Technical Service Bulletins
Year: 2003 MODEL: F-250 |
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-6-5 |
| • WATER-IN-FUEL (WIF) LAMP ON
|
|
| 06-6-1 |
| • DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS - SERVICE TIP
|
|
| 06-4-12 |
| • COKING DEPOSIT DIAGNOSTICS AND SERVICE
TIPS - 6.0L DIESEL
|
|
| 06-4-9 |
| • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 06-3-8 |
| • COOLANT DEGAS BOTTLE OVERFLOW - 6.0L
|
|
| 06-2-13 |
| • WHITE SMOKE, LACKS POWER, EXHAUST
ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L
|
|
| 05-26-25 |
| • MISFIRE, LACK OF POWER, BUCK/JERK,
EXCESSIVE SMOKE, CRANK/NO START - 6.0L ENGINE -
DIAGNOSTICS FOR FUEL SYSTEM - SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-21-9 |
| • WHINE/WHISTLE NOISE - 6.0L
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-20-1 |
| • BROKEN OR CORRODED BOLT ON BATTERY TERMINAL
|
|
| 05-19-14 |
| • LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR - 6.0L
|
|
| 05-18-8 |
| • SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-17-6 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-16-6 |
| • MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP - 6.0L ENGINE
|
|
| 05-13-16 |
| • FEAD BELT FRAYED/SHREDDED/BROKEN - 6.0L DIESEL ENGINE - VEHICLES BUILT THROUGH 1/1/2005
|
|
| 05-13-15 |
| • WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L AND 7.3L DIESEL ENGINE
|
|
| 05-13-9 |
| • DIESEL EXHAUST SMELL IN CAB - 6.0L ENGINE
|
|
| 05-13-5 |
| • OIL LEAK OR BOOST PRESSURE LEAK AT HOT
SIDE CHARGE AIR COOLER (CAC) DUCT - 6.0L DIESEL ENGINE
|
|
| 05-11-5 |
| • VARIOUS DIRVEABILITY CONDITIONS - 6.0L
DIESEL - VEHICLES BUILT BEFORE 9/30/2003
|
|
| 05-6-4 |
| • FALSE PARKING AID WARNINGS
|
|
| 05-5-7 |
| • LOW BATTERY VOLTAGE - SNOW PLOW EQUIPPED VEHICLES - 6.0L DIESEL WITH SINGLE GENERATOR
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-25-16 |
| • MIL ILLUMINATED WITH DTC P0756, P0761 OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005 TORQSHIFT TRANSMISSION
|
|
| 04-25-4 |
| • HARD START OR NO START - 7.3L
|
|
| 04-24-22 |
| • LOSS OF POWER OR STUMBLE WHILE DRIVING IN RAIN - 6.8L ENGINE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-11 |
| • MOMENTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123 - 7.3L ENGINE
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-23-9 |
| • WATER LEAK - ROOF FLANGE AREA - WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA
|
|
| 04-23-6 |
| • VEHICLE LEAN/SAG WHEN OBSERVED FROM REAR OF VEHICLE
|
|
| 04-20-2 |
| • OIL LEAK - TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP) - 7.3L DIESEL
|
|
| 04-18-15 |
| • ADDING ADDITIONAL BULBS TO TURN
INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 04-18-6 |
| • DRIVEABILITY - NO START OR CONSTANT ENGINE MISFIRE - FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS - 6.0L DIESEL
|
|
| 04-18-5 |
| • AXLE - FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING
|
|
| 04-17-13 |
| • HARD START OR NO START - GPCM CONNECTOR SERVICE KIT AVAILABLE - 6.0L ENGINE
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS
|
|
| 04-16-4 |
| • REAR AXLE POPPING/CHATTER NOISE - DANA 80 MODEL DUAL REAR WHEEL (DRW)
|
|
| 04-15-10 |
| • OVERHEAD TRIP COMPUTER (OTC) DISTANCE TO EMPTY (DTE) INCORRECT
|
|
| 04-14-12 |
| • FRONT END ACCESSORY DRIVE (FEAD) BELT NOISE - VEHICLES BUILT PRIOR TO 6/1/2004 - 6.0L ENGINE
|
|
| 04-11-2 |
| • SUSPENSION - VEHICLE SWAY/LEAN DURING LOW SPEED TURNING MANEUVERS |
| • NOISE - SUSPENSION - POPPING NOISE IN FRONT END
|
|
| 04-9-4 |
| • ENGINE - EXHAUST - TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM - 6.0L BUILT PRIOR TO 9/29/2003 |
| • NOISE - VIBRATION - TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM - 6.0L BUILT PRIOR TO 9/29/2003
|
|
| 04-9-3 |
| • DRIVEABILITY - RUNS ROUGH AND/OR LOW POWER - 6.0L DIESEL ENGINE ONLY |
| • ENGINE - FUEL IN OIL - 6.0L DIESEL - INJECTOR DIAGNOSTICS
|
|
| 04-4-4 |
| • ENGINE - 7.3L DIESEL DI - HIGH PRESSURE OIL PUMP LEAK
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-22-2 |
| • NOISE - DRIVESHAFT CENTER BEARING NOISE - VEHICLES BUILT AFTER 6/1/2002 |
| • DRIVESHAFT - DRIVESHAFT CENTER BEARING NOISE - VEHICLES BUILT AFTER 6/1/2002
|
|
| 03-21-45 |
| • ENGINE - 7.3L - EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES
|
|
| 03-20-12 |
| • DRIVEABILITY - VARIOUS DRIVEABILITY CONDITIONS - 6.0L DIT ENGINE - VEHICLES BUILT BEFORE 9/29/03 - CALIBRATION UPDATE - RUNNING CHANGE
|
|
| 03-20-10 |
| • DRIVEABILITY - FUEL SYSTEM - INJECTOR COMBUSTION SEAL - INSTALLATION PROCEDURE - SERVICE TIP - 6.0L ENGINE |
| • ENGINE - FUEL SYSTEM - INJECTOR COMBUSTION SEAL - INSTALLATION PROCEDURE - SERVICE TIP - 6.0L ENGINE
|
|
| 03-20-5 |
| • DRIVEABILITY - NO START/REPEAT STARTER FAILURE - REPEAT STARTER REPLACEMENT |
| • ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN |
| • ENGINE - STARTING - STARTER STAYING ENGAGED AT START UP
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350 AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-17-4 |
| • STEERING - STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-14-3 |
| • SUSPENSION - 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT |
| • AXLE - 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT
|
|
| 03-11-10 |
| • BODY - WATER LEAK FROM ROOF OPENING PANEL - ROOF OPENING PANEL BINDS OR WILL NOT OPEN PROPERLY |
| • NOISE - RATTLE FROM ROOF OPENING PANEL AREA
|
|
| 03-11-2 |
| • SUSPENSION - ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT |
| • AXLE - ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
|
| 03-9-11 |
| • DRIVEABILITY - ROUGH IDLE AND/OR HESITATION ON ACCELERATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE ONLY
|
|
| 03-8-3 |
| • ENGINE - ENGINE OIL LEVEL INDICATOR MARKINGS - REPORTS OF LOW OIL LEVELS
|
|
| 03-4-5 |
| • DRIVEABILITY - "WAIT TO START" LAMP DOES NOT OPERATE PROPERLY |
| • ELECTRICAL - LAMP - "WAIT TO START" LAMP DOES NOT OPERATE PROPERLY
|
|
| 03-4-1 |
| • FRONT LOCKING HUBS - SERVICE TIP
|
|
| 03-3-7 |
| • BODY - PAINT - NO CLEARCOAT BLENDING - COLLISION MANUAL CHANGE
|
|
| 03-1-9 |
| • ENGINE - 6.0L DIESEL - AIR FILTER SERVICE, REMOVAL OR REPLACEMENT - SERVICE TIPS
|
|
| 02-25-2 |
| • ELECTRICAL - CDX6 RADIO DAMAGED DURING SERVICE SHIPPING - CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO - SERVICE TIPS
|
|
| 02-23-7 |
| • COOLING SYSTEM - MOTORCRAFT PREMIUM GOLD ENGINE COOLANT - SERVICE TIPS
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-17-12 |
| • MOTORHOME GENERATORS - SHUT OFF WHEN FUEL TANK READS 1/4 FULL
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-7 |
| • BODY - PAINT - APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS
|
|
| 02-16-3 |
| • PAINT - NEW POLISHING PRODUCTS - SERVICE PROCEDURES
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 07-1-4 |
| • LACK OF COOLING FAN OPERATION - 6.0L
|
|
| 06-26-5 |
| • KING RANCH CREW CAB MODEL ONLY - WHITE CORROSION ON RUNNING BOARDS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-25-14 |
| • 6.0L - COKING DEPOSIT DIAGNOSTICS - SERVICE TIP
|
|
| 06-24-6 |
| • 6.0L - BUILT ON OR BEFORE 9/29/2003 - DTCS P006A OR P132B - LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17
|
|
| 06-24-4 |
| • 6.0L - SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION
|
|
| 06-24-1 |
| • 6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT
|
|
| 06-23-4 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 06-23-2 |
| • 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P0478, P2262, AND/OR P2263
|
|
| 06-22-15 |
| • HEATER CORE LEAKS - 6.0L ENGINE
|
|
| 06-22-12 |
| • WATER-IN-FUEL (WIF) LAMP ON / FLICKERING
|
|
| 06-22-3 |
| • WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-21-10 |
| • 6.0L - REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION
|
|
| 06-21-2 |
| • COOLANT DEGAS BOTTLE OVERFLOW - 6.0L
|
|
| 06-19-14 |
| • NO CRANK / STARTER TERMINAL FATIGUE
|
|
| 06-19-6 |
| • 6.0L - MIL ON - P0401, P0402, P0404, P1335, LACK OF POWER, OR SURGE. EGR VALVE CLEANING PROCEDURE.
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-17-7 |
| • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
| 06-13-3 |
| • MISFIRE, LACK OF POWER, BUCK / JERK, EXCESSIVE SMOKE, CRANK / NO START - 6.0L ENGINE - DIAGNOSTICS FOR FUEL SYSTEM - SERVICE TIPS
|
|
