Technical Service Bulletins
Year: 2005 MODEL: F-150 |
|
| 06-8-15 |
| • INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS - C1979 AND C1980
|
|
| 06-8-2 |
| • UN-COMMANDED TCC APPLY ON THE 1-2
SHIFT CAUSING HESITATION AND/OR PERCEPTION OF LACK OF
POWER DURING SHIFT
|
|
| 06-7-1 |
| • NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS
|
|
| 06-4-9 |
| • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS
|
|
| 06-4-7 |
| • TICKING AND/OR KNOCKING NOISE FROM
ENGINE - 4.6L/5.4L 3V
|
|
| 06-4-3 |
| • ALTERNATE TIRES APPROVED FOR OFF ROAD USE
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 06-3-3 |
| • 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK
|
|
| 06-2-9 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V
AND 5.4L 3V
|
|
| 06-2-5 |
| • POWER FOLDING MIRROR OPERATION
|
|
| 05-26-24 |
| • VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT
|
|
| 05-26-11 |
| • DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP
|
|
| 05-26-7 |
| • RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES
|
|
| 05-24-3 |
| • NOISE FROM BACK GLASS - POWER SLIDING
REAR WINDOW ONLY
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-21-19 |
| • FRONT BRAKE ROUGHNESS - SHUDDER WHILE BRAKING
|
|
| 05-21-18 |
| • SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE
|
|
| 05-19-1 |
| • MIL ON - VARIOUS DRIVEABILITY CONDITIONS - 5.4L 3-VALVE ENGINE - VEHICLES BUILT BEFORE 4/20/2005
|
|
| 05-18-12 |
| • MIL ON WITH DTC P061B AND/OR P2106 AFTER COLD START AND RAPID TRANSMISSION GEAR ENGAGEMENT - VEHICLES BUILT 8/23/2004 THROUGH 1/15/2005 - 5.4L 3-VALVE ENGINE
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-16-12 |
| • SERVICE WIRING HARNESS REPLACEMENT
GUIDELINES - SERVICE TIPS
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-15-1 |
| • CLICKING/TICKING NOISE FROM STEERING COLUMN - VEHICLES BUILT BEFORE 5/31/2005
|
|
| 05-14-4 |
| • WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR
|
|
| 05-14-2 |
| • HEADLINER BUFFETING/RATTLE NOISE - VEHICLES EQUIPPED WITH ROOF-OPENING PANEL AND BUILT PRIOR TO 6/1/2005
|
|
| 05-13-4 |
| • HARD START/LONG CRANK, ROUGH IDLE, ENGINE IDLE MISFIRE - MIL - DTCS P0300 THROUGH P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198
|
|
| 05-13-1 |
| • SHUDDER/VIBRATION ON MODERATE TO HARD
ACCELERATION
|
|
| 05-11-9 |
| • REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS - SERVICE TIP
|
|
| 05-10-19 |
| • INTERMITTENT CD PLAYER CONCERNS - AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS
|
|
| 05-10-12 |
| • HARSH 3-2 DOWNSHIFT BETWEEN 17-25 MPH (27-40 KM/H) - NO DTCS - 4R75E AUTOMATIC TRANSMISSION - VEHICLES BUILT BEFORE 4/20/2005
|
|
| 05-10-11 |
| • WHITE FLAKES COMING FROM A/C VENTS
|
|
| 05-9-23 |
| • STEERING COLUMN RATTLE/CLUNKING WHILE DRIVING OVER ROUGH SURFACES AND WHEN TURNING THE STEERING WHEEL
|
|
| 05-9-3 |
| • INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
|
|
| 05-6-4 |
| • FALSE PARKING AID WARNINGS
|
|
| 05-5-5 |
| • KEYLESS ENTRY KEYPAD INOPERATIVE
|
|
| 05-4-3 |
| • COOLING FAN CLUTCH NOISE - VEHICLES BUILT PRIOR TO 10/1/2004 - 5.4L AND 4.6L ENGINES
|
|
| 05-3-11 |
| • MIL AND/OR DTCS P0172, P0175, P0171, P0174 - THROTTLE PEDAL RESPONSE/TIP IN HESITATION - VEHICLES BUILT PRIOR TO 1/31/2005 - 4.6L ENGINE
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 05-3-5 |
| • ROOF DITCH MOLDING LOOSE - VEHICLES BUILT 1/3/2005 THROUGH 1/4/2005
|
|
| 05-3-1 |
| • MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)
|
|
| 04-26-18 |
| • FRONT DOOR TRIM APPLIQUE REMOVAL
|
|
| 04-26-17 |
| • BODY REPAIR PROCEDURE USING MIG WELDING FOR WELD BONDING
|
|
| 04-26-16 |
| • WELD BONDING PROCEDURE
|
|
| 04-25-17 |
| • MAGNESIUM ALLOY RADIATOR CORE SUPPORT - UNIQUE HANDLING AND REPAIR PROCEDURES - SERVICE TIPS
|
|
| 04-25-8 |
| • 1ST ORDER VIBRATION FROM THE DRIVELINE
AT HIGHWAY SPEEDS
|
|
| 04-25-7 |
| • VEHICLE/STEERING WHEEL VIBRATION AT 50
MPH (80 KM/H) OR HIGHER - STEERING WHEEL NIBBLE AT 65
MPH (105 KM/H) OR HIGHER
|
|
| 04-24-24 |
| • CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE - 5.4L 3V ENGINE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-5 |
| • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-23-10 |
| • AUDIBLE DRIVELINE MOAN ABOVE 45 MPH (72 KM/H) DURING ACCELERATION OR COASTING - VEHICLES BUILT 8/20/2004 TO 10/4/2004
|
|
| 04-9-6 |
| • BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-25-15 |
| • ALUMINUM BODY PANELS - CORROSION - SERVICE TIP
|
|
| 06-23-6 |
| • NOISE FROM BACK GLASS - POWER SLIDING REAR WINDOW ONLY
|
|
| 06-22-7 |
| • UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-21-7 |
| • AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
|
|
| 06-20-5 |
| • PARKING AID SPEAKER INOPERATIVE - DTCS C1742 AND C1743
|
|
| 06-19-16 |
| • SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION
|
|
| 06-19-14 |
| • NO CRANK / STARTER TERMINAL FATIGUE
|
|
| 06-19-13 |
| • RATTLE FROM TIP OUT ASHTRAY - VEHICLES BUILT PRIOR TO 1/1/2006
|
|
| 06-19-12 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V
|
|
| 06-19-8 |
| • TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE - 4.6L / 5.4L 3V
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-17-8 |
| • SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS
|
|
| 06-16-13 |
| • STUMBLE ON HEAVY DECELERATION AND/OR TIP-OUT IN MANUAL 2 - 5.4L 3V WITH 4R75E
|
|
| 06-15-11 |
| • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-15-2 |
| • SPARK PLUG REMOVAL INSTRUCTIONS - 5.4 3V
|
|
| 06-12-3 |
| • VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS
|
|
| 06-12-2 |
| • VEHICLE / STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER - STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER
|
|
| 06-11-12 |
| • 4X4 FRONT DIFFERENTIAL BRACKET REPAIR
|
|
| 06-10-9 |
| • FRAME REPLACEMENT MATRIX - SERVICE TIP
|
|
| 06-9-8 |
| • INOPERATIVE ESOF 4X4 SYSTEM WITH DTC P1867
|
|
