Fulltext TSBs

Technical Service Bulletins

06-8-15

  • INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS – C1979 AND C1980
06-8-2

  • UN-COMMANDED TCC APPLY ON THE 1-2
    SHIFT CAUSING HESITATION AND/OR PERCEPTION OF LACK OF
    POWER DURING SHIFT
06-7-1

  • NEUTRAL TOW CAPABILITY – SERVICE KIT REQUIREMENTS
06-4-9

  • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON – SHAFT SEAL LEAKS
06-4-7

  • TICKING AND/OR KNOCKING NOISE FROM
    ENGINE – 4.6L/5.4L 3V
06-4-3

  • ALTERNATE TIRES APPROVED FOR OFF ROAD USE
06-4-2

  • BATTERY SERVICE – OPERATION OF BATTERY EYE – CHARGING SERVICE TIPS
06-3-3

  • 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK
06-2-9

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V
    AND 5.4L 3V
06-2-5

  • POWER FOLDING MIRROR OPERATION
05-26-24

  • VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT
05-26-11

  • DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP
05-26-7

  • RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES
05-24-3

  • NOISE FROM BACK GLASS – POWER SLIDING
    REAR WINDOW ONLY
05-23-3

  • REAR AXLE NOISE REPAIR
05-22-8

  • WDS COP KIT DIAGNOSTIC TIPS – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING
05-21-19

  • FRONT BRAKE ROUGHNESS – SHUDDER WHILE BRAKING
05-21-18

  • SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE
05-19-1

  • MIL ON – VARIOUS DRIVEABILITY CONDITIONS – 5.4L 3-VALVE ENGINE – VEHICLES BUILT BEFORE 4/20/2005
05-18-12

  • MIL ON WITH DTC P061B AND/OR P2106 AFTER COLD START AND RAPID TRANSMISSION GEAR ENGAGEMENT – VEHICLES BUILT 8/23/2004 THROUGH 1/15/2005 – 5.4L 3-VALVE ENGINE
05-18-7

  • WIRING – SOLDERING AND CRIMPING REPAIRS – SERVICE TIPS
05-16-12

  • SERVICE WIRING HARNESS REPLACEMENT
    GUIDELINES – SERVICE TIPS
05-16-11

  • SAFETY BELT RETRACTION SPEED
05-15-1

  • CLICKING/TICKING NOISE FROM STEERING COLUMN – VEHICLES BUILT BEFORE 5/31/2005
05-14-4

  • WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 – VEHICLES BUILT 11/29/2004 AND PRIOR
05-14-2

  • HEADLINER BUFFETING/RATTLE NOISE – VEHICLES EQUIPPED WITH ROOF-OPENING PANEL AND BUILT PRIOR TO 6/1/2005
05-13-4

  • HARD START/LONG CRANK, ROUGH IDLE, ENGINE IDLE MISFIRE – MIL – DTCS P0300 THROUGH P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198
05-13-1

  • SHUDDER/VIBRATION ON MODERATE TO HARD
    ACCELERATION
05-11-9

  • REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS – SERVICE TIP
05-10-19

  • INTERMITTENT CD PLAYER CONCERNS – AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS
05-10-12

  • HARSH 3-2 DOWNSHIFT BETWEEN 17-25 MPH (27-40 KM/H) – NO DTCS – 4R75E AUTOMATIC TRANSMISSION – VEHICLES BUILT BEFORE 4/20/2005
05-10-11

  • WHITE FLAKES COMING FROM A/C VENTS
05-9-23

  • STEERING COLUMN RATTLE/CLUNKING WHILE DRIVING OVER ROUGH SURFACES AND WHEN TURNING THE STEERING WHEEL
05-9-3

  • INTERIOR PLASTIC TRIM – PAINT-TO-MATCH AND REPAIR – INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
05-6-4

  • FALSE PARKING AID WARNINGS
05-5-5

  • KEYLESS ENTRY KEYPAD INOPERATIVE
05-4-3

  • COOLING FAN CLUTCH NOISE – VEHICLES BUILT PRIOR TO 10/1/2004 – 5.4L AND 4.6L ENGINES
05-3-11

  • MIL AND/OR DTCS P0172, P0175, P0171, P0174 – THROTTLE PEDAL RESPONSE/TIP IN HESITATION – VEHICLES BUILT PRIOR TO 1/31/2005 – 4.6L ENGINE
05-3-10

  • SAFETY BELT WEB STOP BUTTON SERVICE
05-3-5

  • ROOF DITCH MOLDING LOOSE – VEHICLES BUILT 1/3/2005 THROUGH 1/4/2005
05-3-1

  • MAF DIAGNOSTIC SERVICE TIP – VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)
04-26-18

  • FRONT DOOR TRIM APPLIQUE REMOVAL
04-26-17

  • BODY REPAIR PROCEDURE USING MIG WELDING FOR WELD BONDING
04-26-16

  • WELD BONDING PROCEDURE
04-25-17

  • MAGNESIUM ALLOY RADIATOR CORE SUPPORT – UNIQUE HANDLING AND REPAIR PROCEDURES – SERVICE TIPS
04-25-8

  • 1ST ORDER VIBRATION FROM THE DRIVELINE
    AT HIGHWAY SPEEDS
04-25-7

  • VEHICLE/STEERING WHEEL VIBRATION AT 50
    MPH (80 KM/H) OR HIGHER – STEERING WHEEL NIBBLE AT 65
    MPH (105 KM/H) OR HIGHER
04-24-24

  • CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE – 5.4L 3V ENGINE
04-24-14

  • GENERAL PCM PROGRAMMING PROCEDURES
04-24-5

  • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR
04-24-3

  • LEATHER-WRAPPED STEERING WHEEL – LEATHER COMING LOOSE
04-23-10

  • AUDIBLE DRIVELINE MOAN ABOVE 45 MPH (72 KM/H) DURING ACCELERATION OR COASTING – VEHICLES BUILT 8/20/2004 TO 10/4/2004
04-9-6

  • BODY – PAINT – IRON PARTICLE REMOVAL – INDUSTRIAL FALLOUT – ACID RAIN NEUTRALIZATION

07-1-7

  • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
06-26-1

  • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
06-25-15

  • ALUMINUM BODY PANELS – CORROSION – SERVICE TIP
06-23-6

  • NOISE FROM BACK GLASS – POWER SLIDING REAR WINDOW ONLY
06-22-7

  • UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT
06-21-19

  • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-7

  • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-20-5

  • PARKING AID SPEAKER INOPERATIVE – DTCS C1742 AND C1743
06-19-16

  • SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION
06-19-14

  • NO CRANK / STARTER TERMINAL FATIGUE
06-19-13

  • RATTLE FROM TIP OUT ASHTRAY – VEHICLES BUILT PRIOR TO 1/1/2006
06-19-12

  • DTC P0340/P0344/P0345/P0349 – 4.6L 3V AND 5.4L 3V
06-19-8

  • TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE – 4.6L / 5.4L 3V
06-18-16

  • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES – SERVICE TIP
06-17-8

  • SERVICE WIRING HARNESS REPLACEMENT GUIDELINES – SERVICE TIPS
06-16-13

  • STUMBLE ON HEAVY DECELERATION AND/OR TIP-OUT IN MANUAL 2 – 5.4L 3V WITH 4R75E
06-15-11

  • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
06-15-8

  • KEYPAD DIAGNOSTICS – DEALER INSTALLED ACCESSORY
06-15-2

  • SPARK PLUG REMOVAL INSTRUCTIONS – 5.4 3V
06-12-3

  • VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS
06-12-2

  • VEHICLE / STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER – STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER
06-11-12

  • 4X4 FRONT DIFFERENTIAL BRACKET REPAIR
06-10-9

  • FRAME REPLACEMENT MATRIX – SERVICE TIP
06-9-8

  • INOPERATIVE ESOF 4X4 SYSTEM WITH DTC P1867