Technical Service Bulletins
|Publication Date: October 3, 2011|
2009-2011 E-150, E-250, E-350, E-450, Escape, Expedition
2011 F-250, F-350
This article supersedes TSB 11-8-8 to update the Title, Issue Statement, Build Dates and Symptoms.
Some 2009-2010 F-150 vehicles equipped with a 4.6L 2V, 4.6L 3V or 5.4L 3V engine, 2009-2011 Expedition/Navigator and E-Series vehicles built on or before 4/15/2010, 2010 F-150 vehicles equipped with a 6.2L engine, 2009-2011 Escape and Mariner equipped with a Hybrid-Atkinson 2.5L, 2010-2011 Fusion and Milan equipped with a Hybrid-Atkinson 2.5L, 2011 MKZ equipped with a Hybrid-Atkinson 2.5L and F-Super Duty 250/350 vehicles equipped with a 6.2L engine and built on or before 11/1/2010, may exhibit an audible clicking noise in the engine compartment and/or diagnostic trouble codes (DTCs) P0171, P0174, P0316, P0442, P0455, P0456, P0457, P144A, P1450. Vehicles equipped with a Hybrid-Atkinson 2.5L may also exhibit DTC P1A0C.
Follow the Service Procedure steps to correct the condition.
Replace the Evaporative Emission Canister Purge Valve, located in the engine compartment. Refer to Workshop Manual, Section 303-13.
|PART NUMBER||PART NAME|
|9L3Z-9E730-C||Canister Purge Valve (2009-2010 F-150 5.4L/2009-2011 Expedition/Navigator)|
|9L3Z-9E730-F||Canister Purge Valve (2009-2010 F-150 4.6L 2V)|
|9L3Z-9E730-G||Canister Purge Valve (2009-2010 F-150 4.6L 3V)|
|9C2Z-9C915-C||Canister Purge Valve (2009-2011 Econoline 4.6L)|
|9C2Z-9C915-A||Canister Purge Valve (2009-2011 Econoline 5.4L)|
|9C2Z-9C915-E||Canister Purge Valve (2009-2011 Econoline 6.8L)|
|9U5Z-9C915-BE||Canister Purge Valve (All Hybrid-Atkinson 2.5L/2010-2011 F150 6.2L/2011 F250/F250 6.2L )|
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
|111003A||2009-2011 Expedition, Navigator, 2009-2010 F-150: Check DTCs, And Replace The Evaporative Emission Canister Purge Valve (Do Not Use With Any Other Labor Operations)||0.6 Hr.|
|111003A||2009-2011 Escape and Mariner Hybrid-Atkinson 2.5L, 2010-2011 Fusion and Milan Hyrbid-Atkinson 2.5L, 2011 MKZ Hybrid-Atkinson 2.5L And 2011 F-Super Duty 6.2L: Check DTCs, And Replace The Evaporative Emission Canister Purge Valve (Do Not Use With Any Other Labor Operations)||0.7 Hr.|
|111003A||2009-2011 Econoline: Check DTCs, And Replace The Evaporative Emission Canister Purge Valve (Do Not Use With Any Other Labor Operations)||0.9 Hr.|
|BASIC PART NO.||CONDITION CODE|
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford or Lincoln dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company’s on-line technical resources.
Copyright © 2011 Ford Motor Company