Technical Service Bulletins
Year: 2005 MODEL: F-550 |
|
| 06-7-6 |
| • ABS LIGHT ON AND POSSIBLE DTCS C1175,
C1236, P0500, P0503
|
|
| 06-7-1 |
| • NEUTRAL TOW CAPABILITY - SERVICE KIT
REQUIREMENTS
|
|
| 06-6-6 |
| • BANGING/CLUNKING NOISE WHEN DRIVING -
FRONT SUSPENSION BOTTOMS OUT
|
|
| 06-6-5 |
| • WATER-IN-FUEL (WIF) LAMP ON
|
|
| 06-6-1 |
| • DIAGNOSTIC PROCEDURE FOR TRAILER TOW
LIGHTS - SERVICE TIP
|
|
| 06-5-11 |
| • BUCK/JERK STEADY THROTTLE OR SLIGHT
TIP IN - 6.0L
|
|
| 06-5-10 |
| • MIL ON WITH DTC P0460 - 6.0L
|
|
| 06-5-8 |
| • SIDE GLASS SCRATCHED DUE TO COLLECTION
OF DIRT/DEBRIS IN WARPED OUTER WINDOW BELTLINE MOLDING
|
|
| 06-4-12 |
| • COKING DEPOSIT DIAGNOSTICS AND SERVICE
TIPS - 6.0L DIESEL
|
|
| 06-4-9 |
| • A/C COMPRESSOR NOT OPERATIONAL / LOW
FREON - SHAFT SEAL LEAKS
|
|
| 06-4-8 |
| • 5.4L 3V MALFUNCTION INDICATOR LAMP ON
WITH P0455 - LOW SPEED ENGINE SURGE - CALIBRATION
UPDATE
|
|
| 06-4-7 |
| • TICKING AND/OR KNOCKING NOISE FROM
ENGINE - 4.6L/5.4L 3V
|
|
| 06-4-6 |
| • HIGH PRESSURE SYSTEM DIAGNOSTICS -
6.0L
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY
EYE - CHARGING SERVICE TIPS
|
|
| 06-3-9 |
| • SERVICE CALIBRATION UPDATE - LOSS OF
RPM ON DECELERATION - 6.8L 3V
|
|
| 06-3-8 |
| • COOLANT DEGAS BOTTLE OVERFLOW - 6.0L
|
|
| 06-3-3 |
| • 5.4L 3V WITH P030X AND/OR P0316
ACCOMPANIED BY SPARK KNOCK
|
|
| 06-2-13 |
| • WHITE SMOKE, LACKS POWER, EXHAUST
ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L
|
|
| 06-2-9 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V
AND 5.4L 3V
|
|
| 06-2-4 |
| • EXHAUST SMOKE AND/OR SMELL, HARSH
TRANSMISSION SHIFTS - 6.0L
|
|
| 05-26-25 |
| • MISFIRE, LACK OF POWER, BUCK/JERK,
EXCESSIVE SMOKE, CRANK/NO START - 6.0L ENGINE -
DIAGNOSTICS FOR FUEL SYSTEM - SERVICE TIPS
|
|
| 05-26-24 |
| • VIBRATION DIAGNOSIS - TIRE/WHEEL
RUNOUT
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A
STOP
|
|
| 05-25-11 |
| • BUMPER COVER WAVY/WARPED
|
|
| 05-23-15 |
| • 6.0L ENGINE OVERHEATING WITH A SNOW
PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY
INSTALLED SNOW PLOW PACKAGE
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON
PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH
RUNNING
|
|
| 05-22-3 |
| • LOW POWER - COLD SIDE CHARGE AIR
COOLER (CAC) DISCONNECTED - OIL LEAK AT CAC
CONNECTIONS - 6.0L ENGINE - VEHICLES BUILT 4/1/2004
THROUGH 2/20/2005
|
|
| 05-22-1 |
| • STEERING WHEEL OSCILLATION
|
|
| 05-21-9 |
| • WHINE/WHISTLE NOISE - 6.0L
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-20-1 |
| • BROKEN OR CORRODED BOLT ON BATTERY
TERMINAL
|
|
| 05-19-14 |
| • LONG CRANK OR RUNS ROUGH AT FACTORY
DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR -
6.0L
|
|
| 05-19-12 |
| • TURBO-INDUCED EXHAUST MOAN/DRONE AT
1500-2000 RPM - 6.0L BUILT AFTER 9/29/2003
|
|
| 05-18-8 |
| • SERVICE KIT AVAILABLE FOR WIPER MOTOR
WIRING
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING
REPAIRS - SERVICE TIPS
|
|
| 05-18-6 |
| • MIL, DTCS P0172, P0175, P2106,
HESITATION, SURGE, HARSH DRIVE ENGAGEMENTS
|
|
| 05-18-2 |
| • DTC P2106, HARSH DRIVE ENGAGEMENTS,
TRANSMISSION SHUDDER - 5.4L 3V ENGINE
|
|
| 05-17-6 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS
CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST
MODE
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-16-6 |
| • MISFIRE, LACK OF POWER, SMOKE, SLOW
CRANK IN COLD WEATHER ON INITIAL START UP - 6.0L
ENGINE
|
|
| 05-14-9 |
| • LACK OF A/C COOLING - CLIMATE CONTROL
MODE SELECTION NOT WORKING
|
|
| 05-14-4 |
| • WRENCH LIGHT ON WITH BOTH DTC P2106
AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR
|
|
| 05-13-16 |
| • FEAD BELT FRAYED/SHREDDED/BROKEN -
6.0L DIESEL ENGINE - VEHICLES BUILT THROUGH 1/1/2005
|
|
| 05-13-15 |
| • WATER IN THE FUEL TANK BEHIND REAR
AXLE - 6.0L AND 7.3L DIESEL ENGINE
|
|
| 05-13-9 |
| • DIESEL EXHAUST SMELL IN CAB - 6.0L
ENGINE
|
|
| 05-13-7 |
| • INSTRUMENT PANEL SCRATCH AND MAR -
SERVICE TIP
|
|
| 05-13-5 |
| • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
SIDE CHARGE AIR COOLER (CAC) DUCT - 6.0L DIESEL ENGINE
|
|
| 05-13-4 |
| • HARD START/LONG CRANK, ROUGH IDLE,
ENGINE IDLE MISFIRE - MIL - DTCS P0300 THROUGH P0308,
P0171, P0172, P0174, P0175, P0316, P2195, P2196,
P2197, P2198
|
|
| 05-12-4 |
| • REAR AXLE LEAK - DANA S-110 REAR AXLE
|
|
| 05-12-3 |
| • CRANK NO START, HARD START, RUNS ROUGH
AT IDLE - 6.0L
|
|
| 05-12-1 |
| • ENGINE QUITS UPON DRIVE OR REVERSE
ENGAGEMENT, OR WHEN COMING TO A STOP - TORQSHIFT
TRANSMISSION
|
|
| 05-11-14 |
| • VARIOUS ELECTRICAL AND/OR DRIVEABILITY
SYMPTOMS AND/OR DTCS - PDB MINI FUSE LOOSE - VEHICLES
BUILT BEFORE 05/11/2005
|
|
| 05-11-4 |
| • VARIOUS DRIVEABILITY SYMPTOMS -
CALIBRATION UPDATE RELEASE - 6.0L DIESEL ENGINE
|
|
| 05-10-14 |
| • MIL ON AND DTCS P035X - 5.4L OR 6.8L
ENGINE
|
|
| 05-9-3 |
| • INTERIOR PLASTIC TRIM - PAINT-TO-MATCH
AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION
PROMOTER USAGE INSTRUCTIONS
|
|
| 05-6-13 |
| • STEERING GEAR NOISE - 6.0L DIESEL
ENGINE - VEHICLES BUILT BEFORE 11/24/2004
|
|
| 05-6-4 |
| • FALSE PARKING AID WARNINGS
|
|
| 05-5-7 |
| • LOW BATTERY VOLTAGE - SNOW PLOW
EQUIPPED VEHICLES - 6.0L DIESEL WITH SINGLE GENERATOR
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 05-3-6 |
| • 4X4 TRANSFER CASE JUMP OUT OF 4H OR 4L
- MANUAL SHIFT TRANSFER CASE
|
|
| 05-1-2 |
| • TEMPERATURE GAUGE READS HOT
|
|
| 04-26-16 |
| • WELD BONDING PROCEDURE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL -
LEATHER COMING LOOSE
|
|
| 04-23-9 |
| • WATER LEAK - ROOF FLANGE AREA - WATER
ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
PAN AREA
|
|
| 04-23-6 |
| • VEHICLE LEAN/SAG WHEN OBSERVED FROM
REAR OF VEHICLE
|
|
| 04-20-10 |
| • TORQSHIFT TRANSMISSION AND PTO
OPERATION - PTO LINE PRESSURE INSUFFICIENT - POSSIBLE
TRANSMISSION DAMAGE
|
|
| 04-18-15 |
| • ADDING ADDITIONAL BULBS TO TURN
INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 04-9-6 |
| • BODY - PAINT - IRON PARTICLE REMOVAL -
INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION
|
|
