Technical Service Bulletins
Year: 2000 MODEL: EXCURSION |
|
| 06-8-5 |
| • SPEED CONTROL DIAGNOSTICS - W/O SCP
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 06-3-6 |
| • HEADLAMP KNOB SWITCH - SERVICE TIP
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-18-7 |
| • WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE
|
|
| 05-16-11 |
| • SAFETY BELT RETRACTION SPEED
|
|
| 05-4-18 |
| • FALSE PARKING AID WARNINGS
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-25-4 |
| • HARD START OR NO START - 7.3L
|
|
| 04-24-5 |
| • REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
|
|
| 04-20-2 |
| • OIL LEAK - TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP) - 7.3L DIESEL
|
|
| 04-18-15 |
| • ADDING ADDITIONAL BULBS TO TURN
INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 04-18-5 |
| • AXLE - FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING
|
|
| 04-17-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS
|
|
| 04-4-4 |
| • ENGINE - 7.3L DIESEL DI - HIGH PRESSURE OIL PUMP LEAK
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-21-49 |
| • DRIVEABILITY - LOSS OF POWER AND EXTERNAL TURBO OIL LEAK - 7.3L DIESEL |
| • ENGINE - 7.3L DIESEL - LOSS OF POWER AND EXTERNAL TURBO OIL LEAK |
| • NOISE - EXHAUST NOISE FROM TURBO - 7.3L DIESEL
|
|
| 03-21-45 |
| • ENGINE - 7.3L - EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES
|
|
| 03-21-42 |
| • LACK OF POWER - UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES EQUIPPED WITH 7.3L DIT ENGINE ONLY - PRODUCED BEFORE 11/25/2000 ONLY |
| • ENGINE - 7.3L DIT - LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES PRODUCED BEFORE 11/25/2000 ONLY
|
|
| 03-21-41 |
| • DRIVEABILITY - NO START, LOSS OF POWER OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION - FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE |
| • FUEL - NO START, LOSS OF POWER OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION - FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE
|
|
| 03-21-40 |
| • DRIVEABILITY - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY |
| • ELECTRICAL - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY |
| • ELECTRICAL - SPEED CONTROL - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY
|
|
| 03-21-39 |
| • ENGINE - 7.3L DIESEL - ENGINE KNOCK OR "CACKLE" - 1999-2000 SUPER DUTY F-SERIES AND |
|
| 03-21-38 |
| • ENGINE - 7.3L DIT - HIGH INJECTION
CONTROL PRESSURE READINGS - ENGINES BUILT AFTER ENGINE
SERIAL NUMBER 896812
|
|
| 03-21-36 |
| • ENGINE - 7.3L DIESEL - GLOW PLUG
CONTROL MODULE - VEHICLES WITH CALIFORNIA EMISSIONS -
SERVICE TIP
|
|
| 03-20-5 |
| • DRIVEABILITY - NO START/REPEAT STARTER
FAILURE - REPEAT STARTER REPLACEMENT
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER BETWEEN START AND RUN
|
| • ENGINE - STARTING - STARTER STAYING
ENGAGED AT START UP
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350
AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY
(RKE) - SERVICE TIPS
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER
FLUSHER - SERVICE TIPS
|
|
| 03-14-3 |
| • SUSPENSION - 4X4 WHEEL HUB
NON-ENGAGEMENT/DISENGAGEMENT
|
| • AXLE - 4X4 WHEEL HUB
NON-ENGAGEMENT/DISENGAGEMENT
|
|
| 03-11-2 |
| • SUSPENSION - ON-VEHICLE FRONT
INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
| • AXLE - ON-VEHICLE FRONT INTEGRATED
HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
|
| 03-9-11 |
| • DRIVEABILITY - ROUGH IDLE AND/OR
HESITATION ON ACCELERATION - VEHICLES EQUIPPED WITH
5.4L OR 6.8L ENGINE ONLY
|
|
| 03-6-2 |
| • ENGINE - CYLINDER HEAD DECK LEAK - 4.6
AND 5.4L ENGINES - NEW "SERVICE-ONLY" GASKET AND
CYLINDER HEAD KITS AVAILABILITY
|
|
| 03-4-1 |
| • FRONT LOCKING HUBS - SERVICE TIP
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR
CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE
CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
DISLODGED
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING
OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP
"WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT
OR TWO-WAY RADIO SPEAKER
|
| • RADIO - ENTERTAINMENT OR TWO-WAY
COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS
CAUSED BY FUEL PUMP
|
| • NOISE - "WHINING"/"BUZZING" - COMES
THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER
AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED
APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS -
GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL -
FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
FROM PROPYLENE GLYCOL
|
| • ENGINE COOLANT - PROPYLENE
GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON
PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE
CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
MODELS ONLY - STICKING OR BINDING IGNITION LOCK
CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING
IGNITION SWITCH
|
|
| 01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD
LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP
SWITCH
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR
KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN
SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE
TIPS - OBD II VEHICLES ONLY
|
|
| 01-6-2 |
| • PASSIVE ANTI THEFT SYSTEM (PATS) -
DIAGNOSTIC SERVICE TIPS
|
|
| 01-4-9 |
| • BRAKES - FRONT DISC BRAKE PAD AND/OR
CALIPER RATTLE OVER BUMPS - REVISED FRONT BRAKE PADS
|
| • NOISE - RATTLE FROM FRONT DISC BRAKE
PAD AND/OR CALIPER - REVISED FRONT BRAKE PADS
|
|
| 01-3-2 |
| • STEERING - WANDERING/STIFF STEERING OR
POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY
|
| • SUSPENSION - WANDERING/STIFF STEERING
OR POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY
|
|
| 01-1-6 |
| • DIAGNOSTIC TROUBLE CODES (DTCS) -
P0350-P0360 COIL DTCS STORED IN MEMORY - ROUGH IDLE -
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - COIL ON
PLUG APPLICATIONS ONLY
|
| • MALFUNCTION INDICATOR LAMP (MIL)
ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES
(DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL
ON PLUG APPLICATIONS ONLY
|
| • ROUGH IDLE - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES
(DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE
CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY -
COIL ON PLUG APPLICATIONS ONLY
|
|
| 01-1-3 |
| • ENGINE - "MISS" NOISE FROM EXHAUST -
UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED
WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000
|
| • EXHAUST - "MISS" NOISE FROM EXHAUST -
UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED
WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000
|
| • NOISE - "MISS" NOISE FROM EXHAUST -
UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED
WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER
START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN
-12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996
THROUGH 7/31/2000
|
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS
AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS
THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT
3/1/1996 THROUGH 7/31/2000
|
|
| 00-24-4 |
| • TRANSMISSION - 4R100 - FLUID OVERHEATS
DURING SEVERE DUTY - AVAILABILITY OF UPDATED FLUID
COOLER/FILTER KIT - VEHICLES PRODUCED BEFORE 2/6/2000
|
|
| 00-18-3 |
| • COOLING SYSTEM - COOLANT LEAK FROM
PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF
HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000
- VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE
|
| • ENGINE - 4.6L 2V OR 5.4L 2V - COOLANT
LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR
CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH
6/30/2000
|
|
| 00-9-6 |
| • WINDSHIELD WIPERS - FRONT WIPERS
OPERATE WHILE SWITCH IS IN "OFF" POSITION
|
|
| 99-25-3 |
| • MALFUNCTION INDICATOR LAMP (MIL)
ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135,
P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY
CONCERNS - VEHICLES WITH 5.4L ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS)
P0135, P0141, P0155, P0161, AND P0455 - NO
DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE
|
| • POWERTRAIN CONTROL MODULE (PCM) -
REPROGRAM - VEHICLES WITH 5.4L ENGINES
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-17-7 |
| • ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
