Technical Service Bulletins
Year: 2000 MODEL: F-150 |
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-10-11 |
| • WHITE FLAKES COMING FROM A/C VENTS
|
|
| 05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED NATURAL GAS FUEL TANK INSPECTION
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-25-1 |
| • ALUMINUM CORROSION - SERVICE TIP
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS
|
|
| 04-8-3 |
| • ELECTRICAL - SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS - SERVICE PROCEDURE
|
|
| 04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| 04-2-2 |
| • BODY - BACK GLASS - SLIDING BACK GLASS WINDNOISE/WATER LEAK - SEAL REPLACEMENT
|
|
| 04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING |
| • TRANSMISSION - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-22-4 |
| • WHEEL - CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASED WHEEL NUT AND STUD SIZE - SERVICE TIP
|
|
| 03-21-39 |
| • ENGINE - 7.3L DIESEL - ENGINE KNOCK OR "CACKLE" - 1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240 - ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240 |
| • NOISE - "CACKLE" OR ENGINE KNOCK - 7.3L DIESEL - 1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240 - ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240
|
|
| 03-20-7 |
| • ENGINE - 4.2L - VIBRATION AND/OR RATTLE IN GEAR AT IDLE OR WHEN ACCELERATING FROM A SLOW SPEED 32 KM/H (20 MPH) - VEHICLES BUILT BEFORE 2/25/02 EQUIPPED WITH AUTOMATIC TRANSMISSION ONLY |
| • VIBRATION - VIBRATION AND/OR RATTLE IN GEAR AT IDLE OR WHEN ACCELERATING FROM A SLOW SPEED 32 KM/H (20 MPH) - VEHICLES BUILT BEFORE 2/25/02 EQUIPPED WITH 4.2L AND AUTOMATIC TRANSMISSION ONLY
|
|
| 03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER |
| • ENGINE - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-15-13 |
| • STEERING - TIE ROD END INSPECTION PROCEDURE
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| 03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| 03-6-2 |
| • ENGINE - CYLINDER HEAD DECK LEAK - 4.6 AND 5.4L ENGINES - NEW "SERVICE-ONLY" GASKET AND CYLINDER HEAD KITS AVAILABILITY
|
|
| 03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED SERVICE PARTS
|
|
| 03-2-4 |
| • BODY - DRIVER SIDE WINDOW BINDS WHEN OPERATED |
| • ELECTRICAL - DRIVER SIDE WINDOW BINDS WHEN OPERATED
|
|
| 02-23-4 |
| • DIAGNOSTIC TROUBLE CODE (DTC) - P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY |
| • LAMP - 4X4 LAMP ILLUMINATED AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY |
| • SPEEDOMETER - INACCURATE AND/OR INOPERATIVE AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY
|
|
| 02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION |
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-11 |
| • RIDE - HARSH RIDE - CAB/BODY OSCILLATION/BOUNCE - HIGHWAY SPEEDS - 4X2 MODELS ONLY
|
|
| 02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE TIPS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-19-3 |
| • DRIVEABILITY - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE |
| • 4.6L - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER |
| • RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP |
| • NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-12-3 |
| • DRIVEABILITY - ENGINE LACKS POWER WHEN OPERATING IN HIGH AMBIENT TEMPERATURES ABOVE 38C (100F) - VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY |
| • ENGINE - 5.4L - ENGINE LACKS POWER WHEN OPERATING IN HIGH AMBIENT TEMPERATURES ABOVE 38C (100F)
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-10-8 |
| • DRIVEABILITY - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE |
| • ENGINE - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE |
| • NOISE - IDLE-AIR BYPASS FLOW INDUCED WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY
|
|
| 02-4-1 |
| • STEERING - IDLER ARM REPLACEMENT SPECIFICATIONS
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE |
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-25-5 |
| • BRAKES - REDUCED POWER ASSIST DURING OPERATION IN FREEZING AMBIENT TEMPERATURES - LIGHTNING MODELS ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-24-4 |
| • DRIVEABILITY - CNG BI-FUEL - NO START, LONG CRANK, HESITATION OR REDUCED ENGINE POWER - WHILE OPERATING IN BI-FUEL MODE ONLY - VEHICLES EQUIPPED WITH 5.4L CNG BI-FUEL ENGINE ONLY
|
|
| 01-24-3 |
| • DRIVEABILITY - BI-FUEL - REDUCED ENGINE POWER, RPM DIP OR IDLE SURGE GREATER THAN 200 RPM IMMEDIATELY FOLLOWING TIP-IN FROM A STOP - OPERATING IN ALTERNATIVE FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL |
| • ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH |
| • ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
|
| 01-21-10 |
| • ENGINE - 4.6L - OIL LEAK FROM HEAD GASKET AREA - ROMEO BUILT ENGINES ONLY
|
|
| 01-21-8 |
| • DRIVEABILITY - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID |
| • STARTING - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID
|
|
| 01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
|
|
| 01-21-5 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 11/01/01 EQUIPPED WITH 5.4L ENGINE |
| • ENGINE - 5.4L - PCV SYSTEM ICING - VEHICLES BUILT THROUGH 11/01/01
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART - SERVICE TIPS
|
|
| 01-20-8 |
| • TRANSMISSION - 4R70W - HARSH 1-2 SHIFT - VEHICLES EQUIPPED WITH 4.2L ENGINE AND 3.31 OR 3.55 AXLE RATIO - VEHICLES PRODUCED 8/2/1999 THROUGH 8/4/2000 ONLY
|
|
| 01-20-6 |
| • DRIVEABILITY - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART |
| • ELECTRICAL - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART
|
|
| 01-20-1 |
| • IDLE - HIGH IDLE AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000 |
| • ENGINE - 4.2L - PCV SYSTEM ICING - AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000
|
|
| 01-19-4 |
| • ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
|
|
| 01-19-2 |
| • BRAKES - REAR DRUM - GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
|
|
| 01-18-2 |
| • BODY - COSMETIC CRACK IN OUTER DOOR PANEL - LOWER REAR CORNER OF WINDOW OPENING - INSPECTION AND REPAIR PROCEDURE
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-5 |
| • DRIVEABILITY - BI-FUEL VEHICLES ONLY - NO START - GASOLINE OR ALT FUEL MODE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-14-1 |
| • ELECTRICAL - ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE - INADVERTENT 4X4 HI OR LOW SHIFT EVENTS |
| • TRANSMISSION - TRANSFER CASE - INADVERTENT 4X4 HI OR LOW SHIFT EVENTS - VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY (ESOF) ONLY
|
|
| 01-13-7 |
| • NOISE - "CLUNK" NOISE HEARD ON 2-1 DOWNSHIFT VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION |
| • TRANSMISSION - 4R70W - "CLUNK" NOISE HEARD FROM TRANSMISSION ON 2-1 DOWNSHIFT
|
|
| 01-13-6 |
| • DRIVEABILITY - CNG BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 2.0L OR 5.4L CNG BI-FUEL ENGINE ONLY
|
|
| 01-11-12 |
| • BODY - MOISTURE OR DIRT IN REAR TAIL LAMP LENS - F-150 FLARESIDE AND SUPER CREW MODELS ONLY
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY
|
|
| 01-9-3 |
| • VIBRATION - FROM DRIVELINE - 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE |
| • TRANSMISSION - 4R70W - FLUID LEAK FROM EXTENSION HOUSING SEAL - 4X2 VEHICLES WITH 139 INCH WHEELBASE
|
|
| 01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL VEHICLES ONLY
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-6-5 |
| • DRIVEABILITY - BI-FUEL - HESITATION OR IDLE SURGE - HARD START, NO START OR START THEN STALL - WITH FUEL SELECTOR SWITCH LAMP ON IN B-FUEL MODE - VEHICLES EQUIPPED WITH 5.4L/6.8L BI-FUEL ENGINE ONLY |
| • DRIVEABLITY - BI-FUEL - HARD START, NO START OR START THEN STALL, HESITATION OR IDLE SURGE - WITH FUEL SELECTOR SWITCH LAMP ON IN BI-FUEL MODE - VEHICLES EQUIPPED WITH 5.4L/6.8L BI-FUEL ENGINE ONLY
|
|
| 01-6-2 |
| • PASSIVE ANTI THEFT SYSTEM (PATS) - DIAGNOSTIC SERVICE TIPS
|
|
| 01-5-8 |
| • NOISE - "TICKING" OR "CLICKING" FROM TRANSMISSION - HEARD IN 1ST GEAR ONLY - VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION ONLY |
| • TRANSMISSION - 4R70W - "TICKING" OR "CLICKING" NOISE FROM TRANSMISSION - HEARD IN 1ST GEAR ONLY - VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION ONLY
|
|
| 01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4 VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| 01-1-6 |
| • DIAGNOSTIC TROUBLE CODES (DTCS) - P0350-P0360 COIL DTCS STORED IN MEMORY - ROUGH IDLE - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - COIL ON PLUG APPLICATIONS ONLY |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL ON PLUG APPLICATIONS ONLY |
| • ROUGH IDLE - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL ON PLUG APPLICATIONS ONLY
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000 |
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
|
|
| 00-25-8 |
| • STEERING - "CLUNK" NOISE FROM FRONT END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY |
| • SUSPENSION - "CLUNK" NOISE FROM FRONT END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY |
| • NOISE - "CLUNK" FROM FRONT END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ELECTRICAL - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ENGINE - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| 00-23-8 |
| • DRIVEABILITY - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F) |
| • ELECTRICAL - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F)
|
|
| 00-23-2 |
| • BUCK/JERK - WHILE DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY |
| • DRIVEABILITY - BUCK/JERK - WHILE DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY |
| • HESITATION - WHILE DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY
|
|
| 00-19-2 |
| • LAMP - COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES |
| • POWER WINDOWS - INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES |
| • RADIO - INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES |
| • REAR WIPER - INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES
|
|
| 00-18-3 |
| • COOLING SYSTEM - COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000 - VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE |
| • ENGINE - 4.6L 2V OR 5.4L 2V - COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000
|
|
| 00-9-6 |
| • WINDSHIELD WIPERS - FRONT WIPERS OPERATE WHILE SWITCH IS IN "OFF" POSITION
|
|
| 00-9-5 |
| • INNER FENDER WELL - DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK
|
|
| 00-8-4 |
| • NOISE - "CHATTERING" FROM REAR AXLE HEARD ON TURNS OR WHEN CORNERING - VEHICLES WITH LIMITED SLIP AXLE |
| • AXLE - LIMITED SLIP - REAR AXLE "CHATTERING" NOISE ON TURNS OR WHEN CORNERING
|
|
| 00-6-11 |
| • CALIBRATION - RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT - SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS STAMPED ON ROTOR - F-150 4X2 ONLY |
| • BRAKES - INCORRECT WORKSHOP MANUAL ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-25-3 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE |
| • POWERTRAIN CONTROL MODULE (PCM) - REPROGRAM - VEHICLES WITH 5.4L ENGINES
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO DRIVEABILITY CONCERNS
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
