Fulltext TSBs

Technical Service Bulletins

06-7-6

  • ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503
06-7-4

  • STUCK OR JUMPING / BOUNCING / ERRATIC SPEEDOMETER AND/OR TACHOMETER
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT REQUIREMENTS
06-6-6

  • BANGING/CLUNKING NOISE WHEN DRIVING – FRONT SUSPENSION BOTTOMS OUT
06-6-1

  • DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS – SERVICE TIP
06-5-11

  • BUCK/JERK STEADY THROTTLE OR SLIGHT
    TIP IN – 6.0L
06-5-10

  • MIL ON WITH DTC P0460 – 6.0L
06-5-8

  • SIDE GLASS SCRATCHED DUE TO COLLECTION
    OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING

06-4-12

  • COKING DEPOSIT DIAGNOSTICS AND SERVICE
    TIPS – 6.0L DIESEL
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-8

  • 5.4L 3V MALFUNCTION INDICATOR LAMP ON WITH P0455 – LOW SPEED ENGINE SURGE – CALIBRATION UPDATE
06-4-6

  • HIGH PRESSURE SYSTEM DIAGNOSTICS –
    6.0L
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-3-9

  • SERVICE CALIBRATION UPDATE – LOSS OF
    RPM ON DECELERATION – 6.8L 3V
06-3-8

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-2-13

  • WHITE SMOKE, LACKS POWER, EXHAUST
    ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L

06-2-9

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V
    AND 5.4L 3V
06-2-4

  • EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS – 6.0L
05-26-25

  • MISFIRE, LACK OF POWER, BUCK/JERK,
    EXCESSIVE SMOKE, CRANK/NO START – 6.0L ENGINE –
    DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS

05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A STOP
05-25-11

  • BUMPER COVER WAVY/WARPED
05-23-15

  • 6.0L ENGINE OVERHEATING WITH A SNOW
    PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY
    INSTALLED SNOW PLOW PACKAGE
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-22-1

  • STEERING WHEEL OSCILLATION
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR – 6.0L
05-19-12

  • TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM – 6.0L BUILT AFTER 9/29/2003
05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-18-6

  • MIL, DTCS P0172, P0175, P2106, HESITATION, SURGE, HARSH DRIVE ENGAGEMENTS
05-18-2

  • DTC P2106, HARSH DRIVE ENGAGEMENTS, TRANSMISSION SHUDDER – 5.4L 3V ENGINE
05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L ENGINE
05-14-9

  • LACK OF A/C COOLING – CLIMATE CONTROL MODE SELECTION NOT WORKING
05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR AXLE – 6.0L AND 7.3L DIESEL ENGINE
05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L ENGINE
05-13-5

  • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
    SIDE CHARGE AIR COOLER (CAC) DUCT – 6.0L DIESEL ENGINE

05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
07-1-4

  • LACK OF COOLING FAN OPERATION – 6.0L
06-26-5

  • KING RANCH CREW CAB MODEL ONLY – WHITE CORROSION ON RUNNING BOARDS
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-25-14

  • 6.0L – COKING DEPOSIT DIAGNOSTICS – SERVICE TIP
06-25-8

  • SERVICE CALIBRATION UPDATE – LOSS OF RPM ON DECELERATION – 6.8L ENGINE
06-24-12

  • 6.0L ENGINE OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE
06-24-4

  • 6.0L – SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
06-24-1

  • 6.0L DIESEL ENGINE – OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
06-23-9

  • HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP
06-23-4

  • DRIVE-AWAY SHUDDER OR VIBRATION
06-23-2

  • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS – LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P0478, P2262, AND/OR P2263
06-22-15

  • HEATER CORE LEAKS – 6.0L ENGINE
06-22-14

  • STEERING WHEEL OSCILLATION
06-22-12

  • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
06-22-11

  • POWER STEERING FLUID LEAK AT JUMPER LINE TO HYDROBOOST CONNECTION – VEHICLES BUILT BEFORE 5/25/2006
06-22-9

  • 6.0L – MIL ON WITH DTC P2138, P2139, AND P2140
06-22-6

  • BUCK/JERK STEADY THROTTLE OR SLIGHT TIP IN – 6.0L – BUILT ON OR BEFORE 3/15/2006
06-22-3

  • WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-15

  • MIL ON – DTC P1285 / P1299 – 5.4L 3V / 6.8L 3V – FALSE OVERHEAT
06-21-10

  • 6.0L – REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION
06-21-7

  • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-21-2

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-20-8

  • EXHAUST SYSTEM NOISE – SNAP / POP / TICK / PING – 5.4L AND 6.8L ENGINES – VEHICLES BUILT ON OR BEFORE 9/8/2006
06-20-5

  • PARKING AID SPEAKER INOPERATIVE – DTCS C1742 AND C1743
06-19-15

  • SLOW FUEL FILL
06-19-14

  • NO CRANK / STARTER TERMINAL FATIGUE
06-19-12

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V AND 5.4L 3V
06-19-6

  • 6.0L – MIL ON – P0401, P0402, P0404, P1335, LACK OF POWER, OR SURGE. EGR VALVE CLEANING PROCEDURE.
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-18-2

  • SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING
06-17-12

  • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
06-17-7

  • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS
06-17-6

  • HIGH PRESSURE SYSTEM DIAGNOSTICS – 6.0L
06-16-2

  • FRONT WHEEL BEARING NOISE – F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006
06-16-1

  • CHROME TOW HOOKS RUSTING PREMATURELY – VEHICLES BUILT PRIOR TO 7/17/2006
06-15-11

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
06-15-8

  • KEYPAD DIAGNOSTICS – DEALER INSTALLED ACCESSORY
06-15-5

  • SLIDING POWER WINDOW (BACK GLASS) SERVICE PROCEDURE
06-13-11

  • 6.0L – MIL ON WITH DTC P0460
06-13-3

  • MISFIRE, LACK OF POWER, BUCK / JERK, EXCESSIVE SMOKE, CRANK / NO START – 6.0L ENGINE – DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS
06-9-11

  • LOUD TICKING NOISE – 3-VALVE ENGINES – STUCK LASH ADJUSTER
07-2-7

  • 6.0L – REDUCED ENGINE PERFORMANCE – HIGH ALTITUDE
07-3-10

  • LACK OF COOLING FAN OPERATION – 6.0L
07-4-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
07-5-8

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
07-5-11

  • VIBRATION/HOP AT 40-48 MPH (68-77 KM/H) – (8.0 HZ) – TRAILER HITCH EQUIPPED VEHICLES ONLY
07-5-15

  • 6.0L – OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
07-6-9

  • 6.0L DIESEL ENGINE – BUCK/JERK WHEN PULLING LARGE/HEAVY GOOSE NECK TRAILERS
07-7-2

  • REAR OF VEHICLE IS TOO HIGH/LOW – 5TH WHEEL AND GOOSE NECK APPLICATIONS – 4X4 VEHICLES ONLY
07-9-8

  • ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503
07-10-4

  • 6.0L – SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
07-10-5

  • FRONT DOOR SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW MOLDING
07-10-10

  • STEERING WHEEL OSCILLATION
07-11-2

  • STUCK OR JUMPING / BOUNCING / ERRATIC SPEEDOMETER AND/OR TACHOMETER
07-11-5

  • DIESEL ENGINE – OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE
07-11-10

  • BRAKE PEDAL KICKBACK OR GRABBING
07-11-11

  • 5.4L AND 6.8L ENGINES – EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE – VEHICLES BUILT ON OR BEFORE 9/8/20065.4L AND 6.8L ENGINES – EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE – VEHICLES BUILT ON OR BEFORE 9/8/2006
07-13-7

  • DRIVELINE NOISE UNDER LIGHT LOAD – 40-50 MPH (64-80 KM/H) – 6.0L REGULAR CAB 4X2 WITH 137 INCH WHEELBASE
07-14-8

  • ERRATIC SHIFTS – SPEEDS ABOVE 50 MPH (80 KM/H) AND/OR ENGAGEMENT SHUDDER
07-18-4

  • 6.0L – INTERMITTENT MIL ON AND/OR INTERMITTENT DTC P0470 – TEMPERATURES BELOW FREEZING
07-21-7

  • 5.4L GAS ENGINES – DTC P0171, P0172, P0174, P0175 WITH OR WITHOUT DRIVABILITY CONCERNS – CRUISE CONTROL SURGE
07-25-2

  • TAILGATE STRIKER – NOISE/RATTLE
07-26-1

  • BELT CHIRP – POWER STEERING PUMP PULLEY ALIGNMENT – 6.0L – VEHICLES BUILT BETWEEN 1/1/2006 – 8/31/2006
08-7-6

  • SPARK PLUG REMOVAL INSTRUCTIONS – 4.6L 3V/5.4L 3V/6.8L 3V
08-12-6

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
08-13-5

  • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
08-18-2

  • MIL ON – P0506 AND/OR P0505 – HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM
08-23-1

  • 6.0L DIESEL COOLING SYSTEM CONTAMINATION FLUSH PROCEDURE
08-24-2

  • VIBRATION DIAGNOSTICS – STEERING WHEEL NIBBLE – TIRE WHEEL RUNOUT AND BALANCE
08-24-8

  • WATER LEAKS – ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH
08-26-12

  • 6.0L – COKING DEPOSITS DIAGNOSTIC – EGR DTCS P0401, P0402, P0404, P1335
09-7-10

  • DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS – SERVICE TIP
09-8-3

  • COOLANT LOSS – 6.0L
09-8-5

  • DIESEL COOLANT MAINTENANCE – SERVICE TIPS
09-16-5

  • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS
09-18-12

  • COOLING SYSTEM DIAGNOSTICS – OIL IN ENGINE COOLANT – 6.0L
09-20-12

  • SLOW FUEL FILL – 5.4 AND 6.8 ENGINES
09-22-1

  • 4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES
09-22-8

  • STAINLESS STEEL EXHAUST STUDS – 5.4L AND 6.8L 2V ENGINES
09-22-16

  • 6.0L DIESEL-DRIVEABILITY-NO START/HARD START/LONG CRANK/MISFIRE/RUNS ROUGH/LACK OF POWER/BUCK/JERK OR EXCESSIVE EXHAUST SMOKE DIAGNOSIS
09-24-3

  • 6.0L DIESEL CALIBRATION UPDATE – VARIOUS ISSUES
09-26-1

  • 6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS – BUILT ON OR BEFORE 9/30/2008
10-1-11

  • 4X4 ONLY – BANGING/CLUNKING NOISE WHEN DRIVING – CONTACT WITH JOUNCE BUMPER – COLD TEMPERATURES