Technical Service Bulletins
Year: 2002 MODEL: F-550 |
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY
EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A
STOP
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON
PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH
RUNNING
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-20-1 |
| • BROKEN OR CORRODED BOLT ON BATTERY
TERMINAL
|
|
| 05-18-8 |
| • SERVICE KIT AVAILABLE FOR WIPER MOTOR
WIRING
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING
REPAIRS - SERVICE TIPS
|
|
| 05-17-6 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS
CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST
MODE
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-13-15 |
| • WATER IN THE FUEL TANK BEHIND REAR
AXLE - 6.0L AND 7.3L DIESEL ENGINE
|
|
| 05-6-4 |
| • FALSE PARKING AID WARNINGS
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS
IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE -
NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-25-4 |
| • HARD START OR NO START - 7.3L
|
|
| 04-24-22 |
| • LOSS OF POWER OR STUMBLE WHILE DRIVING
IN RAIN - 6.8L ENGINE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-11 |
| • MOMENTARY RETURN TO IDLE DURING
AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE
(DTC) P0123 - 7.3L ENGINE
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL -
LEATHER COMING LOOSE
|
|
| 04-23-9 |
| • WATER LEAK - ROOF FLANGE AREA - WATER
ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
PAN AREA
|
|
| 04-23-6 |
| • VEHICLE LEAN/SAG WHEN OBSERVED FROM
REAR OF VEHICLE
|
|
| 04-20-2 |
| • OIL LEAK - TURBO PEDESTAL SEAL AT
EXHAUST BACK PRESSURE ACTUATOR (EBP) - 7.3L DIESEL
|
|
| 04-18-15 |
| • ADDING ADDITIONAL BULBS TO TURN
INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 04-18-5 |
| • AXLE - FRONT HUBS NOT ENGAGING, NOT
STAYING ENGAGED AND/OR UNLOCKING
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL)
ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES
(DTC'S) - SERVICE TIPS
|
|
| 04-16-4 |
| • REAR AXLE POPPING/CHATTER NOISE - DANA
80 MODEL DUAL REAR WHEEL (DRW)
|
|
| 04-11-2 |
| • SUSPENSION - VEHICLE SWAY/LEAN DURING
LOW SPEED TURNING MANEUVERS
|
| • NOISE - SUSPENSION - POPPING NOISE IN
FRONT END
|
|
| 04-4-4 |
| • ENGINE - 7.3L DIESEL DI - HIGH
PRESSURE OIL PUMP LEAK
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS
AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-22-2 |
| • NOISE - DRIVESHAFT CENTER BEARING
NOISE - VEHICLES BUILT AFTER 6/1/2002
|
| • DRIVESHAFT - DRIVESHAFT CENTER BEARING
NOISE - VEHICLES BUILT AFTER 6/1/2002
|
|
| 03-21-48 |
| • DRIVEABILITY - P0340 CAMSHAFT POSITION
SENSOR FALSE DIAGNOSTIC TROUBLE CODE - VEHICLES
EQUIPPED WITH 7.3L DIESEL ENGINE ONLY
|
| • TRANSMISSION - 4R100 - DELAYED 3-4
SHIFT - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE ONLY
|
|
| 03-21-45 |
| • ENGINE - 7.3L - EXTERNAL OIL LEAK
DIAGNOSIS FOR 7.3L DIT ENGINES
|
|
| 03-20-5 |
| • DRIVEABILITY - NO START/REPEAT STARTER
FAILURE - REPEAT STARTER REPLACEMENT
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER BETWEEN START AND RUN
|
| • ENGINE - STARTING - STARTER STAYING
ENGAGED AT START UP
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456,
P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
DTC P0457
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350
AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY
(RKE) - SERVICE TIPS
|
|
| 03-17-4 |
| • STEERING - STEERING WHEEL FIGHT AFTER
RIDING OVER BUMPS/RUTS
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER
FLUSHER - SERVICE TIPS
|
|
| 03-14-3 |
| • SUSPENSION - 4X4 WHEEL HUB
NON-ENGAGEMENT/DISENGAGEMENT
|
| • AXLE - 4X4 WHEEL HUB
NON-ENGAGEMENT/DISENGAGEMENT
|
|
| 03-11-2 |
| • SUSPENSION - ON-VEHICLE FRONT
INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
| • AXLE - ON-VEHICLE FRONT INTEGRATED
HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
|
| 03-9-11 |
| • DRIVEABILITY - ROUGH IDLE AND/OR
HESITATION ON ACCELERATION - VEHICLES EQUIPPED WITH
5.4L OR 6.8L ENGINE ONLY
|
|
| 03-8-3 |
| • ENGINE - ENGINE OIL LEVEL INDICATOR
MARKINGS - REPORTS OF LOW OIL LEVELS
|
|
| 03-4-5 |
| • DRIVEABILITY - "WAIT TO START" LAMP
DOES NOT OPERATE PROPERLY
|
| • ELECTRICAL - LAMP - "WAIT TO START"
LAMP DOES NOT OPERATE PROPERLY
|
|
| 03-4-1 |
| • FRONT LOCKING HUBS - SERVICE TIP
|
|
| 03-3-7 |
| • BODY - PAINT - NO CLEARCOAT BLENDING -
COLLISION MANUAL CHANGE
|
|
| 02-25-2 |
| • ELECTRICAL - CDX6 RADIO DAMAGED DURING
SERVICE SHIPPING - CORRECT SHIPMENT PROCEDURES FOR
CDX6 RADIO - SERVICE TIPS
|
|
| 02-23-7 |
| • COOLING SYSTEM - MOTORCRAFT PREMIUM
GOLD ENGINE COOLANT - SERVICE TIPS
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR
CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE
CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
DISLODGED
|
|
| 02-17-12 |
| • MOTORHOME GENERATORS - SHUT OFF WHEN
FUEL TANK READS 1/4 FULL
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING
OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP
"WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT
OR TWO-WAY RADIO SPEAKER
|
| • RADIO - ENTERTAINMENT OR TWO-WAY
COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS
CAUSED BY FUEL PUMP
|
| • NOISE - "WHINING"/"BUZZING" - COMES
THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-16-3 |
| • PAINT - NEW POLISHING PRODUCTS -
SERVICE PROCEDURES
|
|
| 02-14-1 |
| • SUSPENSION - SQUEAK NOISE FROM REAR
LEAF SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER
- VEHICLES PRODUCED BEFORE 10/15/01
|
| • NOISE - SQUEAK NOISE FROM REAR LEAF
SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER -
VEHICLES PRODUCED BEFORE 10/15/01
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER
AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-10-8 |
| • DRIVEABILITY - 5.4L 2V - IDLE-AIR
BYPASS FLOW INDUCED WHISTLE
|
| • ENGINE - 5.4L 2V - IDLE-AIR BYPASS
FLOW INDUCED WHISTLE
|
| • NOISE - IDLE-AIR BYPASS FLOW INDUCED
WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY
|
|
| 02-10-4 |
| • DRIVEABILITY - BI-FUEL LPG - CRANK NO
START, ROLLING IDLE, SURGING IDLE, AND/OR SURGE AT
CRUISE IN LPG MODE WITH ALT FUEL GREEN LIGHT ON
|
|
| 02-7-2 |
| • CLIMATE CONTROL - A/C COMING OUT
DEFROST OR PERCEIVED A/C CUTTING OUT ON LONG UPHILL
GRADE
|
|
| 02-5-6 |
| • SHEET METAL - PRIMED SERVICE PARTS -
PREP PROCEDURE AND MSDS INFORMATION
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE
|
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED
APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS -
GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL -
FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
FROM PROPYLENE GLYCOL
|
| • ENGINE COOLANT - PROPYLENE
GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON
PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE
CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
MODELS ONLY - STICKING OR BINDING IGNITION LOCK
CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING
IGNITION SWITCH
|
|
| 01-20-6 |
| • DRIVEABILITY - BI-FUEL WIRING
CONNECTOR CROSS-REFERENCE CHART
|
| • ELECTRICAL - BI-FUEL WIRING CONNECTOR
CROSS-REFERENCE CHART
|
|
| 01-17-3 |
| • VIBRATION - DRIVELINE DRONE OR
VIBRATION - FELT AT 80-96 KM/H (50-60 MPH) - VEHICLES
EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR
KIT AND WIRE SPLICE PROCEDURE
|
|
