Fulltext TSBs

Technical Service Bulletins

06-7-6

  • ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT REQUIREMENTS
06-6-6

  • BANGING/CLUNKING NOISE WHEN DRIVING – FRONT SUSPENSION BOTTOMS OUT
06-6-5

  • WATER-IN-FUEL (WIF) LAMP ON
06-6-1

  • DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS – SERVICE TIP
06-5-11

  • BUCK/JERK STEADY THROTTLE OR SLIGHT
    TIP IN – 6.0L
06-5-10

  • MIL ON WITH DTC P0460 – 6.0L
06-5-8

  • SIDE GLASS SCRATCHED DUE TO COLLECTION
    OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING

06-4-12

  • COKING DEPOSIT DIAGNOSTICS AND SERVICE
    TIPS – 6.0L DIESEL
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-8

  • 5.4L 3V MALFUNCTION INDICATOR LAMP ON WITH P0455 – LOW SPEED ENGINE SURGE – CALIBRATION UPDATE
06-4-7

  • TICKING AND/OR KNOCKING NOISE FROM
    ENGINE – 4.6L/5.4L 3V
06-4-6

  • HIGH PRESSURE SYSTEM DIAGNOSTICS –
    6.0L
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-3-9

  • SERVICE CALIBRATION UPDATE – LOSS OF
    RPM ON DECELERATION – 6.8L 3V
06-3-8

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-3-3

  • 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK
06-2-13

  • WHITE SMOKE, LACKS POWER, EXHAUST
    ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L

06-2-9

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V
    AND 5.4L 3V
06-2-4

  • EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS – 6.0L
05-26-25

  • MISFIRE, LACK OF POWER, BUCK/JERK,
    EXCESSIVE SMOKE, CRANK/NO START – 6.0L ENGINE –
    DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS

05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A STOP
05-25-11

  • BUMPER COVER WAVY/WARPED
05-23-15

  • 6.0L ENGINE OVERHEATING WITH A SNOW
    PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY
    INSTALLED SNOW PLOW PACKAGE
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-22-3

  • LOW POWER – COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED – OIL LEAK AT CAC CONNECTIONS – 6.0L ENGINE – VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005
05-22-1

  • STEERING WHEEL OSCILLATION
05-21-9

  • WHINE/WHISTLE NOISE – 6.0L
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-20-1

  • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
05-19-14

  • LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR – 6.0L
05-19-12

  • TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM – 6.0L BUILT AFTER 9/29/2003
05-18-8

  • SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-18-6

  • MIL, DTCS P0172, P0175, P2106, HESITATION, SURGE, HARSH DRIVE ENGAGEMENTS
05-18-2

  • DTC P2106, HARSH DRIVE ENGAGEMENTS, TRANSMISSION SHUDDER – 5.4L 3V ENGINE
05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST MODE
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-16-6

  • MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP – 6.0L ENGINE
05-14-9

  • LACK OF A/C COOLING – CLIMATE CONTROL MODE SELECTION NOT WORKING
05-14-4

  • WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 – VEHICLES BUILT 11/29/2004 AND PRIOR
05-13-16

  • FEAD BELT FRAYED/SHREDDED/BROKEN – 6.0L DIESEL ENGINE – VEHICLES BUILT THROUGH 1/1/2005
05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR AXLE – 6.0L AND 7.3L DIESEL ENGINE
05-13-9

  • DIESEL EXHAUST SMELL IN CAB – 6.0L ENGINE
05-13-7

  • INSTRUMENT PANEL SCRATCH AND MAR – SERVICE TIP
05-13-5

  • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
    SIDE CHARGE AIR COOLER (CAC) DUCT – 6.0L DIESEL ENGINE

05-13-4

  • HARD START/LONG CRANK, ROUGH IDLE, ENGINE IDLE MISFIRE – MIL – DTCS P0300 THROUGH P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198
05-12-4

  • REAR AXLE LEAK – DANA S-110 REAR AXLE
05-12-3

  • CRANK NO START, HARD START, RUNS ROUGH AT IDLE – 6.0L
05-12-1

  • ENGINE QUITS UPON DRIVE OR REVERSE ENGAGEMENT, OR WHEN COMING TO A STOP – TORQSHIFT TRANSMISSION
05-11-14

  • VARIOUS ELECTRICAL AND/OR DRIVEABILITY SYMPTOMS AND/OR DTCS – PDB MINI FUSE LOOSE – VEHICLES BUILT BEFORE 05/11/2005
05-11-4

  • VARIOUS DRIVEABILITY SYMPTOMS – CALIBRATION UPDATE RELEASE – 6.0L DIESEL ENGINE
05-10-14

  • MIL ON AND DTCS P035X – 5.4L OR 6.8L ENGINE
05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
05-6-13

  • STEERING GEAR NOISE – 6.0L DIESEL ENGINE – VEHICLES BUILT BEFORE 11/24/2004
05-6-4

  • FALSE PARKING AID WARNINGS
05-5-7

  • LOW BATTERY VOLTAGE – SNOW PLOW EQUIPPED VEHICLES – 6.0L DIESEL WITH SINGLE GENERATOR
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
05-3-6

  • 4X4 TRANSFER CASE JUMP OUT OF 4H OR 4L – MANUAL SHIFT TRANSFER CASE
05-1-2

  • TEMPERATURE GAUGE READS HOT
04-26-16

  • WELD BONDING PROCEDURE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
04-23-9

  • WATER LEAK – ROOF FLANGE AREA – WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA
04-23-6

  • VEHICLE LEAN/SAG WHEN OBSERVED FROM REAR OF VEHICLE
04-20-10

  • TORQSHIFT TRANSMISSION AND PTO OPERATION – PTO LINE PRESSURE INSUFFICIENT – POSSIBLE TRANSMISSION DAMAGE
04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL – INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
07-1-4

  • LACK OF COOLING FAN OPERATION – 6.0L
06-26-5

  • KING RANCH CREW CAB MODEL ONLY – WHITE CORROSION ON RUNNING BOARDS
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-25-14

  • 6.0L – COKING DEPOSIT DIAGNOSTICS – SERVICE TIP
06-25-8

  • SERVICE CALIBRATION UPDATE – LOSS OF RPM ON DECELERATION – 6.8L ENGINE
06-24-12

  • 6.0L ENGINE OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE
06-24-4

  • 6.0L – SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
06-24-1

  • 6.0L DIESEL ENGINE – OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
06-23-9

  • HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP
06-23-4

  • DRIVE-AWAY SHUDDER OR VIBRATION
06-23-2

  • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS – LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P0478, P2262, AND/OR P2263
06-22-15

  • HEATER CORE LEAKS – 6.0L ENGINE
06-22-14

  • STEERING WHEEL OSCILLATION
06-22-12

  • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
06-22-11

  • POWER STEERING FLUID LEAK AT JUMPER LINE TO HYDROBOOST CONNECTION – VEHICLES BUILT BEFORE 5/25/2006
06-22-9

  • 6.0L – MIL ON WITH DTC P2138, P2139, AND P2140
06-22-6

  • BUCK/JERK STEADY THROTTLE OR SLIGHT TIP IN – 6.0L – BUILT ON OR BEFORE 3/15/2006
06-22-3

  • WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START – 6.0L
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-15

  • MIL ON – DTC P1285 / P1299 – 5.4L 3V / 6.8L 3V – FALSE OVERHEAT
06-21-10

  • 6.0L – REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION
06-21-7

  • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-21-2

  • COOLANT DEGAS BOTTLE OVERFLOW – 6.0L
06-20-8

  • EXHAUST SYSTEM NOISE – SNAP / POP / TICK / PING – 5.4L AND 6.8L ENGINES – VEHICLES BUILT ON OR BEFORE 9/8/2006
06-20-5

  • PARKING AID SPEAKER INOPERATIVE – DTCS C1742 AND C1743
06-19-15

  • SLOW FUEL FILL
06-19-14

  • NO CRANK / STARTER TERMINAL FATIGUE
06-19-12

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V AND 5.4L 3V
06-19-8

  • TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE – 4.6L / 5.4L 3V
06-19-6

  • 6.0L – MIL ON – P0401, P0402, P0404, P1335, LACK OF POWER, OR SURGE. EGR VALVE CLEANING PROCEDURE.
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-18-2

  • SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING
06-17-12

  • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
06-17-7

  • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS
06-17-6

  • HIGH PRESSURE SYSTEM DIAGNOSTICS – 6.0L
06-16-2

  • FRONT WHEEL BEARING NOISE – F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006
06-16-1

  • CHROME TOW HOOKS RUSTING PREMATURELY – VEHICLES BUILT PRIOR TO 7/17/2006
06-15-11

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
06-15-8

  • KEYPAD DIAGNOSTICS – DEALER INSTALLED ACCESSORY
06-15-5

  • SLIDING POWER WINDOW (BACK GLASS) SERVICE PROCEDURE
06-15-2

  • SPARK PLUG REMOVAL INSTRUCTIONS – 5.4 3V
06-13-11

  • 6.0L – MIL ON WITH DTC P0460
06-13-3

  • MISFIRE, LACK OF POWER, BUCK / JERK, EXCESSIVE SMOKE, CRANK / NO START – 6.0L ENGINE – DIAGNOSTICS FOR FUEL SYSTEM – SERVICE TIPS