Technical Service Bulletins
Year: 1999 MODEL: F-250 SUPER DUTY |
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY
EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A
STOP
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON
PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH
RUNNING
|
|
| 05-20-3 |
| • OIL PAN CORROSION - 7.3L OR 6.0L
|
|
| 05-17-6 |
| • DRIVE-AWAY SHUDDER OR VIBRATION
|
|
| 05-17-4 |
| • VACUUM PUMP INOPERATIVE OR RUNS
CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST
MODE
|
|
| 05-13-15 |
| • WATER IN THE FUEL TANK BEHIND REAR
AXLE - 6.0L AND 7.3L DIESEL ENGINE
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS
IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE -
NON-COMMANDED EGR FLOW
|
|
| 05-3-10 |
| • SAFETY BELT WEB STOP BUTTON SERVICE
|
|
| 04-24-22 |
| • LOSS OF POWER OR STUMBLE WHILE DRIVING
IN RAIN - 6.8L ENGINE
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-24-3 |
| • LEATHER-WRAPPED STEERING WHEEL -
LEATHER COMING LOOSE
|
|
| 04-23-9 |
| • WATER LEAK - ROOF FLANGE AREA - WATER
ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR
PAN AREA
|
|
| 04-23-6 |
| • VEHICLE LEAN/SAG WHEN OBSERVED FROM
REAR OF VEHICLE
|
|
| 04-20-2 |
| • OIL LEAK - TURBO PEDESTAL SEAL AT
EXHAUST BACK PRESSURE ACTUATOR (EBP) - 7.3L DIESEL
|
|
| 04-18-15 |
| • ADDING ADDITIONAL BULBS TO TURN
INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR
TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-18-5 |
| • AXLE - FRONT HUBS NOT ENGAGING, NOT
STAYING ENGAGED AND/OR UNLOCKING
|
|
| 04-16-4 |
| • REAR AXLE POPPING/CHATTER NOISE - DANA
80 MODEL DUAL REAR WHEEL (DRW)
|
|
| 04-4-4 |
| • ENGINE - 7.3L DIESEL DI - HIGH
PRESSURE OIL PUMP LEAK
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS
AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-21-49 |
| • DRIVEABILITY - LOSS OF POWER AND
EXTERNAL TURBO OIL LEAK - 7.3L DIESEL
|
| • ENGINE - 7.3L DIESEL - LOSS OF POWER
AND EXTERNAL TURBO OIL LEAK
|
| • NOISE - EXHAUST NOISE FROM TURBO -
7.3L DIESEL
|
|
| 03-21-45 |
| • ENGINE - 7.3L - EXTERNAL OIL LEAK
DIAGNOSIS FOR 7.3L DIT ENGINES
|
|
| 03-21-44 |
| • NO START - STARTER MOTOR GEAR TEETH
DAMAGE - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE -
MEXICO PRODUCED VEHICLES ONLY
|
| • ENGINE - 7.3L DIESEL - NO START -
STARTER MOTOR GEAR TEETH DAMAGE - MEXICO PRODUCED
VEHICLES ONLY
|
| • NOISE - STARTER MOTOR GEAR TEETH
DAMAGE - MEXICO PRODUCED VEHICLES ONLY
|
|
| 03-21-42 |
| • LACK OF POWER - UNDER A LOAD, AT
CRUISE OR ON ACCELERATION - VEHICLES EQUIPPED WITH
7.3L DIT ENGINE ONLY - PRODUCED BEFORE 11/25/2000 ONLY
|
| • ENGINE - 7.3L DIT - LACK OF POWER
UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES
PRODUCED BEFORE 11/25/2000 ONLY
|
|
| 03-21-41 |
| • DRIVEABILITY - NO START, LOSS OF POWER
OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION
- FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE
|
| • FUEL - NO START, LOSS OF POWER OR
ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION -
FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE
|
|
| 03-21-40 |
| • DRIVEABILITY - BUCK/SURGE FELT WITH
SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY
|
| • ELECTRICAL - BUCK/SURGE FELT WITH
SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY
|
| • ELECTRICAL - SPEED CONTROL -
BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L
ENGINE ONLY
|
|
| 03-21-38 |
| • ENGINE - 7.3L DIT - HIGH INJECTION
CONTROL PRESSURE READINGS - ENGINES BUILT AFTER ENGINE
SERIAL NUMBER 896812
|
|
| 03-21-37 |
| • ROUGH IDLE - NEW TOOL FOR TESTING
ROUGH IDLE - INJECTOR PERFORMANCE ANALYZER - SERVICE
TIP
|
|
| 03-21-35 |
| • IDLE - IDLE SPEED TOO LOW WHEN COLD -
VEHICLES WITHOUT CRUISE CONTROL AND WITH 7.3L DIESEL
ENGINE
|
| • ENGINE - 7.3L DIESEL - IDLE SPEED TOO
LOW WHEN COLD - VEHICLES WITHOUT CRUISE CONTROL
|
|
| 03-21-34 |
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - FALSE DIAGNOSTIC TROUBLE CODE
(DTC) P1298 STORED IN MEMORY - VEHICLES BUILT THROUGH
4/12/1999 WITH 7.3L DIESEL ENGINE
|
| • MALFUNCTION INDICATOR LAMP (MIL)
ILLUMINATED - FALSE DIAGNOSTIC TROUBLE CODE (DTC)
P1298 STORED IN MEMORY - VEHICLES BUILT THROUGH
4/12/1999 WITH 7.3L DIESEL ENGINE
|
|
| 03-21-33 |
| • ENGINE - 7.3L DIESEL - 1999 ENGINE
CONTENT REVISIONS
|
|
| 03-21-31 |
| • ROUGH IDLE - INJECTOR BORE SCUFFING
DURING ENGINE BREAK-IN PERIOD - SERVICE TIP
|
|
| 03-21-30 |
| • ENGINE - 7.3L DIRECT INJECTION DIESEL
- "CACKLING" NOISE HEARD WITH ENGINE WARM AND SLIGHTLY
ABOVE IDLE
|
| • ENGINE - 7.3L DIRECT INJECTION DIESEL
- "BUZZING" NOISE HEARD WITH KEY ON ENGINE OFF DURING
FUEL PUMP CYCLING
|
|
| 03-21-29 |
| • ENGINE - 7.3L DIT - 1998-99 ENGINE
CONTENT REVISIONS - SERVICE TIP
|
|
| 03-20-5 |
| • DRIVEABILITY - NO START/REPEAT STARTER
FAILURE - REPEAT STARTER REPLACEMENT
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER BETWEEN START AND RUN
|
| • ENGINE - STARTING - STARTER STAYING
ENGAGED AT START UP
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456,
P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
DTC P0457
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350
AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY
(RKE) - SERVICE TIPS
|
|
| 03-17-4 |
| • STEERING - STEERING WHEEL FIGHT AFTER
RIDING OVER BUMPS/RUTS
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER
FLUSHER - SERVICE TIPS
|
|
| 03-11-2 |
| • SUSPENSION - ON-VEHICLE FRONT
INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
| • AXLE - ON-VEHICLE FRONT INTEGRATED
HUB/BEARING ROCKING END-PLAY MEASUREMENT
|
|
| 03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR
DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| 03-6-2 |
| • ENGINE - CYLINDER HEAD DECK LEAK - 4.6
AND 5.4L ENGINES - NEW "SERVICE-ONLY" GASKET AND
CYLINDER HEAD KITS AVAILABILITY
|
|
| 03-4-1 |
| • FRONT LOCKING HUBS - SERVICE TIP
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR
CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE
CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
DISLODGED
|
|
| 02-17-12 |
| • MOTORHOME GENERATORS - SHUT OFF WHEN
FUEL TANK READS 1/4 FULL
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING
OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP
"WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT
OR TWO-WAY RADIO SPEAKER
|
| • RADIO - ENTERTAINMENT OR TWO-WAY
COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS
CAUSED BY FUEL PUMP
|
| • NOISE - "WHINING"/"BUZZING" - COMES
THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-14-1 |
| • SUSPENSION - SQUEAK NOISE FROM REAR
LEAF SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER
- VEHICLES PRODUCED BEFORE 10/15/01
|
| • NOISE - SQUEAK NOISE FROM REAR LEAF
SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER -
VEHICLES PRODUCED BEFORE 10/15/01
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER
AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-11-3 |
| • ELECTRICAL - VEHICLE SPEED SIGNAL
(VSS) INPUT NOTICED WHEN TESTING WITH NEW GENERATION
STAR TESTER (NGS) WHEN VEHICLE IS STOPPED - SUPER DUTY
F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH
7/31/2000
|
| • TRANSMISSION - 4R100 - TRANSMISSION
STARTS OUT IN 2ND GEAR - ERRATIC 1-2 UPSHIFT OR
ERRATIC 2-1 DOWNSHIFT FROM TRANSMISSION - SUPER DUTY
F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH
7/31/2000
|
|
| 02-10-8 |
| • DRIVEABILITY - 5.4L 2V - IDLE-AIR
BYPASS FLOW INDUCED WHISTLE
|
| • ENGINE - 5.4L 2V - IDLE-AIR BYPASS
FLOW INDUCED WHISTLE
|
| • NOISE - IDLE-AIR BYPASS FLOW INDUCED
WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE
|
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED
APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS -
GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL -
FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
FROM PROPYLENE GLYCOL
|
| • ENGINE COOLANT - PROPYLENE
GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON
PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE
CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
MODELS ONLY - STICKING OR BINDING IGNITION LOCK
CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING
IGNITION SWITCH
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF
SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART
- SERVICE TIPS
|
|
| 01-20-6 |
| • DRIVEABILITY - BI-FUEL WIRING
CONNECTOR CROSS-REFERENCE CHART
|
| • ELECTRICAL - BI-FUEL WIRING CONNECTOR
CROSS-REFERENCE CHART
|
|
| 01-17-3 |
| • VIBRATION - DRIVELINE DRONE OR
VIBRATION - FELT AT 80-96 KM/H (50-60 MPH) - VEHICLES
EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-5 |
| • DRIVEABILITY - BI-FUEL VEHICLES ONLY -
NO START - GASOLINE OR ALT FUEL MODE - VEHICLES
EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN
BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED
WITH BI-FUEL ENGINE ONLY
|
|
| 01-12-2 |
| • ENGINE - OIL LEAK FROM RIGHT SIDE HEAD
GASKET AREA - VEHICLES EQUIPPED WITH 4.6L/5.4L WINDSOR
ENGINE ONLY - SERVICE TIPS
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR
KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT
IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE
PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-10-5 |
| • ENGINE - 6.8L - OIL LEVEL INDICATOR
READS INACCURATE - SUPER DUTY F-53 MOTORHOME CHASSIS
VEHICLES - UPDATED OIL LEVEL INDICATOR
|
|
| 01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER
IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION
- VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE
ONLY
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN
SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE
TIPS - OBD II VEHICLES ONLY
|
|
| 01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II
DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL
VEHICLES ONLY
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT
STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN
BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-7-5 |
| • CLIMATE CONTROL - FACTORY INSTALLED
A/C PREP PACKAGE COMPONENT IDENTIFICATION AND WARRANTY
COVERAGE - F-53 SUPER DUTY CLASS A MOTORHOME CHASSIS
VEHICLES ONLY
|
|
| 01-7-2 |
| • ENGINE - 6.8L - "SQUEALING" NOISE FROM
ENGINE COMPARTMENT - COMING FROM FRONT END ACCESSORY
DRIVE (FEAD) BELT AREA - F-53 MOTORHOME CHASSIS
VEHICLES BUILT 1/5/1998 THROUGH 7/18/1999 ONLY
|
| • NOISE - "SQUEALING" FROM ENGINE
COMPARTMENT - COMING FROM FRONT END ACCESSORY DRIVE
(FEAD) BELT AREA - F-53 MOTORHOME CHASSIS VEHICLES
BUILT 1/5/1998 THROUGH 7/18/1999 ONLY
|
|
| 01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT
INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4
VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| 01-3-2 |
| • STEERING - WANDERING/STIFF STEERING OR
POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY
|
| • SUSPENSION - WANDERING/STIFF STEERING
OR POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER
START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN
-12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996
THROUGH 7/31/2000
|
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS
AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS
THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT
3/1/1996 THROUGH 7/31/2000
|
|
| 00-24-6 |
| • TRANSMISSION - 4R100 - ERRATIC
SHIFTING - EARLY AND/OR LATE SHIFTS - VEHICLES
EQUIPPED WITH 6.8L ENGINE BUILT 1/12/1998 THROUGH
7/3/1999 ONLY
|
|
| 00-24-4 |
| • TRANSMISSION - 4R100 - FLUID OVERHEATS
DURING SEVERE DUTY - AVAILABILITY OF UPDATED FLUID
COOLER/FILTER KIT - VEHICLES PRODUCED BEFORE 2/6/2000
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER
KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-21-9 |
| • SUSPENSION - VIBRATION/SHAKE FELT IN
STEERING WHEEL OR SEAT 72-120 KM/H (45-75 MPH)
|
| • VIBRATION - VIBRATION/SHAKE FELT IN
STEERING WHEEL OR SEAT 72-120 KM/H (45-75) MPH
|
|
| 00-18-9 |
| • MIRRORS - SIDE VIEW SIGNAL MIRRORS -
DELAMINATION OF SIGNAL MIRROR CHROME PLATING - MIRROR
GLASS BLACK SPOTS
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT
RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC
TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR
END TANK
|
|
| 00-7-4 |
| • BRAKES - PREMATURE REAR BRAKE PAD WEAR
- SEVERE DUTY OPERATION - 17,500 LB F-550 AND ALL
F-450 ONLY
|
|
| 00-1-6 |
| • SUSPENSION - FRONT STABILITY BAR MAY
BREAK OFF - VEHICLES BUILT FROM 1/1/1998
|
|
| 99-25-8 |
| • BRAKES - GRABBING OR PEDAL KICKBACK
|
| • STEERING - INCREASED STEERING EFFORT
|
| • NOISE - "HISSING" HEARD WHILE APPLYING
BRAKES
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS
STAMPED ON ROTOR - F-150 4X2 ONLY
|
| • BRAKES - INCORRECT WORKSHOP MANUAL
ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-24-6 |
| • NOISE - "THUMPING" FROM THE A/C SYSTEM
DURING COLD ENGINE STARTUP - VEHICLES BUILT THROUGH
11/29/1999
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK
COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-6 |
| • TRANSMISSION - 4R100 - FLEXPLATE
REPLACEMENT - VEHICLES WITH 7.3L DIESEL ENGINE -
SERVICE TIP
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) -
DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO
DRIVEABILITY CONCERNS
|
|
| 99-23-2 |
| • AXLE - GAWR - INCREASING GAWR -
SERVICE TIP
|
|
| 99-21-2 |
| • WHEELS - HUB CAPS FALLING OFF WHILE
DRIVING - VEHICLES BUILT THROUGH 10/16/1999
|
|
| 99-18-10 |
| • TRANSMISSION - M6OD - BROKEN/BENT
SHIFT LEVER - VEHICLES WITH 7.3L DIESEL ENGINE
|
| • TRANSMISSION - M6OD - HARD SHIFTING -
VEHICLES WITH 7.3L DIESEL ENGINE
|
|
| 99-18-7 |
| • NOISE - "SQUAWKING" NOISE HEARD WHILE
IN REVERSE BACKING UP - VEHICLES EQUIPPED WITH 5.4L OR
6.8L ENGINE
|
| • TRANSMISSION - 4R100 - "SQUAWKING"
NOISE HEARD WHILE IN REVERSE BACKING UP - VEHICLES
EQUIPPED WITH 5.4L OR 6.8L ENGINE
|
|
| 99-16-9 |
| • TRANSMISSION - 4R100 - 3-4/4-3 SHIFT
HUNT WHILE THE CRUISE CONTROL IS IN USE - VEHICLES
WITH 7.3L DIESEL ENGINE
|
| • TRANSMISSION - 4R100 - NO 3-4 UPSHIFT
WHILE THE CRUISE CONTROL IS IN USE - VEHICLES WITH
7.3L DIESEL ENGINE
|
|
| 99-16-4 |
| • IGNITION KEY - HARD TO REMOVE FROM
IGNITION CYLINDER
|
| • IGNITION KEY - HARD TO TURN
|
|
| 99-16-3 |
| • SUSPENSION - FRONT LEAF SPRINGS -
"SQUEAKING" NOISE HEARD WHILE DRIVING
|
| • NOISE - "SQUEAKING" NOISE HEARD FROM
FRONT LEAF SPRINGS WHILE DRIVING
|
|
| 99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH
AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| 99-14-7 |
| • CALIBRATION INFORMATION - VEHICLES
BUILT THROUGH 1/29/1999 - APPLICABLE ENGINES ARE 2.0L,
2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L,
6.8L, AND 7.3L - SERVICE TIP
|
|
| 99-14-5 |
| • SUSPENSION - REAR OF VEHICLE IS TOO
HIGH/LOW - 5TH WHEEL AND GOOSE NECK APPLICATIONS - 4X4
VEHICLES BUILT THROUGH 2/14/1999
|
|
| 99-13-6 |
| • BRAKES - INNER REAR PAD - PREMATURE
WEAR
|
|
| 99-12-12 |
| • BRAKES - NEW DESIGN FRONT ROTOR AND
HUB - INCLUDES VEHICLES WITH 4X4 - SERVICE TIP
|
|
| 99-11-1 |
| • NOISE - TSB SPECIAL FOR
NOISE/VIBRATION/HARSHNESS
|
| • VIBRATION - TSB SPECIAL FOR
NOISE/VIBRATION/HARSHNESS
|
|
| 99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL
REPLACEMENT - SERVICE TIP
|
|
| 99-8-1 |
| • TRANSMISSION - 4R100 - SHIFT FLARE
(RISE IN ENGINE RPM) DURING 2-3 AND/OR 3-4 UPSHIFT -
VEHICLES BUILT THROUGH 12/7/1998 WITH 7.3L DIESEL
ENGINE
|
|
| 99-7-4 |
| • TRANSMISSION - 4R100 - OIL-TO-AIR
TRANSMISSION FLUID COOLER - SERVICE TIP
|
|
| 99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) -
SERVICE TIPS
|
|
| 99-5-3 |
| • TRANSMISSION - CHECKING TRANSMISSION
FLUID LEVEL COLD - SERVICE TIP
|
|
| 99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL
MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| 99-4-2 |
| • BRAKES - ILLUMINATION OF RED BRAKE
WARNING LAMP - BRAKE FLUID LEAK FROM REAR CALIPER -
VEHICLES BUILT THROUGH 10/22/1998
|
| • BRAKES - INCREASED BRAKE PEDAL TRAVEL
- BRAKE FLUID LEAK FROM REAR CALIPER - VEHICLES BUILT
THROUGH 10/22/1998
|
| • BRAKES - SPONGY BRAKE PEDAL FEEL -
BRAKE FLUID LEAK FROM REAR CALIPER - VEHICLES BUILT
THROUGH 10/22/1998
|
| • LAMP - ILLUMINATION OF RED BRAKE
WARNING LAMP - BRAKE FLUID LEAK FROM REAR CALIPER -
VEHICLES BUILT THROUGH 10/22/1998
|
|
| 99-3-5 |
| • NOISE - "RATTLING" NOISE FROM
CONVERTER AREA - VEHICLES EQUIPPED WITH 4R100
TRANSMISSION AND 7.3L DIESEL ENGINE
|
| • TRANSMISSION - 4R100 - "RATTLING"
NOISE FROM CONVERTER AREA - VEHICLES EQUIPPED WITH
7.3L DIESEL ENGINE
|
|
| 99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING -
SERVICE TIP
|
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| 99-1-6 |
| • CLUTCH - LOW CLUTCH PEDAL ENGAGEMENT -
VEHICLES BUILT THROUGH 9/12/1998 WITH 7.3L ENGINE AND
M6 TRANSMISSION
|
|
| 98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS
TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| 98-25-9 |
| • INTERIOR TRIM - REPAIRS TO VINYL
COVERED SURFACES - SERVICE TIP
|
|
| 98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE
RELEASED FOR SERVICE
|
|
| 98-23-21 |
| • SUSPENSION - FRONT OR REAR -
SIDE-TO-SIDE LEVELING PROCEDURES AND ATTITUDE SERVICE
KITS FOR F-53 RV BASIC STRIPPED CHASSIS
|
|
| 98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR
CONTAMINATION - SERVICE TIP
|
|
| 98-23-8 |
| • AIR CONDITIONING - CONDENSATE DRIPS
ONTO PASSENGER FLOOR
|
|
| 98-22-4 |
| • BRAKES - "WHISTLING" NOISE FROM
HYDRO-MAX BRAKE BOOSTER ASSEMBLY - MOTORHOME CHASSIS
VEHICLES
|
| • NOISE - "WHISTLING" FROM HYDRO-MAX
BRAKE BOOSTER ASSEMBLY - MOTORHOME CHASSIS VEHICLES
|
|
| 98-21-20 |
| • STEERING - STEERING WHEEL ALIGNMENT -
CLEAR VISION - VEHICLES WITH MOTORHOME CHASSIS
|
|
| 98-21-17 |
| • BRAKES - PARKING BRAKE CONTROL RUBBER
BUMPER STOP - SERVICE PART NOW AVAILABLE
|
|
| 98-20-19 |
| • POWER SEAT SWITCH - BUTTON COMES OFF
|
|
| 98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR
MUFFLER HEAT SHIELDS
|
| • NOISE - "BUZZING" OR "RATTLING" -
LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| 98-20-9 |
| • NOISE - "TICKING" OCCURS ON INITIAL
STARTUP WITH SHIFT SELECTOR IN "P" OR "N" POSITION -
VEHICLES WITH E4OD/4R100 TRANSMISSION AND BUILT
THROUGH 6/11/98
|
| • TRANSMISSION - E4OD/4R100 - "TICKING"
NOISE OCCURS ON INITIAL STARTUP WITH SHIFT SELECTOR IN
"P" OR "N" POSITION - VEHICLES BUILT THROUGH 6/11/98
|
|
| 98-20-3 |
| • BODY - ADHESIVES NOT RECOMMENDED FOR
BODY PANEL REPAIRS - SERVICE TIP
|
|
| 98-19-3 |
| • AIR CONDITIONING - INOPERATIVE -
VEHICLES BUILT THROUGH 7/30/98
|
| • AIR CONDITIONING - TEMPERATURE CONTROL
INOPERATIVE - VEHICLES BUILT THROUGH 7/30/98
|
| • FUSE - FUSE #24 IN JUNCTION BLOCK OPEN
|
|
| 98-17-23 |
| • BODY - TAILGATE MOULDING - WARPING
|
|
| 98-16-10 |
| • SEAT - SEAT BACK RECLINER INOPERATIVE
- MEMORY LATCH DOES NOT ENGAGE
|
|
| 98-16-8 |
| • TRANSMISSION - E4OD/4R100 - 1989-99 -
MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE
GASKETS USAGE CHART
|
|
| 98-12-5 |
| • AIR CONDITIONING - FILTERING
REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT - SERVICE
TIPS
|
|
| 98-11-10 |
| • AXLE - FLUID LEAKS FROM REAR AXLE VENT
TUBE - F-350, F-450 DRW VEHICLES BUILT THROUGH 3/2/98
AND F-450 MOTORHOME CHASSIS BUILT THROUGH 3/25/98 -
VEHICLES EQUIPPED WITH 6.8L OR 7.3L ENGINE AND DANA
MODEL 80 REAR AXLES
|
|
| 98-8-10 |
| • TRAILER WIRING - CONVERTING A 4-WAY
TRAILER CONNECTOR SYSTEM TO A 7-WAY HEAVY DUTY SYSTEM
- SERVICE TIP
|
|
| 98-7-7 |
| • MIRROR - TRAILER TOW MIRROR GLASS
REPLACEMENT PROCEDURE
|
|
| 98-7-4 |
| • LEAKS - OIL - AVAILABILITY OF NEW
SILICONE GASKET AND SEALANT
|
|
| 98-4-4 |
| • PAINT - ANTI-CHIP STONE ABRASION
UNDERCOAT - SERVICE TIP
|
|
