHAUST
    ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L

05-26-25

  • MISFIRE, LACK OF POWER, BUCK/JERK,
    EXCESSIVE SMOKE, CRANK/NO START – 6.0L ENGINE –
    DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS

05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A
    STOP
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON
    PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH
    RUNNING
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY
    TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY
    DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR –
    6.0L
05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR
    WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING
    REPAIRS – SERVICE TIPS
05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS
    CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST
    MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW
    CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L
    ENGINE
05-13-16

  • FEAD BELT FRAYED/SHREDDED/BROKEN –
    6.0L DIESEL ENGINE – VEHICLES BUILT THROUGH 1/1/2005

05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR
    AXLE – 6.0L AND 7.3L DIESEL ENGINE

05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L
    ENGINE
05-13-5

  • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
    SIDE CHARGE AIR COOLER (CAC) DUCT – 6.0L DIESEL ENGINE

05-11-5

  • VARIOUS DIRVEABILITY CONDITIONS – 6.0L
    DIESEL – VEHICLES BUILT BEFORE 9/30/2003

05-6-4

  • FALSE PARKING AID WARNINGS
05-5-7

  • LOW BATTERY VOLTAGE – SNOW PLOW
    EQUIPPED VEHICLES – 6.0L DIESEL WITH SINGLE GENERATOR

05-5-4

  • USE OF STAINLESS STEEL EXHAUST STUDS
    IN SERVICE FOR 5.4L 2V ENGINE
05-4-17

  • INTERMITTENT ROUGH IDLE –
    NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
04-25-16

  • MIL ILLUMINATED WITH DTC P0756, P0761
    OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005
    TORQSHIFT TRANSMISSION
04-25-4

  • HARD START OR NO START – 7.3L
04-24-22

  • LOSS OF POWER OR STUMBLE WHILE DRIVING
    IN RAIN – 6.8L ENGINE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-11

  • MOMENTARY RETURN TO IDLE DURING
    AGGRESSIVE ACCELERATION – DIAGNOSTIC TROUBLE CODE
    (DTC) P0123 – 7.3L ENGINE
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL –
    LEATHER COMING LOOSE
04-23-9

  • WATER LEAK – ROOF FLANGE AREA – WATER
    ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
    PAN AREA
04-23-6

  • VEHICLE LEAN/SAG WHEN OBSERVED FROM
    REAR OF VEHICLE
04-20-2

  • OIL LEAK – TURBO PEDESTAL SEAL AT
    EXHAUST BACK PRESSURE ACTUATOR (EBP) – 7.3L DIESEL

04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-18-6

  • DRIVEABILITY – NO START OR CONSTANT
    ENGINE MISFIRE – FUEL INJECTION CONTROL MODULE (FICM)
    DIAGNOSIS – 6.0L DIESEL
04-18-5

  • AXLE – FRONT HUBS NOT ENGAGING, NOT
    STAYING ENGAGED AND/OR UNLOCKING

04-17-13

  • HARD START OR NO START – GPCM
    CONNECTOR SERVICE KIT AVAILABLE – 6.0L ENGINE

04-17-4

  • MALFUNCTION INDICATOR LAMP (MIL)
    ILLUMINATED – SYSTEM LEAN DIAGNOSTIC TROUBLE CODES
    (DTC’S) – SERVICE TIPS
04-16-4

  • REAR AXLE POPPING/CHATTER NOISE – DANA
    80 MODEL DUAL REAR WHEEL (DRW)
04-15-10

  • OVERHEAD TRIP COMPUTER (OTC) DISTANCE
    TO EMPTY (DTE) INCORRECT
04-14-12

  • FRONT END ACCESSORY DRIVE (FEAD) BELT
    NOISE – VEHICLES BUILT PRIOR TO 6/1/2004 – 6.0L ENGINE

04-11-2

  • SUSPENSION – VEHICLE SWAY/LEAN DURING
    LOW SPEED TURNING MANEUVERS
  • NOISE – SUSPENSION – POPPING NOISE IN
    FRONT END
04-9-4

  • ENGINE – EXHAUST – TURBO-INDUCED
    EXHAUST MOAN/DRONE AT 1600-1800 RPM – 6.0L BUILT PRIOR
    TO 9/29/2003
  • NOISE – VIBRATION – TURBO-INDUCED
    EXHAUST MOAN/DRONE AT 1600-1800 RPM – 6.0L BUILT PRIOR
    TO 9/29/2003
04-9-3

  • DRIVEABILITY – RUNS ROUGH AND/OR LOW
    POWER – 6.0L DIESEL ENGINE ONLY
  • ENGINE – FUEL IN OIL – 6.0L DIESEL –
    INJECTOR DIAGNOSTICS
04-4-4

  • ENGINE – 7.3L DIESEL DI – HIGH
    PRESSURE OIL PUMP LEAK
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS
    AND MOTOR REPLACEMENT – SERVICE TIPS

03-22-2

  • NOISE – DRIVESHAFT CENTER BEARING
    NOISE – VEHICLES BUILT AFTER 6/1/2002
  • DRIVESHAFT – DRIVESHAFT CENTER BEARING
    NOISE – VEHICLES BUILT AFTER 6/1/2002

03-21-45

  • ENGINE – 7.3L – EXTERNAL OIL LEAK
    DIAGNOSIS FOR 7.3L DIT ENGINES
03-20-12

  • DRIVEABILITY – VARIOUS DRIVEABILITY
    CONDITIONS – 6.0L DIT ENGINE – VEHICLES BUILT BEFORE
    9/29/03 – CALIBRATION UPDATE – RUNNING CHANGE

03-20-10

  • DRIVEABILITY – FUEL SYSTEM – INJECTOR
    COMBUSTION SEAL – INSTALLATION PROCEDURE – SERVICE TIP
    – 6.0L ENGINE
  • ENGINE – FUEL SYSTEM – INJECTOR
    COMBUSTION SEAL – INSTALLATION PROCEDURE – SERVICE TIP
    – 6.0L ENGINE
03-20-5

  • DRIVEABILITY – NO START/REPEAT STARTER
    FAILURE – REPEAT STARTER REPLACEMENT
  • ELECTRICAL – STICKING OR BINDING
    IGNITION LOCK CYLINDER BETWEEN START AND RUN
  • ENGINE – STARTING – STARTER STAYING
    ENGAGED AT START UP
03-20-3

  • DRIVEABILITY – MALFUNCTION INDICATOR
    LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456,
    P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
    DTC P0457
03-19-10

  • BRAKES – BRAKE PULL – 4X4 F-250/350
    AND 4X4 EXCURSION VEHICLES ONLY
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY
    (RKE) – SERVICE TIPS
03-17-4

  • STEERING – STEERING WHEEL FIGHT AFTER
    RIDING OVER BUMPS/RUTS
03-14-8

  • TRANSMISSION – NEW TRANSMISSION COOLER
    FLUSHER – SERVICE TIPS
03-14-3

  • SUSPENSION – 4X4 WHEEL HUB
    NON-ENGAGEMENT/DISENGAGEMENT
  • AXLE – 4X4 WHEEL HUB
    NON-ENGAGEMENT/DISENGAGEMENT
03-11-10

  • BODY – WATER LEAK FROM ROOF OPENING
    PANEL – ROOF OPENING PANEL BINDS OR WILL NOT OPEN
    PROPERLY
  • NOISE – RATTLE FROM ROOF OPENING PANEL
    AREA
03-11-2

  • SUSPENSION – ON-VEHICLE FRONT
    INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
  • AXLE – ON-VEHICLE FRONT INTEGRATED
    HUB/BEARING ROCKING END-PLAY MEASUREMENT

03-9-11

  • DRIVEABILITY – ROUGH IDLE AND/OR
    HESITATION ON ACCELERATION – VEHICLES EQUIPPED WITH
    5.4L OR 6.8L ENGINE ONLY
03-8-3

  • ENGINE – ENGINE OIL LEVEL INDICATOR
    MARKINGS – REPORTS OF LOW OIL LEVELS

03-4-5

  • DRIVEABILITY – “WAIT TO START” LAMP
    DOES NOT OPERATE PROPERLY
  • ELECTRICAL – LAMP – “WAIT TO START”
    LAMP DOES NOT OPERATE PROPERLY
03-4-1

  • FRONT LOCKING HUBS – SERVICE TIP
03-3-7

  • BODY – PAINT – NO CLEARCOAT BLENDING –
    COLLISION MANUAL CHANGE
03-1-9

  • ENGINE – 6.0L DIESEL – AIR FILTER
    SERVICE, REMOVAL OR REPLACEMENT – SERVICE TIPS

02-25-2

  • ELECTRICAL – CDX6 RADIO DAMAGED DURING
    SERVICE SHIPPING – CORRECT SHIPMENT PROCEDURES FOR
    CDX6 RADIO – SERVICE TIPS
02-23-7

  • COOLING SYSTEM – MOTORCRAFT PREMIUM
    GOLD ENGINE COOLANT – SERVICE TIPS

02-21-13

  • ENGINE – STRAIGHTEDGE PROCEDURE FOR
    CHECKING CYLINDER HEAD AND BLOCK FLATNESS

02-21-1

  • TRANSMISSION – 4R100/E4OD – TORQUE
    CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
    DISLODGED
02-17-12

  • MOTORHOME GENERATORS – SHUT OFF WHEN
    FUEL TANK READS 1/4 FULL
02-17-6

  • LAMP – BRAKE – INADVERTENT DISABLING
    OF BRAKE SHIFT INTERLOCK
02-16-7

  • BODY – PAINT – APPROVED PAINT
    MATERIALS FOR WARRANTY REPAIRS
02-16-3

  • PAINT – NEW POLISHING PRODUCTS –
    SERVICE PROCEDURES