Technical Service Bulletins
Year: 2000 MODEL: F-250 |
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-17-6 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-13-15 |
| • WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L AND 7.3L DIESEL ENGINE
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-25-4 |
| • HARD START OR NO START - 7.3L
|
|
| 04-24-22 |
| • LOSS OF POWER OR STUMBLE WHILE DRIVING IN RAIN - 6.8L ENGINE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-23-9 |
| • WATER LEAK - ROOF FLANGE AREA - WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA
|
|
| 04-23-6 |
| • VEHICLE LEAN/SAG WHEN OBSERVED FROM REAR OF VEHICLE
|
|
| 04-20-2 |
| • OIL LEAK - TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP) - 7.3L DIESEL
|
|
| 04-18-15 |
| • ADDING ADDITIONAL BULBS TO TURN
INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-18-5 |
| • AXLE - FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS
|
|
| 04-16-4 |
| • REAR AXLE POPPING/CHATTER NOISE - DANA 80 MODEL DUAL REAR WHEEL (DRW)
|
|
| 04-4-4 |
| • ENGINE - 7.3L DIESEL DI - HIGH PRESSURE OIL PUMP LEAK
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-21-49 |
| • DRIVEABILITY - LOSS OF POWER AND EXTERNAL TURBO OIL LEAK - 7.3L DIESEL |
| • ENGINE - 7.3L DIESEL - LOSS OF POWER AND EXTERNAL TURBO OIL LEAK |
| • NOISE - EXHAUST NOISE FROM TURBO - 7.3L DIESEL
|
|
| 03-21-45 |
| • ENGINE - 7.3L - EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES
|
|
| 03-21-44 |
| • NO START - STARTER MOTOR GEAR TEETH DAMAGE - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE - MEXICO PRODUCED VEHICLES ONLY |
| • ENGINE - 7.3L DIESEL - NO START - STARTER MOTOR GEAR TEETH DAMAGE - MEXICO PRODUCED VEHICLES ONLY |
| • NOISE - STARTER MOTOR GEAR TEETH DAMAGE - MEXICO PRODUCED VEHICLES ONLY
|
|
| 03-21-42 |
| • LACK OF POWER - UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES EQUIPPED WITH 7.3L DIT ENGINE ONLY - PRODUCED BEFORE 11/25/2000 ONLY |
| • ENGINE - 7.3L DIT - LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES PRODUCED BEFORE 11/25/2000 ONLY
|
|
| 03-21-41 |
| • DRIVEABILITY - NO START, LOSS OF POWER OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION - FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE |
| • FUEL - NO START, LOSS OF POWER OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION - FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE
|
|
| 03-21-40 |
| • DRIVEABILITY - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY |
| • ELECTRICAL - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY |
| • ELECTRICAL - SPEED CONTROL - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY
|
|
| 03-21-38 |
| • ENGINE - 7.3L DIT - HIGH INJECTION CONTROL PRESSURE READINGS - ENGINES BUILT AFTER ENGINE SERIAL NUMBER 896812
|
|
| 03-21-37 |
| • ROUGH IDLE - NEW TOOL FOR TESTING ROUGH IDLE - INJECTOR PERFORMANCE ANALYZER - SERVICE TIP
|
|
| 03-21-36 |
| • ENGINE - 7.3L DIESEL - GLOW PLUG CONTROL MODULE - VEHICLES WITH CALIFORNIA EMISSIONS - SERVICE TIP
|
|
| 03-20-5 |
| • DRIVEABILITY - NO START/REPEAT STARTER FAILURE - REPEAT STARTER REPLACEMENT |
| • ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN |
| • ENGINE - STARTING - STARTER STAYING ENGAGED AT START UP
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350 AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-17-4 |
| • STEERING - STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-14-3 |
| • SUSPENSION - 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT |
| • AXLE - 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT
|
|
| 03-11-2 |
| • SUSPENSION - ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT |
| • AXLE - ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-9-11 |
| • DRIVEABILITY - ROUGH IDLE AND/OR HESITATION ON ACCELERATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE ONLY
|
|
| 03-6-2 |
| • ENGINE - CYLINDER HEAD DECK LEAK - 4.6 AND 5.4L ENGINES - NEW "SERVICE-ONLY" GASKET AND CYLINDER HEAD KITS AVAILABILITY
|
|
| 03-4-1 |
| • FRONT LOCKING HUBS - SERVICE TIP
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-17-12 |
| • MOTORHOME GENERATORS - SHUT OFF WHEN FUEL TANK READS 1/4 FULL
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER |
| • RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP |
| • NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-14-1 |
| • SUSPENSION - SQUEAK NOISE FROM REAR LEAF SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER - VEHICLES PRODUCED BEFORE 10/15/01 |
| • NOISE - SQUEAK NOISE FROM REAR LEAF SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER - VEHICLES PRODUCED BEFORE 10/15/01
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-11-3 |
| • ELECTRICAL - VEHICLE SPEED SIGNAL (VSS) INPUT NOTICED WHEN TESTING WITH NEW GENERATION STAR TESTER (NGS) WHEN VEHICLE IS STOPPED - SUPER DUTY F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH 7/31/2000 |
| • TRANSMISSION - 4R100 - TRANSMISSION STARTS OUT IN 2ND GEAR - ERRATIC 1-2 UPSHIFT OR ERRATIC 2-1 DOWNSHIFT FROM TRANSMISSION - SUPER DUTY F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH 7/31/2000
|
|
| 02-10-8 |
| • DRIVEABILITY - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE |
| • ENGINE - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE |
| • NOISE - IDLE-AIR BYPASS FLOW INDUCED WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY
|
|
| 02-7-2 |
| • CLIMATE CONTROL - A/C COMING OUT DEFROST OR PERCEIVED A/C CUTTING OUT ON LONG UPHILL GRADE
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE |
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-2-1 |
| • DRIVEABILITY - LOW POWER CONDITION WHILE IN REVERSE GEAR - VEHICLES EQUIPPED WITH 6.8L 2V ENGINE, 4R100 TRANSMISSION AND PTO OPTION ONLY |
| • TRANSMISSION - 4R100 - LOW POWER CONDITION WHILE IN REVERSE GEAR - VEHICLES EQUIPPED WITH 6.8L 2V ENGINE, 4R100 TRANSMISSION AND PTO OPTION ONLY
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 02-1-8 |
| • DRIVEABILITY - BI-FUEL - NO START IN ALT FUEL MODE - ALT FUEL SWITCH INDICATOR ON THEN OFF WHILE CRANKING - SOLENOID TANK VALVE COIL NOW AVAILABLE SEPARATELY FOR SERVICE
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL |
| • ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH |
| • ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART - SERVICE TIPS
|
|
| 01-20-6 |
| • DRIVEABILITY - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART |
| • ELECTRICAL - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART
|
|
| 01-19-4 |
| • ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
|
|
| 01-17-3 |
| • VIBRATION - DRIVELINE DRONE OR VIBRATION - FELT AT 80-96 KM/H (50-60 MPH) - VEHICLES EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-5 |
| • DRIVEABILITY - BI-FUEL VEHICLES ONLY - NO START - GASOLINE OR ALT FUEL MODE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-10-5 |
| • ENGINE - 6.8L - OIL LEVEL INDICATOR READS INACCURATE - SUPER DUTY F-53 MOTORHOME CHASSIS VEHICLES - UPDATED OIL LEVEL INDICATOR
|
|
| 01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY
|
|
| 01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL VEHICLES ONLY
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-7-5 |
| • CLIMATE CONTROL - FACTORY INSTALLED A/C PREP PACKAGE COMPONENT IDENTIFICATION AND WARRANTY COVERAGE - F-53 SUPER DUTY CLASS A MOTORHOME CHASSIS VEHICLES ONLY
|
|
| 01-7-4 |
| • DRIVEABILITY - BI-FUEL VEHICLE COMMUNICATION LINK (VCL) AND ALTERNATIVE FUEL CONTROL MODULE (AFCM) TERMINOLOGY CLARIFICATION - BI-FUEL VEHICLES ONLY
|
|
| 01-6-5 |
| • DRIVEABILITY - BI-FUEL - HESITATION OR IDLE SURGE - HARD START, NO START OR START THEN STALL - WITH FUEL SELECTOR SWITCH LAMP ON IN B-FUEL MODE - VEHICLES EQUIPPED WITH 5.4L/6.8L BI-FUEL ENGINE ONLY |
| • DRIVEABLITY - BI-FUEL - HARD START, NO START OR START THEN STALL, HESITATION OR IDLE SURGE - WITH FUEL SELECTOR SWITCH LAMP ON IN BI-FUEL MODE - VEHICLES EQUIPPED WITH 5.4L/6.8L BI-FUEL ENGINE ONLY
|
|
| 01-5-3 |
| • ELECTRICAL - TRAILER TOW WIRING - DIFFICULT TO LOCATE AT INSTRUMENT PANEL - VEHICLES BUILT 9/1/1999 THROUGH 10/4/2000 - RELOCATION PROCEDURE
|
|
| 01-4-9 |
| • BRAKES - FRONT DISC BRAKE PAD AND/OR CALIPER RATTLE OVER BUMPS - REVISED FRONT BRAKE PADS |
| • NOISE - RATTLE FROM FRONT DISC BRAKE PAD AND/OR CALIPER - REVISED FRONT BRAKE PADS
|
|
| 01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4 VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| 01-3-2 |
| • STEERING - WANDERING/STIFF STEERING OR POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY |
| • SUSPENSION - WANDERING/STIFF STEERING OR POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY
|
|
| 01-1-6 |
| • DIAGNOSTIC TROUBLE CODES (DTCS) - P0350-P0360 COIL DTCS STORED IN MEMORY - ROUGH IDLE - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - COIL ON PLUG APPLICATIONS ONLY |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL ON PLUG APPLICATIONS ONLY |
| • ROUGH IDLE - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL ON PLUG APPLICATIONS ONLY
|
|
| 01-1-3 |
| • ENGINE - "MISS" NOISE FROM EXHAUST - UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000 |
| • EXHAUST - "MISS" NOISE FROM EXHAUST - UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000 |
| • NOISE - "MISS" NOISE FROM EXHAUST - UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000 |
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
|
|
| 00-24-4 |
| • TRANSMISSION - 4R100 - FLUID OVERHEATS DURING SEVERE DUTY - AVAILABILITY OF UPDATED FLUID COOLER/FILTER KIT - VEHICLES PRODUCED BEFORE 2/6/2000
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-21-9 |
| • SUSPENSION - VIBRATION/SHAKE FELT IN STEERING WHEEL OR SEAT 72-120 KM/H (45-75 MPH) |
| • VIBRATION - VIBRATION/SHAKE FELT IN STEERING WHEEL OR SEAT 72-120 KM/H (45-75) MPH
|
|
| 00-18-3 |
| • COOLING SYSTEM - COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000 - VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE |
| • ENGINE - 4.6L 2V OR 5.4L 2V - COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK
|
|
| 00-7-4 |
| • BRAKES - PREMATURE REAR BRAKE PAD WEAR - SEVERE DUTY OPERATION - 17,500 LB F-550 AND ALL F-450 ONLY
|
|
| 00-6-11 |
| • CALIBRATION - RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT - SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS STAMPED ON ROTOR - F-150 4X2 ONLY |
| • BRAKES - INCORRECT WORKSHOP MANUAL ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-25-3 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE |
| • POWERTRAIN CONTROL MODULE (PCM) - REPROGRAM - VEHICLES WITH 5.4L ENGINES
|
|
| 99-24-6 |
| • NOISE - "THUMPING" FROM THE A/C SYSTEM DURING COLD ENGINE STARTUP - VEHICLES BUILT THROUGH 11/29/1999
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO DRIVEABILITY CONCERNS
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-5 |
| • KING RANCH CREW CAB MODEL ONLY - WHITE CORROSION ON RUNNING BOARDS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-23-4 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-19-14 |
| • NO CRANK / STARTER TERMINAL FATIGUE
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-17-7 |
| • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
