Technical Service Bulletins
Year: 1999 MODEL: F-150 |
|
| *06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY
EYE - CHARGING SERVICE TIPS
|
|
| *05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A
STOP
|
|
| *05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| *05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON
PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH
RUNNING
|
|
| *05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED
NATURAL GAS FUEL TANK INSPECTION
|
|
| *05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS
IN SERVICE FOR 5.4L 2V ENGINE
|
|
| *05-4-17 |
| • INTERMITTENT ROUGH IDLE -
NON-COMMANDED EGR FLOW
|
|
| *04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| *04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM
THE CATALYTIC CONVERTERS
|
|
| *04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR
TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| *04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP
NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW
BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| *04-2-2 |
| • BODY - BACK GLASS - SLIDING BACK GLASS
WINDNOISE/WATER LEAK - SEAL REPLACEMENT
|
|
| *04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING
NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE
ACCELERATION AND/OR BRAKING
|
| • TRANSMISSION - DRIVELINE
CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING
LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| *03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS
AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| *03-21-39 |
| • ENGINE - 7.3L DIESEL - ENGINE KNOCK OR
"CACKLE" - 1999-2000 SUPER DUTY F-SERIES AND 2000
EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH
1311240 - ALL 1998-2000 E-SERIES WITH ENGINE SERIAL
NUMBERS 661974 THROUGH 1311240
|
| • NOISE - "CACKLE" OR ENGINE KNOCK -
7.3L DIESEL - 1999-2000 SUPER DUTY F-SERIES AND 2000
EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH
1311240 - ALL 1998-2000 E-SERIES WITH ENGINE SERIAL
NUMBERS 661974 THROUGH 1311240
|
|
| *03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED
NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE -
ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF
POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC
CONVERTER
|
| • ENGINE - DEDICATED COMPRESSED NATURAL
GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH
IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER
- LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| *03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456,
P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
DTC P0457
|
|
| *03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED
NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD -
VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG
ENGINE ONLY
|
|
| *03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY
(RKE) - SERVICE TIPS
|
|
| *03-15-13 |
| • STEERING - TIE ROD END INSPECTION
PROCEDURE
|
|
| *03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER
FLUSHER - SERVICE TIPS
|
|
| *03-10-4 |
| • DRIVEABILITY - BI-FUEL LPG LOW FLOW
INJECTOR SERVICE ASSEMBLY WITH COOLANT LOCK-OFF
|
|
| *03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW
FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
| • DRIVEABILITY - CRANK NO START -
BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE
KIT WITHOUT COOLANT LOCK-OFF
|
|
| *03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS
(CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES
EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| *03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR
DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| *03-6-2 |
| • ENGINE - CYLINDER HEAD DECK LEAK - 4.6
AND 5.4L ENGINES - NEW "SERVICE-ONLY" GASKET AND
CYLINDER HEAD KITS AVAILABILITY
|
|
| *03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL
VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED
SERVICE PARTS
|
|
| *03-2-4 |
| • BODY - DRIVER SIDE WINDOW BINDS WHEN
OPERATED
|
| • ELECTRICAL - DRIVER SIDE WINDOW BINDS
WHEN OPERATED
|
|
| *02-23-4 |
| • DIAGNOSTIC TROUBLE CODE (DTC) - P1635
AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE
(PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE
ENGINE VEHICLES ONLY
|
| • LAMP - 4X4 LAMP ILLUMINATED AFTER
POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER
REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY
|
| • SPEEDOMETER - INACCURATE AND/OR
INOPERATIVE AFTER POWERTRAIN CONTROL MODULE (PCM) OR
INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE
VEHICLES ONLY
|
|
| *02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE -
GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION -
CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL
CORRECT APPLICATION
|
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS -
INCORRECT INSTALLATION - CAMSHAFT POSITION
SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT
APPLICATION
|
|
| *02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR
CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| *02-21-11 |
| • RIDE - HARSH RIDE - CAB/BODY
OSCILLATION/BOUNCE - HIGHWAY SPEEDS - 4X2 MODELS ONLY
|
|
| *02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE
TIPS
|
|
| *02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE
CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
DISLODGED
|
|
| *02-19-3 |
| • DRIVEABILITY - IDLE - HIGH IDLE SPEEDS
- THROTTLE STICKS AFTER STEADY STATE DRIVING IN
EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT
THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
|
| • 4.6L - IDLE - HIGH IDLE SPEEDS -
THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME
COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH
12/31/01 EQUIPPED WITH 4.6L ENGINE
|
|
| *02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING
OF BRAKE SHIFT INTERLOCK
|
|
| *02-16-4 |
| • FUEL SYSTEM - FUEL PUMP
"WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT
OR TWO-WAY RADIO SPEAKER
|
| • RADIO - ENTERTAINMENT OR TWO-WAY
COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS
CAUSED BY FUEL PUMP
|
| • NOISE - "WHINING"/"BUZZING" - COMES
THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| *02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER
AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| *02-10-8 |
| • DRIVEABILITY - 5.4L 2V - IDLE-AIR
BYPASS FLOW INDUCED WHISTLE
|
| • ENGINE - 5.4L 2V - IDLE-AIR BYPASS
FLOW INDUCED WHISTLE
|
| • NOISE - IDLE-AIR BYPASS FLOW INDUCED
WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY
|
|
| *02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE
|
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| *02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED
APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS -
GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| *01-25-5 |
| • BRAKES - REDUCED POWER ASSIST DURING
OPERATION IN FREEZING AMBIENT TEMPERATURES - LIGHTNING
MODELS ONLY
|
|
| *01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| *01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL -
FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
FROM PROPYLENE GLYCOL
|
| • ENGINE COOLANT - PROPYLENE
GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON
PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| *01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE
CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
MODELS ONLY - STICKING OR BINDING IGNITION LOCK
CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING
IGNITION SWITCH
|
|
| *01-21-12 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE
STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD
AMBIENT TEMPERATURES - VEHICLES BUILT 12/2/1997
THROUGH 7/15/1999 EQUIPPED WITH 5.4L ENGINE
|
| • ENGINE - 5.4L - PCV SYSTEM ICING -
VEHICLES BUILT 12/2/1997 THROUGH 7/15/1999 ONLY
|
|
| *01-21-10 |
| • ENGINE - 4.6L - OIL LEAK FROM HEAD
GASKET AREA - ROMEO BUILT ENGINES ONLY
|
|
| *01-21-8 |
| • DRIVEABILITY - NO CRANK, NO START -
CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE
STARTER SOLENOID
|
| • STARTING - NO CRANK, NO START -
CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE
STARTER SOLENOID
|
|
| *01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD
LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP
SWITCH
|
|
| *01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF
SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART
- SERVICE TIPS
|
|
| *01-20-6 |
| • DRIVEABILITY - BI-FUEL WIRING
CONNECTOR CROSS-REFERENCE CHART
|
| • ELECTRICAL - BI-FUEL WIRING CONNECTOR
CROSS-REFERENCE CHART
|
|
| *01-20-1 |
| • IDLE - HIGH IDLE AFTER STEADY STATE
DRIVING IN EXTREME COLD AMBIENT TEMPERATURES -
VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH
1/24/2000
|
| • ENGINE - 4.2L - PCV SYSTEM ICING -
AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT
TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE
BUILT THROUGH 1/24/2000
|
|
| *01-19-2 |
| • BRAKES - REAR DRUM - GRABBING DURING
FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
|
|
| *01-18-2 |
| • BODY - COSMETIC CRACK IN OUTER DOOR
PANEL - LOWER REAR CORNER OF WINDOW OPENING -
INSPECTION AND REPAIR PROCEDURE
|
|
| *01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| *01-15-5 |
| • DRIVEABILITY - BI-FUEL VEHICLES ONLY -
NO START - GASOLINE OR ALT FUEL MODE - VEHICLES
EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| *01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN
BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED
WITH BI-FUEL ENGINE ONLY
|
|
| *01-14-1 |
| • ELECTRICAL - ELECTRONIC SHIFT ON THE
FLY (ESOF) TRANSFER CASE - INADVERTENT 4X4 HI OR LOW
SHIFT EVENTS
|
| • TRANSMISSION - TRANSFER CASE -
INADVERTENT 4X4 HI OR LOW SHIFT EVENTS - VEHICLES
EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY (ESOF) ONLY
|
|
| *01-13-7 |
| • NOISE - "CLUNK" NOISE HEARD ON 2-1
DOWNSHIFT VEHICLES EQUIPPED WITH 4R70W AUTOMATIC
TRANSMISSION
|
| • TRANSMISSION - 4R70W - "CLUNK" NOISE
HEARD FROM TRANSMISSION ON 2-1 DOWNSHIFT
|
|
| *01-13-6 |
| • DRIVEABILITY - CNG BI-FUEL - PARAMETER
IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION
- VEHICLES EQUIPPED WITH 2.0L OR 5.4L CNG BI-FUEL
ENGINE ONLY
|
|
| *01-12-2 |
| • ENGINE - OIL LEAK FROM RIGHT SIDE HEAD
GASKET AREA - VEHICLES EQUIPPED WITH 4.6L/5.4L WINDSOR
ENGINE ONLY - SERVICE TIPS
|
|
| *01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR
KIT AND WIRE SPLICE PROCEDURE
|
|
| *01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT
IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| *01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE
PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| *01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER
IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION
- VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE
ONLY
|
|
| *01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN
SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE
TIPS - OBD II VEHICLES ONLY
|
|
| *01-9-3 |
| • VIBRATION - FROM DRIVELINE - 4X2
VEHICLES WITH 4R70W AND 139 INCH WHEELBASE
|
| • TRANSMISSION - 4R70W - FLUID LEAK FROM
EXTENSION HOUSING SEAL - 4X2 VEHICLES WITH 139 INCH
WHEELBASE
|
|
| *01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II
DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL
VEHICLES ONLY
|
|
| *01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT
STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN
BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| *01-8-2 |
| • DRIVEABILITY - NO START - BI-FUEL
LIGHT ON THEN OFF - REVISED DIAGNOSTIC PROCEDURE -
BI-FUEL VEHICLES ONLY
|
|
| *01-6-2 |
| • PASSIVE ANTI THEFT SYSTEM (PATS) -
DIAGNOSTIC SERVICE TIPS
|
|
| *01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT
INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4
VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| *01-1-11 |
| • WATER LEAK - SLIDING REAR WINDOW -
VEHICLES BUILT THROUGH 4/1999
|
|
| *00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER
START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN
-12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996
THROUGH 7/31/2000
|
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS
AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS
THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT
3/1/1996 THROUGH 7/31/2000
|
|
| *00-25-8 |
| • STEERING - "CLUNK" NOISE FROM FRONT
END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL
VEHICLES ONLY
|
| • SUSPENSION - "CLUNK" NOISE FROM FRONT
END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL
VEHICLES ONLY
|
| • NOISE - "CLUNK" FROM FRONT END DURING
PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY
|
|
| *00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER
KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| *00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT
PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
| • ELECTRICAL - COMPUVALVE REPLACEMENT
PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
| • ENGINE - COMPUVALVE REPLACEMENT
PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| *00-23-8 |
| • DRIVEABILITY - NO CRANK/NO START -
MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES
BELOW -12 DEGREES C (10 DEGREES F)
|
| • ELECTRICAL - NO CRANK/NO START -
MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES
BELOW -12 DEGREES C (10 DEGREES F)
|
|
| *00-23-2 |
| • BUCK/JERK - WHILE DRIVING IN ANY FUEL
MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY
|
| • DRIVEABILITY - BUCK/JERK - WHILE
DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L
BI-FUEL ENGINE ONLY
|
| • HESITATION - WHILE DRIVING IN ANY FUEL
MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY
|
|
| *00-19-2 |
| • LAMP - COURTESY, GLOVE COMPARTMENT,
UNDERHOOD, RUNNING BOARD LAMPS INOPERATIVE IN MORNING
OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES
|
| • POWER WINDOWS - INOPERATIVE IN MORNING
OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES
|
| • RADIO - INOPERATIVE IN MORNING OR
AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES
|
| • REAR WIPER - INOPERATIVE IN MORNING OR
AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES
|
|
| *00-18-9 |
| • MIRRORS - SIDE VIEW SIGNAL MIRRORS -
DELAMINATION OF SIGNAL MIRROR CHROME PLATING - MIRROR
GLASS BLACK SPOTS
|
|
| *00-18-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL
ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171
AND/OR P0174 STORED IN MEMORY AT IDLE AND/OR NEUTRAL -
LIGHTNING MODELS WITH 5.4L SUPERCHARGED ENGINE ONLY
BUILT 3/1/1999 THROUGH 8/1/1999
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC)
P0171 AND/OR P0174 STORED IN MEMORY AT IDLE AND/OR
NEUTRAL - LIGHTNING MODELS WITH 5.4L SUPERCHARGED
ENGINE ONLY BUILT 3/1/1999 THROUGH 8/1/1999
|
|
| *00-10-4 |
| • IDLE - ROUGH IDLE SPEED - BI-FUEL
VEHICLES ONLY
|
| • STALL - DURING IDLE SPEEDS - BI-FUEL
VEHICLES ONLY
|
|
| *00-9-6 |
| • WINDSHIELD WIPERS - FRONT WIPERS
OPERATE WHILE SWITCH IS IN "OFF" POSITION
|
|
| *00-9-5 |
| • INNER FENDER WELL - DENTED OR DINGED
FROM STONES BEING THROWN INTO WHEELWELL
|
|
| *00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT
RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC
TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR
END TANK
|
|
| *00-8-4 |
| • NOISE - "CHATTERING" FROM REAR AXLE
HEARD ON TURNS OR WHEN CORNERING - VEHICLES WITH
LIMITED SLIP AXLE
|
| • AXLE - LIMITED SLIP - REAR AXLE
"CHATTERING" NOISE ON TURNS OR WHEN CORNERING
|
|
| *00-6-11 |
| • CALIBRATION - RECALIBRATION OF
POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT -
SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| *99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS
STAMPED ON ROTOR - F-150 4X2 ONLY
|
| • BRAKES - INCORRECT WORKSHOP MANUAL
ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| *99-25-5 |
| • BRAKES - REAR BRAKE DRAG AND/OR
PREMATURE WEAR OF THE REAR BRAKE LININGS
|
|
| *99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK
COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| *99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) -
DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO
DRIVEABILITY CONCERNS
|
|
| *99-21-3 |
| • AUTO-LOCK - AUTO-LOCK FUNCTIONS NOT
OPERATING PROPERLY - VEHICLES BUILT FROM 6/3/1999
THROUGH 6/8/1999
|
|
| *99-19-7 |
| • LAMP - INTERMITTENT MALFUNCTION
INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE
CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE
STORED IN MEMORY - VEHICLES BUILT FROM 8/1/1998
THROUGH 5/1/1999 WITH 4R70W TRANSMISSION
|
| • LAMP - INTERMITTENT TRANSMISSION
CONTROL INDICATOR LAMP (TCIL) ILLUMINATION -
DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755,
AND P1746 MAY BE STORED IN MEMORY - VEHICLES BUILT
FROM 8/1/1998 THROUGH 5/1/1999 WITH 4R70W TRANSMISSION
|
| • TRANSMISSION - 4R70W - INTERMITTENT
TRANSMISSION CONTROL INDICATOR LAMP (TCIL)
ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS) P0741,
P0750, P0755, AND P1746 MAY BE STORED IN MEMORY -
VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999
|
|
| *99-18-8 |
| • INDUCTION BACKFIRE - ON ACCELERATION -
ALL AMBIENT TEMPERATURES - VEHICLES WITH 4.2L ENGINE -
CANADIAN VEHICLES ONLY
|
|
| *99-18-5 |
| • TRANSMISSION CONTROL INDICATOR LAMP
(TCIL) - TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE
(DTC) P0782 STORED IN MEMORY - VEHICLES BUILT BETWEEN
3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION
|
| • TRANSMISSION - 4R70W - DELAYED OR NO
2-3 UPSHIFT - VEHICLES BUILT BETWEEN 3/15/1997 AND
12/31/1998
|
|
| *99-16-4 |
| • IGNITION KEY - HARD TO REMOVE FROM
IGNITION CYLINDER
|
| • IGNITION KEY - HARD TO TURN
|
|
| *99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH
AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| *99-14-10 |
| • INDUCTION BACKFIRE - VEHICLES IN
MEXICO ONLY WITH 4.2L ENGINE
|
| • ENGINE - 4.2L - INDUCTION BACKFIRE -
VEHICLES IN MEXICO ONLY
|
|
| *99-14-7 |
| • CALIBRATION INFORMATION - VEHICLES
BUILT THROUGH 1/29/1999 - APPLICABLE ENGINES ARE 2.0L,
2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L,
6.8L, AND 7.3L - SERVICE TIP
|
|
| *99-14-3 |
| • NOISE - "MOANING" FROM FRONT
DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT
THROUGH 4/15/1999
|
| • AXLE - "MOANING" NOISE FROM FRONT
DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT
THROUGH 4/15/1999
|
|
| *99-13-13 |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - ABS
LAMP ILLUMINATED - 4X2 ONLY
|
| • ANTI-LOCK BRAKE SYSTEM (ABS) - FALSE
ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
| • ANTI-LOCK BRAKE SYSTEM (ABS) -
INCREASED BRAKE PEDAL EFFORT AT LOW SPEEDS - 4X2 ONLY
|
| • LAMP - ANTI-LOCK BRAKE LAMP
ILLUMINATION - INCREASED BRAKE PEDAL EFFORT AND/OR
FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
|
| *99-12-8 |
| • AIR CONDITIONING - "WHISTLING" NOISE
HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64
KM/H (40 MPH)
|
| • NOISE - "WHISTLING" HEARD WHILE
DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
|
|
| *99-12-4 |
| • NOISE - "CLUNKING" HEARD DURING 4-3
COASTDOWN WHILE DECELERATING FROM 48-32 KM/H (30-20
MPH) - VEHICLES WITH 5.4L ENGINE AND 4R70W
TRANSMISSION
|
| • TRANSMISSION - 4R70W - 4-3 COASTDOWN
"CLUNK" WHILE DECELERATING FROM 48-32 KM/H (30-20 MPH)
- VEHICLES WITH 5.4L ENGINE
|
|
| *99-11-1 |
| • NOISE - TSB SPECIAL FOR
NOISE/VIBRATION/HARSHNESS
|
| • VIBRATION - TSB SPECIAL FOR
NOISE/VIBRATION/HARSHNESS
|
|
| *99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL
REPLACEMENT - SERVICE TIP
|
|
| *99-8-12 |
| • INTERIOR - STORAGE BIN INSIDE CONSOLE
DETACHES FROM BOX - SUPER CAB VEHICLES BUILT THROUGH
4/1/1999
|
|
| *99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) -
SERVICE TIPS
|
|
| *99-5-4 |
| • FRAME - FRAME SERVICE KITS - NEW
SERVICE PARTS RELEASED FOR REPAIRING FRAME DAMAGE
|
|
| *99-5-3 |
| • TRANSMISSION - CHECKING TRANSMISSION
FLUID LEVEL COLD - SERVICE TIP
|
|
| *99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL
MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| *99-3-2 |
| • TRANSMISSION - M5OD - VEHICLE WILL NOT
GO INTO REVERSE - VEHICLES BUILT THROUGH 11/1/1998
|
|
| *99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING -
SERVICE TIP
|
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| *99-2-2 |
| • NOISE - "BUZZING" - UNDERHOOD WHEN AIR
SUSPENSION IS IN OPERATION
|
|
| *98-5A-5 |
| • BRAKES - AVAILABILITY OF HUB-MOUNT
BRAKE ROTOR MACHINING EQUIPMENT
|
| • BRAKE ROTOR MACHINING - AVAILABILITY
OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
|
|
| *98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS
TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| *98-25-9 |
| • INTERIOR TRIM - REPAIRS TO VINYL
COVERED SURFACES - SERVICE TIP
|
|
| *98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE
RELEASED FOR SERVICE
|
|
| *98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR
CONTAMINATION - SERVICE TIP
|
|
| *98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR
MUFFLER HEAT SHIELDS
|
| • NOISE - "BUZZING" OR "RATTLING" -
LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| *98-7-7 |
| • MIRROR - TRAILER TOW MIRROR GLASS
REPLACEMENT PROCEDURE
|
|
| *98-7-4 |
| • LEAKS - OIL - AVAILABILITY OF NEW
SILICONE GASKET AND SEALANT
|
|
| *98-5-2 |
| • TIRE - TIRE COMPANY TELEPHONE NUMBERS
FOR CUSTOMER ASSISTANCE
|
|
| *98-4-22 |
| • TRANSMISSION - 4R100 - SERVICE
PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS -
VEHICLES WITH 5.4L, 6.8L OR 7.3L ENGINE
|
|
| *98-3-3 |
| • PAINT - SURFACE DEFECT REMOVAL WITHOUT
REPAINTING - SERVICE TIP
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED NATURAL GAS FUEL TANK INSPECTION
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| 04-2-2 |
| • BODY - BACK GLASS - SLIDING BACK GLASS WINDNOISE/WATER LEAK - SEAL REPLACEMENT
|
|
| 04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING |
| • TRANSMISSION - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-21-39 |
| • ENGINE - 7.3L DIESEL - ENGINE KNOCK OR "CACKLE" - 1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240 - ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240 |
| • NOISE - "CACKLE" OR ENGINE KNOCK - 7.3L DIESEL - 1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240 - ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240
|
|
| 03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER |
| • ENGINE - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-15-13 |
| • STEERING - TIE ROD END INSPECTION PROCEDURE
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-10-4 |
| • DRIVEABILITY - BI-FUEL LPG LOW FLOW INJECTOR SERVICE ASSEMBLY WITH COOLANT LOCK-OFF
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| 03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| 03-6-2 |
| • ENGINE - CYLINDER HEAD DECK LEAK - 4.6 AND 5.4L ENGINES - NEW "SERVICE-ONLY" GASKET AND CYLINDER HEAD KITS AVAILABILITY
|
|
| 03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED SERVICE PARTS
|
|
| 03-2-4 |
| • BODY - DRIVER SIDE WINDOW BINDS WHEN OPERATED |
| • ELECTRICAL - DRIVER SIDE WINDOW BINDS WHEN OPERATED
|
|
| 02-23-4 |
| • DIAGNOSTIC TROUBLE CODE (DTC) - P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY |
| • LAMP - 4X4 LAMP ILLUMINATED AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY |
| • SPEEDOMETER - INACCURATE AND/OR INOPERATIVE AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT - GASOLINE ENGINE VEHICLES ONLY
|
|
| 02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION |
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-11 |
| • RIDE - HARSH RIDE - CAB/BODY OSCILLATION/BOUNCE - HIGHWAY SPEEDS - 4X2 MODELS ONLY
|
|
| 02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE TIPS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-19-3 |
| • DRIVEABILITY - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE |
| • 4.6L - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER |
| • RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP |
| • NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-10-8 |
| • DRIVEABILITY - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE |
| • ENGINE - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE |
| • NOISE - IDLE-AIR BYPASS FLOW INDUCED WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE |
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-25-5 |
| • BRAKES - REDUCED POWER ASSIST DURING OPERATION IN FREEZING AMBIENT TEMPERATURES - LIGHTNING MODELS ONLY
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL |
| • ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH |
| • ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
|
| 01-21-12 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT 12/2/1997 THROUGH 7/15/1999 EQUIPPED WITH 5.4L ENGINE |
| • ENGINE - 5.4L - PCV SYSTEM ICING - VEHICLES BUILT 12/2/1997 THROUGH 7/15/1999 ONLY
|
|
| 01-21-10 |
| • ENGINE - 4.6L - OIL LEAK FROM HEAD GASKET AREA - ROMEO BUILT ENGINES ONLY
|
|
| 01-21-8 |
| • DRIVEABILITY - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID |
| • STARTING - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID
|
|
| 01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART - SERVICE TIPS
|
|
| 01-20-6 |
| • DRIVEABILITY - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART |
| • ELECTRICAL - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART
|
|
| 01-20-1 |
| • IDLE - HIGH IDLE AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000 |
| • ENGINE - 4.2L - PCV SYSTEM ICING - AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000
|
|
| 01-19-2 |
| • BRAKES - REAR DRUM - GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
|
|
| 01-18-2 |
| • BODY - COSMETIC CRACK IN OUTER DOOR PANEL - LOWER REAR CORNER OF WINDOW OPENING - INSPECTION AND REPAIR PROCEDURE
|
|
| 01-15-5 |
| • DRIVEABILITY - BI-FUEL VEHICLES ONLY - NO START - GASOLINE OR ALT FUEL MODE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY
|
|
| 01-14-1 |
| • ELECTRICAL - ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE - INADVERTENT 4X4 HI OR LOW SHIFT EVENTS |
| • TRANSMISSION - TRANSFER CASE - INADVERTENT 4X4 HI OR LOW SHIFT EVENTS - VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY (ESOF) ONLY
|
|
| 01-13-7 |
| • NOISE - "CLUNK" NOISE HEARD ON 2-1 DOWNSHIFT VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION |
| • TRANSMISSION - 4R70W - "CLUNK" NOISE HEARD FROM TRANSMISSION ON 2-1 DOWNSHIFT
|
|
| 01-13-6 |
| • DRIVEABILITY - CNG BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 2.0L OR 5.4L CNG BI-FUEL ENGINE ONLY
|
|
| 01-12-2 |
| • ENGINE - OIL LEAK FROM RIGHT SIDE HEAD GASKET AREA - VEHICLES EQUIPPED WITH 4.6L/5.4L WINDSOR ENGINE ONLY - SERVICE TIPS
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY
|
|
| 01-9-3 |
| • VIBRATION - FROM DRIVELINE - 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE |
| • TRANSMISSION - 4R70W - FLUID LEAK FROM EXTENSION HOUSING SEAL - 4X2 VEHICLES WITH 139 INCH WHEELBASE
|
|
| 01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL VEHICLES ONLY
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-8-2 |
| • DRIVEABILITY - NO START - BI-FUEL LIGHT ON THEN OFF - REVISED DIAGNOSTIC PROCEDURE - BI-FUEL VEHICLES ONLY
|
|
| 01-6-2 |
| • PASSIVE ANTI THEFT SYSTEM (PATS) - DIAGNOSTIC SERVICE TIPS
|
|
| 01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4 VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| 01-1-11 |
| • WATER LEAK - SLIDING REAR WINDOW - VEHICLES BUILT THROUGH 4/1999
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000 |
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
|
|
| 00-25-8 |
| • STEERING - "CLUNK" NOISE FROM FRONT END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY |
| • SUSPENSION - "CLUNK" NOISE FROM FRONT END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY |
| • NOISE - "CLUNK" FROM FRONT END DURING PARKING LOT MANEUVERS - LIGHTNING MODEL VEHICLES ONLY
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ELECTRICAL - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ENGINE - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| 00-23-8 |
| • DRIVEABILITY - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F) |
| • ELECTRICAL - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F)
|
|
| 00-23-2 |
| • BUCK/JERK - WHILE DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY |
| • DRIVEABILITY - BUCK/JERK - WHILE DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY |
| • HESITATION - WHILE DRIVING IN ANY FUEL MODE - VEHICLES EQUIPPED WITH 5.4L BI-FUEL ENGINE ONLY
|
|
| 00-19-2 |
| • LAMP - COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES |
| • POWER WINDOWS - INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES |
| • RADIO - INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES |
| • REAR WIPER - INOPERATIVE IN MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES
|
|
| 00-18-9 |
| • MIRRORS - SIDE VIEW SIGNAL MIRRORS - DELAMINATION OF SIGNAL MIRROR CHROME PLATING - MIRROR GLASS BLACK SPOTS
|
|
| 00-18-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171 AND/OR P0174 STORED IN MEMORY AT IDLE AND/OR NEUTRAL - LIGHTNING MODELS WITH 5.4L SUPERCHARGED ENGINE ONLY BUILT 3/1/1999 THROUGH 8/1/1999 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171 AND/OR P0174 STORED IN MEMORY AT IDLE AND/OR NEUTRAL - LIGHTNING MODELS WITH 5.4L SUPERCHARGED ENGINE ONLY BUILT 3/1/1999 THROUGH 8/1/1999
|
|
| 00-10-4 |
| • IDLE - ROUGH IDLE SPEED - BI-FUEL VEHICLES ONLY |
| • STALL - DURING IDLE SPEEDS - BI-FUEL VEHICLES ONLY
|
|
| 00-9-6 |
| • WINDSHIELD WIPERS - FRONT WIPERS OPERATE WHILE SWITCH IS IN "OFF" POSITION
|
|
| 00-9-5 |
| • INNER FENDER WELL - DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK
|
|
| 00-8-4 |
| • NOISE - "CHATTERING" FROM REAR AXLE HEARD ON TURNS OR WHEN CORNERING - VEHICLES WITH LIMITED SLIP AXLE |
| • AXLE - LIMITED SLIP - REAR AXLE "CHATTERING" NOISE ON TURNS OR WHEN CORNERING
|
|
| 00-6-11 |
| • CALIBRATION - RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT - SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS STAMPED ON ROTOR - F-150 4X2 ONLY |
| • BRAKES - INCORRECT WORKSHOP MANUAL ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-25-5 |
| • BRAKES - REAR BRAKE DRAG AND/OR PREMATURE WEAR OF THE REAR BRAKE LININGS
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO DRIVEABILITY CONCERNS
|
|
| 99-21-3 |
| • AUTO-LOCK - AUTO-LOCK FUNCTIONS NOT OPERATING PROPERLY - VEHICLES BUILT FROM 6/3/1999 THROUGH 6/8/1999
|
|
| 99-19-7 |
| • LAMP - INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN MEMORY - VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999 WITH 4R70W TRANSMISSION |
| • LAMP - INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN MEMORY - VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999 WITH 4R70W TRANSMISSION |
| • TRANSMISSION - 4R70W - INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN MEMORY - VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999
|
|
| 99-18-8 |
| • INDUCTION BACKFIRE - ON ACCELERATION - ALL AMBIENT TEMPERATURES - VEHICLES WITH 4.2L ENGINE - CANADIAN VEHICLES ONLY
|
|
| 99-18-5 |
| • TRANSMISSION CONTROL INDICATOR LAMP (TCIL) - TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0782 STORED IN MEMORY - VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION |
| • TRANSMISSION - 4R70W - DELAYED OR NO 2-3 UPSHIFT - VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998
|
|
| 99-16-4 |
| • IGNITION KEY - HARD TO REMOVE FROM IGNITION CYLINDER |
| • IGNITION KEY - HARD TO TURN
|
|
| 99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| 99-14-10 |
| • INDUCTION BACKFIRE - VEHICLES IN MEXICO ONLY WITH 4.2L ENGINE |
| • ENGINE - 4.2L - INDUCTION BACKFIRE - VEHICLES IN MEXICO ONLY
|
|
| 99-14-7 |
| • CALIBRATION INFORMATION - VEHICLES BUILT THROUGH 1/29/1999 - APPLICABLE ENGINES ARE 2.0L, 2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L, 6.8L, AND 7.3L - SERVICE TIP
|
|
| 99-14-3 |
| • NOISE - "MOANING" FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT THROUGH 4/15/1999 |
| • AXLE - "MOANING" NOISE FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT THROUGH 4/15/1999
|
|
| 99-13-13 |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - ABS LAMP ILLUMINATED - 4X2 ONLY |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - INCREASED BRAKE PEDAL EFFORT AT LOW SPEEDS - 4X2 ONLY |
| • LAMP - ANTI-LOCK BRAKE LAMP ILLUMINATION - INCREASED BRAKE PEDAL EFFORT AND/OR FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
|
| 99-12-8 |
| • AIR CONDITIONING - "WHISTLING" NOISE HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH) |
| • NOISE - "WHISTLING" HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
|
|
| 99-12-4 |
| • NOISE - "CLUNKING" HEARD DURING 4-3 COASTDOWN WHILE DECELERATING FROM 48-32 KM/H (30-20 MPH) - VEHICLES WITH 5.4L ENGINE AND 4R70W TRANSMISSION |
| • TRANSMISSION - 4R70W - 4-3 COASTDOWN "CLUNK" WHILE DECELERATING FROM 48-32 KM/H (30-20 MPH) - VEHICLES WITH 5.4L ENGINE
|
|
| 99-11-1 |
| • NOISE - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS |
| • VIBRATION - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
|
|
| 99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL REPLACEMENT - SERVICE TIP
|
|
| 99-8-12 |
| • INTERIOR - STORAGE BIN INSIDE CONSOLE DETACHES FROM BOX - SUPER CAB VEHICLES BUILT THROUGH 4/1/1999
|
|
| 99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) - SERVICE TIPS
|
|
| 99-5-4 |
| • FRAME - FRAME SERVICE KITS - NEW SERVICE PARTS RELEASED FOR REPAIRING FRAME DAMAGE
|
|
| 99-5-3 |
| • TRANSMISSION - CHECKING TRANSMISSION FLUID LEVEL COLD - SERVICE TIP
|
|
| 99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| 99-3-2 |
| • TRANSMISSION - M5OD - VEHICLE WILL NOT GO INTO REVERSE - VEHICLES BUILT THROUGH 11/1/1998
|
|
| 99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING - SERVICE TIP |
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| 99-2-2 |
| • NOISE - "BUZZING" - UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION
|
|
| 98-5A-5 |
| • BRAKES - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT |
| • BRAKE ROTOR MACHINING - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
|
|
| 98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| 98-25-9 |
| • INTERIOR TRIM - REPAIRS TO VINYL COVERED SURFACES - SERVICE TIP
|
|
| 98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE RELEASED FOR SERVICE
|
|
| 98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP
|
|
| 98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR MUFFLER HEAT SHIELDS |
| • NOISE - "BUZZING" OR "RATTLING" - LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| 98-7-7 |
| • MIRROR - TRAILER TOW MIRROR GLASS REPLACEMENT PROCEDURE
|
|
| 98-7-4 |
| • LEAKS - OIL - AVAILABILITY OF NEW SILICONE GASKET AND SEALANT
|
|
| 98-5-2 |
| • TIRE - TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE
|
|
| 98-4-22 |
| • TRANSMISSION - 4R100 - SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS - VEHICLES WITH 5.4L, 6.8L OR 7.3L ENGINE
|
|
| 98-3-3 |
| • PAINT - SURFACE DEFECT REMOVAL WITHOUT REPAINTING - SERVICE TIP
|
|
