Technical Service Bulletins
Year: 2006 MODEL: F-450 |
|
| 06-7-6 |
| • ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503
|
|
| 06-7-4 |
| • STUCK OR JUMPING / BOUNCING / ERRATIC SPEEDOMETER AND/OR TACHOMETER
|
|
| 06-7-1 |
| • NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS
|
|
| 06-6-6 |
| • BANGING/CLUNKING NOISE WHEN DRIVING - FRONT SUSPENSION BOTTOMS OUT
|
|
| 06-6-1 |
| • DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS - SERVICE TIP
|
|
| 06-5-11 |
| • BUCK/JERK STEADY THROTTLE OR SLIGHT
TIP IN - 6.0L
|
|
| 06-5-10 |
| • MIL ON WITH DTC P0460 - 6.0L
|
|
| 06-5-8 |
| • SIDE GLASS SCRATCHED DUE TO COLLECTION
OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING
|
|
| 06-4-12 |
| • COKING DEPOSIT DIAGNOSTICS AND SERVICE
TIPS - 6.0L DIESEL
|
|
| 06-4-9 |
| • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS
|
|
| 06-4-8 |
| • 5.4L 3V MALFUNCTION INDICATOR LAMP ON WITH P0455 - LOW SPEED ENGINE SURGE - CALIBRATION UPDATE
|
|
| 06-4-6 |
| • HIGH PRESSURE SYSTEM DIAGNOSTICS -
6.0L
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 06-3-9 |
| • SERVICE CALIBRATION UPDATE - LOSS OF
RPM ON DECELERATION - 6.8L 3V
|
|
| 06-3-8 |
| • COOLANT DEGAS BOTTLE OVERFLOW - 6.0L
|
|
| 06-2-13 |
| • WHITE SMOKE, LACKS POWER, EXHAUST
ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L
|
|
| 06-2-9 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V
AND 5.4L 3V
|
|
| 06-2-4 |
| • EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS - 6.0L
|
|
| 05-26-25 |
| • MISFIRE, LACK OF POWER, BUCK/JERK,
EXCESSIVE SMOKE, CRANK/NO START - 6.0L ENGINE -
DIAGNOSTICS FOR FUEL SYSTEM - SERVICE TIPS
|
|
| 05-26-24 |
| • VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-25-11 |
| • BUMPER COVER WAVY/WARPED
|
|
| 05-23-15 |
| • 6.0L ENGINE OVERHEATING WITH A SNOW
PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY
INSTALLED SNOW PLOW PACKAGE
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-22-1 |
| • STEERING WHEEL OSCILLATION
|
|
| 05-21-9 |
| • WHINE/WHISTLE NOISE - 6.0L
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-20-1 |
| • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
|
|
| 05-19-14 |
| • LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR - 6.0L
|
|
| 05-19-12 |
| • TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM - 6.0L BUILT AFTER 9/29/2003
|
|
| 05-18-8 |
| • SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-18-6 |
| • MIL, DTCS P0172, P0175, P2106, HESITATION, SURGE, HARSH DRIVE ENGAGEMENTS
|
|
| 05-18-2 |
| • DTC P2106, HARSH DRIVE ENGAGEMENTS, TRANSMISSION SHUDDER - 5.4L 3V ENGINE
|
|
| 05-17-6 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-16-6 |
| • MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP - 6.0L ENGINE
|
|
| 05-14-9 |
| • LACK OF A/C COOLING - CLIMATE CONTROL MODE SELECTION NOT WORKING
|
|
| 05-13-15 |
| • WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L AND 7.3L DIESEL ENGINE
|
|
| 05-13-9 |
| • DIESEL EXHAUST SMELL IN CAB - 6.0L ENGINE
|
|
| 05-13-5 |
| • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
SIDE CHARGE AIR COOLER (CAC) DUCT - 6.0L DIESEL ENGINE
|
|
| 05-9-3 |
| • INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 07-1-4 |
| • LACK OF COOLING FAN OPERATION - 6.0L
|
|
| 06-26-5 |
| • KING RANCH CREW CAB MODEL ONLY - WHITE CORROSION ON RUNNING BOARDS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-25-14 |
| • 6.0L - COKING DEPOSIT DIAGNOSTICS - SERVICE TIP
|
|
| 06-25-8 |
| • SERVICE CALIBRATION UPDATE - LOSS OF RPM ON DECELERATION - 6.8L ENGINE
|
|
| 06-24-12 |
| • 6.0L ENGINE OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE
|
|
| 06-24-4 |
| • 6.0L - SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
|
|
| 06-24-1 |
| • 6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
|
|
| 06-23-9 |
| • HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP
|
|
| 06-23-4 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 06-23-2 |
| • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P0478, P2262, AND/OR P2263
|
|
| 06-22-15 |
| • HEATER CORE LEAKS - 6.0L ENGINE
|
|
| 06-22-14 |
| • STEERING WHEEL OSCILLATION
|
|
| 06-22-12 |
| • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
|
|
| 06-22-11 |
| • POWER STEERING FLUID LEAK AT JUMPER LINE TO HYDROBOOST CONNECTION - VEHICLES BUILT BEFORE 5/25/2006
|
|
| 06-22-9 |
| • 6.0L - MIL ON WITH DTC P2138, P2139, AND P2140
|
|
| 06-22-6 |
| • BUCK/JERK STEADY THROTTLE OR SLIGHT TIP IN - 6.0L - BUILT ON OR BEFORE 3/15/2006
|
|
| 06-22-3 |
| • WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-21-15 |
| • MIL ON - DTC P1285 / P1299 - 5.4L 3V / 6.8L 3V - FALSE OVERHEAT
|
|
| 06-21-10 |
| • 6.0L - REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION
|
|
| 06-21-7 |
| • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
|
|
| 06-21-2 |
| • COOLANT DEGAS BOTTLE OVERFLOW - 6.0L
|
|
| 06-20-8 |
| • EXHAUST SYSTEM NOISE - SNAP / POP / TICK / PING - 5.4L AND 6.8L ENGINES - VEHICLES BUILT ON OR BEFORE 9/8/2006
|
|
| 06-20-5 |
| • PARKING AID SPEAKER INOPERATIVE - DTCS C1742 AND C1743
|
|
| 06-19-15 |
| • SLOW FUEL FILL
|
|
| 06-19-14 |
| • NO CRANK / STARTER TERMINAL FATIGUE
|
|
| 06-19-12 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V
|
|
| 06-19-6 |
| • 6.0L - MIL ON - P0401, P0402, P0404, P1335, LACK OF POWER, OR SURGE. EGR VALVE CLEANING PROCEDURE.
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-18-2 |
| • SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING
|
|
| 06-17-12 |
| • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE
|
|
| 06-17-7 |
| • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 06-17-6 |
| • HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L
|
|
| 06-16-2 |
| • FRONT WHEEL BEARING NOISE - F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006
|
|
| 06-16-1 |
| • CHROME TOW HOOKS RUSTING PREMATURELY - VEHICLES BUILT PRIOR TO 7/17/2006
|
|
| 06-15-11 |
| • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-15-5 |
| • SLIDING POWER WINDOW (BACK GLASS) SERVICE PROCEDURE
|
|
| 06-13-11 |
| • 6.0L - MIL ON WITH DTC P0460
|
|
| 06-13-3 |
| • MISFIRE, LACK OF POWER, BUCK / JERK, EXCESSIVE SMOKE, CRANK / NO START - 6.0L ENGINE - DIAGNOSTICS FOR FUEL SYSTEM - SERVICE TIPS
|
|
| 06-9-11 |
| • LOUD TICKING NOISE - 3-VALVE ENGINES - STUCK LASH ADJUSTER
|
|
| 07-2-7 |
| • 6.0L - REDUCED ENGINE PERFORMANCE - HIGH ALTITUDE |
|
| 07-3-10 |
| • LACK OF COOLING FAN OPERATION - 6.0L |
|
| 07-4-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE |
|
| 07-5-8 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS |
|
| 07-5-11 |
| • VIBRATION/HOP AT 40-48 MPH (68-77 KM/H) - (8.0 HZ) - TRAILER HITCH EQUIPPED VEHICLES ONLY |
|
| 07-5-15 |
| • 6.0L - OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT |
|
| 07-6-9 |
| • 6.0L DIESEL ENGINE - BUCK/JERK WHEN PULLING LARGE/HEAVY GOOSE NECK TRAILERS |
|
| 07-7-2 |
| • REAR OF VEHICLE IS TOO HIGH/LOW - 5TH WHEEL AND GOOSE NECK APPLICATIONS - 4X4 VEHICLES ONLY |
|
| 07-9-8 |
| • ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503 |
|
| 07-10-4 |
| • 6.0L - SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION |
|
| 07-10-5 |
| • FRONT DOOR SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW MOLDING |
|
| 07-10-10 |
| • STEERING WHEEL OSCILLATION |
|
| 07-11-2 |
| • STUCK OR JUMPING / BOUNCING / ERRATIC SPEEDOMETER AND/OR TACHOMETER |
|
| 07-11-5 |
| • DIESEL ENGINE - OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE |
|
| 07-11-10 |
| • BRAKE PEDAL KICKBACK OR GRABBING |
|
| 07-11-11 |
| • 5.4L AND 6.8L ENGINES - EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE - VEHICLES BUILT ON OR BEFORE 9/8/20065.4L AND 6.8L ENGINES - EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE - VEHICLES BUILT ON OR BEFORE 9/8/2006 |
|
| 07-13-7 |
| • DRIVELINE NOISE UNDER LIGHT LOAD - 40-50 MPH (64-80 KM/H) - 6.0L REGULAR CAB 4X2 WITH 137 INCH WHEELBASE |
|
| 07-14-8 |
| • ERRATIC SHIFTS - SPEEDS ABOVE 50 MPH (80 KM/H) AND/OR ENGAGEMENT SHUDDER |
|
| 07-18-4 |
| • 6.0L - INTERMITTENT MIL ON AND/OR INTERMITTENT DTC P0470 - TEMPERATURES BELOW FREEZING |
|
| 07-21-7 |
| • 5.4L GAS ENGINES - DTC P0171, P0172, P0174, P0175 WITH OR WITHOUT DRIVABILITY CONCERNS - CRUISE CONTROL SURGE |
|
| 07-25-2 |
| • TAILGATE STRIKER - NOISE/RATTLE |
|
| 07-26-1 |
| • BELT CHIRP - POWER STEERING PUMP PULLEY ALIGNMENT - 6.0L - VEHICLES BUILT BETWEEN 1/1/2006 - 8/31/2006 |
|
| 08-7-6 |
| • SPARK PLUG REMOVAL INSTRUCTIONS - 4.6L 3V/5.4L 3V/6.8L 3V |
|
| 08-12-6 |
| • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS |
|
| 08-13-5 |
| • LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE |
|
| 08-18-2 |
| • MIL ON - P0506 AND/OR P0505 - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM |
|
| 08-23-1 |
| • 6.0L DIESEL COOLING SYSTEM CONTAMINATION FLUSH PROCEDURE |
|
| 08-24-2 |
| • VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE |
|
| 08-24-8 |
| • WATER LEAKS - ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH |
|
| 08-26-12 |
| • 6.0L - COKING DEPOSITS DIAGNOSTIC - EGR DTCS P0401, P0402, P0404, P1335 |
|
| 09-7-10 |
| • DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS - SERVICE TIP |
|
| 09-8-3 |
| • COOLANT LOSS - 6.0L |
|
| 09-8-5 |
| • DIESEL COOLANT MAINTENANCE - SERVICE TIPS |
|
| 09-16-5 |
| • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS |
|
| 09-18-12 |
| • COOLING SYSTEM DIAGNOSTICS - OIL IN ENGINE COOLANT - 6.0L |
|
| 09-20-12 |
| • SLOW FUEL FILL - 5.4 AND 6.8 ENGINES |
|
| 09-22-1 |
| • 4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES |
|
| 09-22-8 |
| • STAINLESS STEEL EXHAUST STUDS - 5.4L AND 6.8L 2V ENGINES |
|
| 09-22-16 |
| • 6.0L DIESEL-DRIVEABILITY-NO START/HARD START/LONG CRANK/MISFIRE/RUNS ROUGH/LACK OF POWER/BUCK/JERK OR EXCESSIVE EXHAUST SMOKE DIAGNOSIS |
|
| 09-24-3 |
| • 6.0L DIESEL CALIBRATION UPDATE - VARIOUS ISSUES |
|
| 09-26-1 |
| • 6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS - BUILT ON OR BEFORE 9/30/2008 |
|
| 10-1-11 |
| • 4X4 ONLY - BANGING/CLUNKING NOISE WHEN DRIVING - CONTACT WITH JOUNCE BUMPER - COLD TEMPERATURES |
|
