Technical Service Bulletins
Year: 2003 MODEL: F-150 |
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-4-9 |
| • A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-22-6 |
| • MIL ON WITH DTC P1131 AND/OR P1151 - 4.2L ENGINE
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-11-9 |
| • REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS - SERVICE TIP
|
|
| 05-10-11 |
| • WHITE FLAKES COMING FROM A/C VENTS
|
|
| 05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED NATURAL GAS FUEL TANK INSPECTION
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-25-1 |
| • ALUMINUM CORROSION - SERVICE TIP
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS
|
|
| 04-8-3 |
| • ELECTRICAL - SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS - SERVICE PROCEDURE
|
|
| 04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| 04-2-2 |
| • BODY - BACK GLASS - SLIDING BACK GLASS WINDNOISE/WATER LEAK - SEAL REPLACEMENT
|
|
| 04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING |
| • TRANSMISSION - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| 03-25-6 |
| • ENGINE - ROMEO BUILT 4.6L 2V - TICK NOISE FROM ENGINE - ENGINES BUILT BEFORE 9/17/2003
|
|
| 03-23-5 |
| • BODY - BED EXTENDER - COMPONENT REPLACEMENT - SERVICE TIP
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-22-4 |
| • WHEEL - CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASED WHEEL NUT AND STUD SIZE - SERVICE TIP
|
|
| 03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER |
| • ENGINE - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-15-13 |
| • STEERING - TIE ROD END INSPECTION PROCEDURE
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-11-10 |
| • BODY - WATER LEAK FROM ROOF OPENING PANEL - ROOF OPENING PANEL BINDS OR WILL NOT OPEN PROPERLY |
| • NOISE - RATTLE FROM ROOF OPENING PANEL AREA
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-7-1 |
| • BODY - WATER LEAK FROM ROOF OPENING PANEL AREA
|
|
| 03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| 03-5-1 |
| • STEERING - POWER STEERING PUMP WHINE NOISE - VEHICLES PRODUCED ON OR BEFORE 10/7/02 ONLY |
| • NOISE - "WHINE" NOISE FROM POWER STEERING PUMP - VEHICLES PRODUCED ON OR BEFORE 10/7/02 ONLY
|
|
| 03-4-3 |
| • DRIVEABILITY - NO START - CRANK NO START - AMBIENT TEMPERATURE AT OR BELOW 0 DEGREE F (-17C) - VEHICLES BUILT 7/29/02 THROUGH 2/3/03 EQUIPPED WITH 4.6L ENGINE ONLY
|
|
| 03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED SERVICE PARTS
|
|
| 02-25-2 |
| • ELECTRICAL - CDX6 RADIO DAMAGED DURING SERVICE SHIPPING - CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO - SERVICE TIPS
|
|
| 02-23-7 |
| • COOLING SYSTEM - MOTORCRAFT PREMIUM GOLD ENGINE COOLANT - SERVICE TIPS
|
|
| 02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION |
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE TIPS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-7 |
| • BODY - PAINT - APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS
|
|
| 02-16-3 |
| • PAINT - NEW POLISHING PRODUCTS - SERVICE PROCEDURES
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
