Fulltext TSBs

Technical Service Bulletins

06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY
    EYE – CHARGING SERVICE TIPS
05-26-10

  • CLUNK OR BUMP WHEN STARTING FROM A
    STOP
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON
    PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH
    RUNNING
05-20-3

  • OIL PAN CORROSION – 7.3L OR 6.0L
05-17-6

  • DRIVE-AWAY SHUDDER OR VIBRATION
05-17-4

  • VACUUM PUMP INOPERATIVE OR RUNS
    CONTINUOUSLY – CLIMATE CONTROL DEFAULTS TO DEFROST
    MODE
05-13-15

  • WATER IN THE FUEL TANK BEHIND REAR
    AXLE – 6.0L AND 7.3L DIESEL ENGINE

05-5-4

  • USE OF STAINLESS STEEL EXHAUST STUDS
    IN SERVICE FOR 5.4L 2V ENGINE
05-4-17

  • INTERMITTENT ROUGH IDLE –
    NON-COMMANDED EGR FLOW
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
04-24-22

  • LOSS OF POWER OR STUMBLE WHILE DRIVING
    IN RAIN – 6.8L ENGINE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL –
    LEATHER COMING LOOSE
04-23-9

  • WATER LEAK – ROOF FLANGE AREA – WATER
    ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
    PAN AREA
04-23-6

  • VEHICLE LEAN/SAG WHEN OBSERVED FROM
    REAR OF VEHICLE
04-20-2

  • OIL LEAK – TURBO PEDESTAL SEAL AT
    EXHAUST BACK PRESSURE ACTUATOR (EBP) – 7.3L DIESEL

04-18-15

  • ADDING ADDITIONAL BULBS TO TURN
    INDICATOR OR HAZARD FLASHER CIRCUITS – SERVICE TIPS

04-18-11

  • BODY-CORROSION AT BOTTOM OF DOOR OR
    TAILGATE HEM FLANGE – REPAIR PROCEDURE

04-18-5

  • AXLE – FRONT HUBS NOT ENGAGING, NOT
    STAYING ENGAGED AND/OR UNLOCKING

04-16-4

  • REAR AXLE POPPING/CHATTER NOISE – DANA
    80 MODEL DUAL REAR WHEEL (DRW)
04-4-4

  • ENGINE – 7.3L DIESEL DI – HIGH
    PRESSURE OIL PUMP LEAK
03-23-2

  • BODY – MIRROR – EXTERIOR MIRROR GLASS
    AND MOTOR REPLACEMENT – SERVICE TIPS

03-21-49

  • DRIVEABILITY – LOSS OF POWER AND
    EXTERNAL TURBO OIL LEAK – 7.3L DIESEL
  • ENGINE – 7.3L DIESEL – LOSS OF POWER
    AND EXTERNAL TURBO OIL LEAK
  • NOISE – EXHAUST NOISE FROM TURBO –
    7.3L DIESEL
03-21-45

  • ENGINE – 7.3L – EXTERNAL OIL LEAK
    DIAGNOSIS FOR 7.3L DIT ENGINES
03-21-44

  • NO START – STARTER MOTOR GEAR TEETH
    DAMAGE – VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE –
    MEXICO PRODUCED VEHICLES ONLY
  • ENGINE – 7.3L DIESEL – NO START –
    STARTER MOTOR GEAR TEETH DAMAGE – MEXICO PRODUCED
    VEHICLES ONLY
  • NOISE – STARTER MOTOR GEAR TEETH
    DAMAGE – MEXICO PRODUCED VEHICLES ONLY

03-21-42

  • LACK OF POWER – UNDER A LOAD, AT
    CRUISE OR ON ACCELERATION – VEHICLES EQUIPPED WITH
    7.3L DIT ENGINE ONLY – PRODUCED BEFORE 11/25/2000 ONLY
  • ENGINE – 7.3L DIT – LACK OF POWER
    UNDER A LOAD, AT CRUISE OR ON ACCELERATION – VEHICLES
    PRODUCED BEFORE 11/25/2000 ONLY
03-21-41

  • DRIVEABILITY – NO START, LOSS OF POWER
    OR ROUGH IDLE – DURING EXTREME COLD WEATHER OPERATION
    – FUEL GELLING – VEHICLES EQUIPPED WITH 7.3L ENGINE
  • FUEL – NO START, LOSS OF POWER OR
    ROUGH IDLE – DURING EXTREME COLD WEATHER OPERATION –
    FUEL GELLING – VEHICLES EQUIPPED WITH 7.3L ENGINE

03-21-40

  • DRIVEABILITY – BUCK/SURGE FELT WITH
    SPEED CONTROL ENGAGED – 7.3L ENGINE ONLY
  • ELECTRICAL – BUCK/SURGE FELT WITH
    SPEED CONTROL ENGAGED – 7.3L ENGINE ONLY
  • ELECTRICAL – SPEED CONTROL –
    BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED – 7.3L
    ENGINE ONLY
03-21-38

  • ENGINE – 7.3L DIT – HIGH INJECTION
    CONTROL PRESSURE READINGS – ENGINES BUILT AFTER ENGINE
    SERIAL NUMBER 896812
03-21-37

  • ROUGH IDLE – NEW TOOL FOR TESTING
    ROUGH IDLE – INJECTOR PERFORMANCE ANALYZER – SERVICE
    TIP
03-21-35

  • IDLE – IDLE SPEED TOO LOW WHEN COLD –
    VEHICLES WITHOUT CRUISE CONTROL AND WITH 7.3L DIESEL
    ENGINE
  • ENGINE – 7.3L DIESEL – IDLE SPEED TOO
    LOW WHEN COLD – VEHICLES WITHOUT CRUISE CONTROL

03-21-34

  • LAMP – MALFUNCTION INDICATOR LAMP
    (MIL) ILLUMINATED – FALSE DIAGNOSTIC TROUBLE CODE
    (DTC) P1298 STORED IN MEMORY – VEHICLES BUILT THROUGH
    4/12/1999 WITH 7.3L DIESEL ENGINE
  • MALFUNCTION INDICATOR LAMP (MIL)
    ILLUMINATED – FALSE DIAGNOSTIC TROUBLE CODE (DTC)
    P1298 STORED IN MEMORY – VEHICLES BUILT THROUGH
    4/12/1999 WITH 7.3L DIESEL ENGINE

03-21-33

  • ENGINE – 7.3L DIESEL – 1999 ENGINE
    CONTENT REVISIONS
03-21-31

  • ROUGH IDLE – INJECTOR BORE SCUFFING
    DURING ENGINE BREAK-IN PERIOD – SERVICE TIP

03-21-30

  • ENGINE – 7.3L DIRECT INJECTION DIESEL
    – “CACKLING” NOISE HEARD WITH ENGINE WARM AND SLIGHTLY
    ABOVE IDLE
  • ENGINE – 7.3L DIRECT INJECTION DIESEL
    – “BUZZING” NOISE HEARD WITH KEY ON ENGINE OFF DURING
    FUEL PUMP CYCLING
03-21-29

  • ENGINE – 7.3L DIT – 1998-99 ENGINE
    CONTENT REVISIONS – SERVICE TIP
03-20-5

  • DRIVEABILITY – NO START/REPEAT STARTER
    FAILURE – REPEAT STARTER REPLACEMENT
  • ELECTRICAL – STICKING OR BINDING
    IGNITION LOCK CYLINDER BETWEEN START AND RUN
  • ENGINE – STARTING – STARTER STAYING
    ENGAGED AT START UP
03-20-3

  • DRIVEABILITY – MALFUNCTION INDICATOR
    LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456,
    P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
    DTC P0457
03-19-10

  • BRAKES – BRAKE PULL – 4X4 F-250/350
    AND 4X4 EXCURSION VEHICLES ONLY
03-18-1

  • ELECTRICAL – REMOTE KEYLESS ENTRY
    (RKE) – SERVICE TIPS
03-17-4

  • STEERING – STEERING WHEEL FIGHT AFTER
    RIDING OVER BUMPS/RUTS
03-14-8

  • TRANSMISSION – NEW TRANSMISSION COOLER
    FLUSHER – SERVICE TIPS
03-11-2

  • SUSPENSION – ON-VEHICLE FRONT
    INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
  • AXLE – ON-VEHICLE FRONT INTEGRATED
    HUB/BEARING ROCKING END-PLAY MEASUREMENT

03-6-6

  • DRIVEABILITY – BI-FUEL – OXYGEN SENSOR
    DIAGNOSTICS – HIGH OXYGEN SENSOR VOLTAGE READING

03-6-2

  • ENGINE – CYLINDER HEAD DECK LEAK – 4.6
    AND 5.4L ENGINES – NEW “SERVICE-ONLY” GASKET AND
    CYLINDER HEAD KITS AVAILABILITY
03-4-1

  • FRONT LOCKING HUBS – SERVICE TIP
02-21-13

  • ENGINE – STRAIGHTEDGE PROCEDURE FOR
    CHECKING CYLINDER HEAD AND BLOCK FLATNESS

02-21-1

  • TRANSMISSION – 4R100/E4OD – TORQUE
    CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
    DISLODGED
02-17-12

  • MOTORHOME GENERATORS – SHUT OFF WHEN
    FUEL TANK READS 1/4 FULL
02-17-6

  • LAMP – BRAKE – INADVERTENT DISABLING
    OF BRAKE SHIFT INTERLOCK
02-16-4

  • FUEL SYSTEM – FUEL PUMP
    “WHINING”/”BUZZING” NOISE COMES THROUGH ENTERTAINMENT
    OR TWO-WAY RADIO SPEAKER
  • RADIO – ENTERTAINMENT OR TWO-WAY
    COMMUNICATION – “WHINING”/”BUZZING” NOISE IN SPEAKERS
    CAUSED BY FUEL PUMP
  • NOISE – “WHINING”/”BUZZING” – COMES
    THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO

02-14-1

  • SUSPENSION – SQUEAK NOISE FROM REAR
    LEAF SPRINGS – REPLACEMENT REAR LEAF SPRING TIP LINER
    – VEHICLES PRODUCED BEFORE 10/15/01
  • NOISE – SQUEAK NOISE FROM REAR LEAF
    SPRINGS – REPLACEMENT REAR LEAF SPRING TIP LINER –
    VEHICLES PRODUCED BEFORE 10/15/01

02-11-4

  • ENGINE – NEW GASKET REMOVER/CLEANER
    AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

02-11-3

  • ELECTRICAL – VEHICLE SPEED SIGNAL
    (VSS) INPUT NOTICED WHEN TESTING WITH NEW GENERATION
    STAR TESTER (NGS) WHEN VEHICLE IS STOPPED – SUPER DUTY
    F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH
    7/31/2000
  • TRANSMISSION – 4R100 – TRANSMISSION
    STARTS OUT IN 2ND GEAR – ERRATIC 1-2 UPSHIFT OR
    ERRATIC 2-1 DOWNSHIFT FROM TRANSMISSION – SUPER DUTY
    F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH
    7/31/2000
02-10-8

  • DRIVEABILITY – 5.4L 2V – IDLE-AIR
    BYPASS FLOW INDUCED WHISTLE
  • ENGINE – 5.4L 2V – IDLE-AIR BYPASS
    FLOW INDUCED WHISTLE
  • NOISE – IDLE-AIR BYPASS FLOW INDUCED
    WHISTLE – VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY

02-3-5

  • BODY – “SQUEAK” OR BIND FROM TAILGATE
  • NOISE – “SQUEAK” OR BIND FROM TAILGATE
02-1-9

  • ENGINE – ENGINE OIL – RECOMMENDED
    APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS –
    GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY

01-24-6

  • ENGINE – ENGINE OIL SYSTEM PRIMING
    PROCEDURES – SERVICE TIPS
01-23-6

  • ENGINE COOLANT – PROPYLENE GLYCOL –
    FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
    FROM PROPYLENE GLYCOL
  • ENGINE COOLANT – PROPYLENE
    GLYCOL-BASED – FORD MOTOR COMPANY POSITION ON
    PROPYLENE GLYCOL-BASED ENGINE COOLANTS

01-21-13

  • DRIVEABILITY – DIAGNOSTIC TROUBLE
    CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
    MODELS ONLY – STICKING OR BINDING IGNITION LOCK
    CYLINDER – HIGH EFFORT WHEN TURNING IGNITION SWITCH
  • ELECTRICAL – STICKING OR BINDING
    IGNITION LOCK CYLINDER – HIGH EFFORT WHEN TURNING
    IGNITION SWITCH
01-21-4

  • DRIVEABILITY – BI-FUEL – LOCK-OFF
    SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART
    – SERVICE TIPS
01-20-6

  • DRIVEABILITY – BI-FUEL WIRING
    CONNECTOR CROSS-REFERENCE CHART
  • ELECTRICAL – BI-FUEL WIRING CONNECTOR
    CROSS-REFERENCE CHART
01-17-3

  • VIBRATION – DRIVELINE DRONE OR
    VIBRATION – FELT AT 80-96 KM/H (50-60 MPH) – VEHICLES
    EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY

01-15-6

  • CLIMATE CONTROL – REPEAT HEATER CORE
    FAILURE
  • COOLING SYSTEM – REPEAT HEATER CORE
    FAILURE
01-15-5

  • DRIVEABILITY – BI-FUEL VEHICLES ONLY –
    NO START – GASOLINE OR ALT FUEL MODE – VEHICLES
    EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY

01-15-2

  • DRIVEABILITY – BI-FUEL – NO START IN
    BI-FUEL MODE – ALT FUEL LIGHT ON – VEHICLES EQUIPPED
    WITH BI-FUEL ENGINE ONLY
01-12-2

  • ENGINE – OIL LEAK FROM RIGHT SIDE HEAD
    GASKET AREA – VEHICLES EQUIPPED WITH 4.6L/5.4L WINDSOR
    ENGINE ONLY – SERVICE TIPS
01-10-12

  • WIRING – WIRE HARNESS TERMINAL REPAIR
    KIT AND WIRE SPLICE PROCEDURE
01-10-11

  • DRIVEABILITY – BI-FUEL COMPONENT
    IDENTIFICATION CHART – BI-FUEL ENGINES ONLY

01-10-6

  • DRIVEABILITY – BI-FUEL – COMPUVALVE
    PRE-REPLACEMENT CHECK LIST – SERVICE TIPS

01-10-5

  • ENGINE – 6.8L – OIL LEVEL INDICATOR
    READS INACCURATE – SUPER DUTY F-53 MOTORHOME CHASSIS
    VEHICLES – UPDATED OIL LEVEL INDICATOR

01-10-1

  • DRIVEABILITY – BI-FUEL – PARAMETER
    IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION
    – VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE
    ONLY
01-9-7

  • DRIVEABILITY – HO2S (HEATED OXYGEN
    SENSOR), CATALYST, AND FUEL SYSTEM MONITORS – SERVICE
    TIPS – OBD II VEHICLES ONLY
01-8-8

  • DRIVEABILITY – BI-FUEL OBD II
    DIAGNOSTIC MONITOR APPLICATION STRATEGIES – BI-FUEL
    VEHICLES ONLY
01-8-7

  • DRIVEABILITY – BI-FUEL – INTERMITTENT
    STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS – IN
    BI-FUEL OR GASOLINE MODE – BI-FUEL VEHICLES ONLY

01-7-5

  • CLIMATE CONTROL – FACTORY INSTALLED
    A/C PREP PACKAGE COMPONENT IDENTIFICATION AND WARRANTY
    COVERAGE – F-53 SUPER DUTY CLASS A MOTORHOME CHASSIS
    VEHICLES ONLY
01-7-2

  • ENGINE – 6.8L – “SQUEALING” NOISE FROM
    ENGINE COMPARTMENT – COMING FROM FRONT END ACCESSORY
    DRIVE (FEAD) BELT AREA – F-53 MOTORHOME CHASSIS
    VEHICLES BUILT 1/5/1998 THROUGH 7/18/1999 ONLY
  • NOISE – “SQUEALING” FROM ENGINE
    COMPARTMENT – COMING FROM FRONT END ACCESSORY DRIVE
    (FEAD) BELT AREA – F-53 MOTORHOME CHASSIS VEHICLES
    BUILT 1/5/1998 THROUGH 7/18/1999 ONLY

01-4-2

  • ENGINE – 5.4L – OIL SENDING UNIT
    INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD – 4X4
    VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY

01-3-2

  • STEERING – WANDERING/STIFF STEERING OR
    POOR RETURNABILITY AFTER TURNS – 4X4 VEHICLES ONLY
  • SUSPENSION – WANDERING/STIFF STEERING
    OR POOR RETURNABILITY AFTER TURNS – 4X4 VEHICLES ONLY

00-26-1

  • ENGINE – ROUGH IDLE/MISS AFTER
    START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN
    -12 DEGREES C (10 DEGREES F) – VEHICLES BUILT 3/1/1996
    THROUGH 7/31/2000
  • NOISE – FROM ENGINE – ROUGH IDLE/MISS
    AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS
    THAN -12 DEGREES C (10 DEGREES F) – VEHICLES BUILT
    3/1/1996 THROUGH 7/31/2000
00-24-6

  • TRANSMISSION – 4R100 – ERRATIC
    SHIFTING – EARLY AND/OR LATE SHIFTS – VEHICLES
    EQUIPPED WITH 6.8L ENGINE BUILT 1/12/1998 THROUGH
    7/3/1999 ONLY
00-24-4

  • TRANSMISSION – 4R100 – FLUID OVERHEATS
    DURING SEVERE DUTY – AVAILABILITY OF UPDATED FLUID
    COOLER/FILTER KIT – VEHICLES PRODUCED BEFORE 2/6/2000

00-23-10

  • TRANSMISSION – FLUID IN-LINE FILTER
    KIT – REPEAT REPAIRS OF TRANSMISSION – SERVICE TIPS

00-21-9

  • SUSPENSION – VIBRATION/SHAKE FELT IN
    STEERING WHEEL OR SEAT 72-120 KM/H (45-75 MPH)
  • VIBRATION – VIBRATION/SHAKE FELT IN
    STEERING WHEEL OR SEAT 72-120 KM/H (45-75) MPH

00-18-9

  • MIRRORS – SIDE VIEW SIGNAL MIRRORS –
    DELAMINATION OF SIGNAL MIRROR CHROME PLATING – MIRROR
    GLASS BLACK SPOTS
00-9-1

  • LEAK – TRANSMISSION FLUID LEAKS AT
    RADIATOR – VEHICLES EQUIPPED WITH AUTOMATIC
    TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR
    END TANK
00-7-4

  • BRAKES – PREMATURE REAR BRAKE PAD WEAR
    – SEVERE DUTY OPERATION – 17,500 LB F-550 AND ALL
    F-450 ONLY
00-1-6

  • SUSPENSION – FRONT STABILITY BAR MAY
    BREAK OFF – VEHICLES BUILT FROM 1/1/1998

99-25-8

  • BRAKES – GRABBING OR PEDAL KICKBACK
  • STEERING – INCREASED STEERING EFFORT
  • NOISE – “HISSING” HEARD WHILE APPLYING
    BRAKES
99-25-6

  • BRAKES – INCORRECT ROTOR THICKNESS
    STAMPED ON ROTOR – F-150 4X2 ONLY
  • BRAKES – INCORRECT WORKSHOP MANUAL
    ROTOR DISCARD THICKNESS SPECIFICATION

99-24-6

  • NOISE – “THUMPING” FROM THE A/C SYSTEM
    DURING COLD ENGINE STARTUP – VEHICLES BUILT THROUGH
    11/29/1999
99-24-2

  • LOCKS – REPLACE AND/OR REPAIR ANY LOCK
    COMPONENT – AVAILABILITY OF INDIVIDUAL LOCKS

99-23-6

  • TRANSMISSION – 4R100 – FLEXPLATE
    REPLACEMENT – VEHICLES WITH 7.3L DIESEL ENGINE –
    SERVICE TIP
99-23-4

  • MALFUNCTION INDICATOR LAMP (MIL) –
    DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 – NO
    DRIVEABILITY CONCERNS
99-23-2

  • AXLE – GAWR – INCREASING GAWR –
    SERVICE TIP
99-21-2

  • WHEELS – HUB CAPS FALLING OFF WHILE
    DRIVING – VEHICLES BUILT THROUGH 10/16/1999

99-18-10

  • TRANSMISSION – M6OD – BROKEN/BENT
    SHIFT LEVER – VEHICLES WITH 7.3L DIESEL ENGINE
  • TRANSMISSION – M6OD – HARD SHIFTING –
    VEHICLES WITH 7.3L DIESEL ENGINE

99-18-7

  • NOISE – “SQUAWKING” NOISE HEARD WHILE
    IN REVERSE BACKING UP – VEHICLES EQUIPPED WITH 5.4L OR
    6.8L ENGINE
  • TRANSMISSION – 4R100 – “SQUAWKING”
    NOISE HEARD WHILE IN REVERSE BACKING UP – VEHICLES
    EQUIPPED WITH 5.4L OR 6.8L ENGINE

99-16-9

  • TRANSMISSION – 4R100 – 3-4/4-3 SHIFT
    HUNT WHILE THE CRUISE CONTROL IS IN USE – VEHICLES
    WITH 7.3L DIESEL ENGINE
  • TRANSMISSION – 4R100 – NO 3-4 UPSHIFT
    WHILE THE CRUISE CONTROL IS IN USE – VEHICLES WITH
    7.3L DIESEL ENGINE
99-16-4

  • IGNITION KEY – HARD TO REMOVE FROM
    IGNITION CYLINDER
  • IGNITION KEY – HARD TO TURN
99-16-3

  • SUSPENSION – FRONT LEAF SPRINGS –
    “SQUEAKING” NOISE HEARD WHILE DRIVING
  • NOISE – “SQUEAKING” NOISE HEARD FROM
    FRONT LEAF SPRINGS WHILE DRIVING

99-15-2

  • TRANSMISSION – NEW TRANSMISSION FLUSH
    AND FILL TOOL AVAILABLE THROUGH ROTUNDA

99-14-7

  • CALIBRATION INFORMATION – VEHICLES
    BUILT THROUGH 1/29/1999 – APPLICABLE ENGINES ARE 2.0L,
    2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L,
    6.8L, AND 7.3L – SERVICE TIP
99-14-5

  • SUSPENSION – REAR OF VEHICLE IS TOO
    HIGH/LOW – 5TH WHEEL AND GOOSE NECK APPLICATIONS – 4X4
    VEHICLES BUILT THROUGH 2/14/1999

99-13-6

  • BRAKES – INNER REAR PAD – PREMATURE
    WEAR
99-12-12

  • BRAKES – NEW DESIGN FRONT ROTOR AND
    HUB – INCLUDES VEHICLES WITH 4X4 – SERVICE TIP

99-11-1

  • NOISE – TSB SPECIAL FOR
    NOISE/VIBRATION/HARSHNESS
  • VIBRATION – TSB SPECIAL FOR
    NOISE/VIBRATION/HARSHNESS
99-8-15

  • INTERIOR TRIM – DOOR TRIM PANEL
    REPLACEMENT – SERVICE TIP
99-8-1

  • TRANSMISSION – 4R100 – SHIFT FLARE
    (RISE IN ENGINE RPM) DURING 2-3 AND/OR 3-4 UPSHIFT –
    VEHICLES BUILT THROUGH 12/7/1998 WITH 7.3L DIESEL
    ENGINE
99-7-4

  • TRANSMISSION – 4R100 – OIL-TO-AIR
    TRANSMISSION FLUID COOLER – SERVICE TIP

99-6-5

  • WINDNOISE – AROUND SIDE DOOR(S) –
    SERVICE TIPS
99-5-3

  • TRANSMISSION – CHECKING TRANSMISSION
    FLUID LEVEL COLD – SERVICE TIP
99-4-3

  • REPROGRAMMING POWERTRAIN CONTROL
    MODULES (PCMS) – OUT-OF-VEHICLE – EEC V VEHICLES ONLY

99-4-2

  • BRAKES – ILLUMINATION OF RED BRAKE
    WARNING LAMP – BRAKE FLUID LEAK FROM REAR CALIPER –
    VEHICLES BUILT THROUGH 10/22/1998
  • BRAKES – INCREASED BRAKE PEDAL TRAVEL
    – BRAKE FLUID LEAK FROM REAR CALIPER – VEHICLES BUILT
    THROUGH 10/22/1998
  • BRAKES – SPONGY BRAKE PEDAL FEEL –
    BRAKE FLUID LEAK FROM REAR CALIPER – VEHICLES BUILT
    THROUGH 10/22/1998
  • LAMP – ILLUMINATION OF RED BRAKE
    WARNING LAMP – BRAKE FLUID LEAK FROM REAR CALIPER –
    VEHICLES BUILT THROUGH 10/22/1998

99-3-5

  • NOISE – “RATTLING” NOISE FROM
    CONVERTER AREA – VEHICLES EQUIPPED WITH 4R100
    TRANSMISSION AND 7.3L DIESEL ENGINE
  • TRANSMISSION – 4R100 – “RATTLING”
    NOISE FROM CONVERTER AREA – VEHICLES EQUIPPED WITH
    7.3L DIESEL ENGINE
99-2-3

  • WATER LEAKS – WINDSHIELD SEALING –
    SERVICE TIP
  • WINDSHIELD – SEALING – SERVICE TIP
99-1-6

  • CLUTCH – LOW CLUTCH PEDAL ENGAGEMENT –
    VEHICLES BUILT THROUGH 9/12/1998 WITH 7.3L ENGINE AND
    M6 TRANSMISSION
98-26-2

  • FUEL – INFORMATION ON GASOLINE – TIPS
    TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS

98-25-9

  • INTERIOR TRIM – REPAIRS TO VINYL
    COVERED SURFACES – SERVICE TIP
98-24-6

  • ELECTRICAL – NEW TERMINAL GREASE
    RELEASED FOR SERVICE
98-23-21

  • SUSPENSION – FRONT OR REAR –
    SIDE-TO-SIDE LEVELING PROCEDURES AND ATTITUDE SERVICE
    KITS FOR F-53 RV BASIC STRIPPED CHASSIS

98-23-10

  • MASS AIR FLOW (MAF) – SENSOR
    CONTAMINATION – SERVICE TIP
98-23-8

  • AIR CONDITIONING – CONDENSATE DRIPS
    ONTO PASSENGER FLOOR
98-22-4

  • BRAKES – “WHISTLING” NOISE FROM
    HYDRO-MAX BRAKE BOOSTER ASSEMBLY – MOTORHOME CHASSIS
    VEHICLES
  • NOISE – “WHISTLING” FROM HYDRO-MAX
    BRAKE BOOSTER ASSEMBLY – MOTORHOME CHASSIS VEHICLES

98-21-20

  • STEERING – STEERING WHEEL ALIGNMENT –
    CLEAR VISION – VEHICLES WITH MOTORHOME CHASSIS

98-21-17

  • BRAKES – PARKING BRAKE CONTROL RUBBER
    BUMPER STOP – SERVICE PART NOW AVAILABLE

98-20-19

  • POWER SEAT SWITCH – BUTTON COMES OFF
98-20-10

  • EXHAUST SYSTEM – LOOSE CATALYST OR
    MUFFLER HEAT SHIELDS
  • NOISE – “BUZZING” OR “RATTLING” –
    LOOSE CATALYST OR MUFFLER HEAT SHIELDS

98-20-9

  • NOISE – “TICKING” OCCURS ON INITIAL
    STARTUP WITH SHIFT SELECTOR IN “P” OR “N” POSITION –
    VEHICLES WITH E4OD/4R100 TRANSMISSION AND BUILT
    THROUGH 6/11/98
  • TRANSMISSION – E4OD/4R100 – “TICKING”
    NOISE OCCURS ON INITIAL STARTUP WITH SHIFT SELECTOR IN
    “P” OR “N” POSITION – VEHICLES BUILT THROUGH 6/11/98

98-20-3

  • BODY – ADHESIVES NOT RECOMMENDED FOR
    BODY PANEL REPAIRS – SERVICE TIP

98-19-3

  • AIR CONDITIONING – INOPERATIVE –
    VEHICLES BUILT THROUGH 7/30/98
  • AIR CONDITIONING – TEMPERATURE CONTROL
    INOPERATIVE – VEHICLES BUILT THROUGH 7/30/98
  • FUSE – FUSE #24 IN JUNCTION BLOCK OPEN
98-17-23

  • BODY – TAILGATE MOULDING – WARPING
98-16-10

  • SEAT – SEAT BACK RECLINER INOPERATIVE
    – MEMORY LATCH DOES NOT ENGAGE
98-16-8

  • TRANSMISSION – E4OD/4R100 – 1989-99 –
    MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE
    GASKETS USAGE CHART
98-12-5

  • AIR CONDITIONING – FILTERING
    REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT – SERVICE
    TIPS
98-11-10

  • AXLE – FLUID LEAKS FROM REAR AXLE VENT
    TUBE – F-350, F-450 DRW VEHICLES BUILT THROUGH 3/2/98
    AND F-450 MOTORHOME CHASSIS BUILT THROUGH 3/25/98 –
    VEHICLES EQUIPPED WITH 6.8L OR 7.3L ENGINE AND DANA
    MODEL 80 REAR AXLES
98-8-10

  • TRAILER WIRING – CONVERTING A 4-WAY
    TRAILER CONNECTOR SYSTEM TO A 7-WAY HEAVY DUTY SYSTEM
    – SERVICE TIP
98-7-7

  • MIRROR – TRAILER TOW MIRROR GLASS
    REPLACEMENT PROCEDURE
98-7-4

  • LEAKS – OIL – AVAILABILITY OF NEW
    SILICONE GASKET AND SEALANT
98-4-4

  • PAINT – ANTI-CHIP STONE ABRASION
    UNDERCOAT – SERVICE TIP