Technical Service Bulletins
Year: 2004 MODEL: F-150 |
|
| 06-8-15 |
| • INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS - C1979 AND C1980
|
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-7-1 |
| • NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS
|
|
| 06-5-9 |
| • SPARK PLUG REMOVAL INSTRUCTIONS - 5.4
3V
|
|
| 06-4-9 |
| • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS
|
|
| 06-4-7 |
| • TICKING AND/OR KNOCKING NOISE FROM
ENGINE - 4.6L/5.4L 3V
|
|
| 06-4-4 |
| • LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS
|
|
| 06-4-3 |
| • ALTERNATE TIRES APPROVED FOR OFF ROAD USE
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 06-3-4 |
| • PICK UP BOX TO FRAME INTERFERENCE FOLLOWING FRAME REPLACEMENT - 133 INCH SUPERCAB AND 139 INCH SUPERCREW WHEELBASE VEHICLES W/5.5 FOOT BOX
|
|
| 06-3-3 |
| • 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK
|
|
| 06-2-9 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V
AND 5.4L 3V
|
|
| 06-2-5 |
| • POWER FOLDING MIRROR OPERATION
|
|
| 05-26-24 |
| • VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT
|
|
| 05-26-11 |
| • DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP
|
|
| 05-26-7 |
| • RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES
|
|
| 05-26-6 |
| • RAPID FEATHERING WEAR OF FRONT TIRES
|
|
| 05-24-3 |
| • NOISE FROM BACK GLASS - POWER SLIDING
REAR WINDOW ONLY
|
|
| 05-23-18 |
| • ROUGH IDLE - 5.4L 3V 4X2 SUPERCAB AND SUPERCREW
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-21-19 |
| • FRONT BRAKE ROUGHNESS - SHUDDER WHILE BRAKING
|
|
| 05-21-18 |
| • SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-16-12 |
| • SERVICE WIRING HARNESS REPLACEMENT
GUIDELINES - SERVICE TIPS
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-15-1 |
| • CLICKING/TICKING NOISE FROM STEERING COLUMN - VEHICLES BUILT BEFORE 5/31/2005
|
|
| 05-14-4 |
| • WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR
|
|
| 05-14-2 |
| • HEADLINER BUFFETING/RATTLE NOISE - VEHICLES EQUIPPED WITH ROOF-OPENING PANEL AND BUILT PRIOR TO 6/1/2005
|
|
| 05-13-1 |
| • SHUDDER/VIBRATION ON MODERATE TO HARD
ACCELERATION
|
|
| 05-11-9 |
| • REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS - SERVICE TIP
|
|
| 05-10-11 |
| • WHITE FLAKES COMING FROM A/C VENTS
|
|
| 05-10-9 |
| • MIL ON AND DTC P0172 AND/OR P0175 IN MEMORY - 4.6L 2V ENGINE
|
|
| 05-9-3 |
| • INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS
|
|
| 05-6-10 |
| • SPEED CONTROL INOPERATIVE/INTERMITTENT OPERATION - VEHICLES BUILT BEFORE 5/17/2004
|
|
| 05-6-4 |
| • FALSE PARKING AID WARNINGS
|
|
| 05-5-15 |
| • ROUGH IDLE - 5.4L AND 4.6L ENGINES
|
|
| 05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED NATURAL GAS FUEL TANK INSPECTION
|
|
| 05-5-5 |
| • KEYLESS ENTRY KEYPAD INOPERATIVE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 05-4-3 |
| • COOLING FAN CLUTCH NOISE - VEHICLES BUILT PRIOR TO 10/1/2004 - 5.4L AND 4.6L ENGINES
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 05-3-1 |
| • MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)
|
|
| 04-26-18 |
| • FRONT DOOR TRIM APPLIQUE REMOVAL
|
|
| 04-25-17 |
| • MAGNESIUM ALLOY RADIATOR CORE SUPPORT - UNIQUE HANDLING AND REPAIR PROCEDURES - SERVICE TIPS
|
|
| 04-25-8 |
| • 1ST ORDER VIBRATION FROM THE DRIVELINE
AT HIGHWAY SPEEDS
|
|
| 04-25-7 |
| • VEHICLE/STEERING WHEEL VIBRATION AT 50
MPH (80 KM/H) OR HIGHER - STEERING WHEEL NIBBLE AT 65
MPH (105 KM/H) OR HIGHER
|
|
| 04-25-1 |
| • ALUMINUM CORROSION - SERVICE TIP
|
|
| 04-24-24 |
| • CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE - 5.4L 3V ENGINE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-5 |
| • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-21-20 |
| • WATER LEAK AT PASSENGER SIDE LOWER A-PILLAR
|
|
| 04-21-14 |
| • HESITATION ON ACCELERATION AND/OR ERRATIC IDLE WHEN COMING TO A STOP
|
|
| 04-21-10 |
| • MIL ON WITH DTC P0354
|
|
| 04-20-5 |
| • WATER LEAK FROM HIGH MOUNT STOP LAMP
|
|
| 04-18-8 |
| • HOOD FLUTTER AT HIGHWAY SPEEDS
|
|
| 04-18-7 |
| • FRONT END ACCESSORY DRIVE NOISE
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS
|
|
| 04-9-6 |
| • BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION
|
|
| 04-8-3 |
| • ELECTRICAL - SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS - SERVICE PROCEDURE
|
|
| 04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING |
| • TRANSMISSION - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| 03-26-4 |
| • BODY - REAR DOOR PANEL - WAVY APPEARANCE IN COLD WEATHER - LOUD RINGING UPON CLOSING DOOR - RATTLE INSIDE OF DOOR - VEHICLES BUILT BEFORE 11/12/2003 |
| • NOISE - REAR DOOR PANEL - WAVY APPEARANCE IN COLD WEATHER - LOUD RINGING UPON CLOSING DOOR - RATTLE INSIDE OF DOOR - VEHICLES BUILT BEFORE 11/12/2003
|
|
| 03-25-6 |
| • ENGINE - ROMEO BUILT 4.6L 2V - TICK NOISE FROM ENGINE - ENGINES BUILT BEFORE 9/17/2003
|
|
| 03-23-5 |
| • BODY - BED EXTENDER - COMPONENT REPLACEMENT - SERVICE TIP
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-22-4 |
| • WHEEL - CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASED WHEEL NUT AND STUD SIZE - SERVICE TIP
|
|
| 03-20-8 |
| • STEERING - STEERING WHEEL NIBBLE AT OR
ABOVE 100 KM/H (60 MPH) - VEHICLES BUILT PRIOR TO
8/20/2003
|
| • VIBRATION - STEERING WHEEL NIBBLE AT
OR ABOVE 100 KM/H (60 MPH) - VEHICLES BUILT PRIOR TO
8/20/2003
|
|
| 03-20-4 |
| • BODY - INTERIOR DOOR HANDLE REPAIR - REAR DOORS ON CREW CAB AND FRONT DOORS ON REGULAR AND SUPER CAB (STX / XL)
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-15-4 |
| • PAINT - INSTRUMENT PANEL - SCRATCH/MAR REPAIR TIPS
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-25-15 |
| • ALUMINUM BODY PANELS - CORROSION - SERVICE TIP
|
|
| 06-23-6 |
| • NOISE FROM BACK GLASS - POWER SLIDING REAR WINDOW ONLY
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-20-5 |
| • PARKING AID SPEAKER INOPERATIVE - DTCS C1742 AND C1743
|
|
| 06-19-16 |
| • SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION
|
|
| 06-19-14 |
| • NO CRANK / STARTER TERMINAL FATIGUE
|
|
| 06-19-13 |
| • RATTLE FROM TIP OUT ASHTRAY - VEHICLES BUILT PRIOR TO 1/1/2006
|
|
| 06-19-12 |
| • DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V
|
|
| 06-19-8 |
| • TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE - 4.6L / 5.4L 3V
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-17-8 |
| • SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS
|
|
| 06-15-11 |
| • RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-15-2 |
| • SPARK PLUG REMOVAL INSTRUCTIONS - 5.4 3V
|
|
| 06-12-4 |
| • STEERING WHEEL NIBBLE AT OR ABOVE 60 MPH (100 KM/H) - VEHICLES BUILT PRIOR TO 8/20/2003
|
|
| 06-12-3 |
| • VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS
|
|
| 06-12-2 |
| • VEHICLE / STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER - STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER
|
|
| 06-11-12 |
| • 4X4 FRONT DIFFERENTIAL BRACKET REPAIR
|
|
| 06-10-9 |
| • FRAME REPLACEMENT MATRIX - SERVICE TIP
|
|
