Technical Service Bulletins
Year: 1998 MODEL: F-250 LIGHT DUTY |
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY
EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A
STOP
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON
PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH
RUNNING
|
|
| 05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED
NATURAL GAS FUEL TANK INSPECTION
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS
IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE -
NON-COMMANDED EGR FLOW
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM
THE CATALYTIC CONVERTERS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR
TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP
NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW
BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| 04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING
NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE
ACCELERATION AND/OR BRAKING
|
| • TRANSMISSION - DRIVELINE
CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING
LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS
AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-21-37 |
| • ROUGH IDLE - NEW TOOL FOR TESTING
ROUGH IDLE - INJECTOR PERFORMANCE ANALYZER - SERVICE
TIP
|
|
| 03-21-31 |
| • ROUGH IDLE - INJECTOR BORE SCUFFING
DURING ENGINE BREAK-IN PERIOD - SERVICE TIP
|
|
| 03-21-29 |
| • ENGINE - 7.3L DIT - 1998-99 ENGINE
CONTENT REVISIONS - SERVICE TIP
|
|
| 03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED
NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE -
ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF
POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC
CONVERTER
|
| • ENGINE - DEDICATED COMPRESSED NATURAL
GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH
IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER
- LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456,
P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH
DTC P0457
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350
AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED
NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD -
VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG
ENGINE ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY
(RKE) - SERVICE TIPS
|
|
| 03-15-13 |
| • STEERING - TIE ROD END INSPECTION
PROCEDURE
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER
FLUSHER - SERVICE TIPS
|
|
| 03-10-4 |
| • DRIVEABILITY - BI-FUEL LPG LOW FLOW
INJECTOR SERVICE ASSEMBLY WITH COOLANT LOCK-OFF
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW
FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
| • DRIVEABILITY - CRANK NO START -
BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE
KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS
(CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES
EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| 03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR
DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| 03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL
VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED
SERVICE PARTS
|
|
| 02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE -
GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION -
CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL
CORRECT APPLICATION
|
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS -
INCORRECT INSTALLATION - CAMSHAFT POSITION
SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT
APPLICATION
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR
CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-11 |
| • RIDE - HARSH RIDE - CAB/BODY
OSCILLATION/BOUNCE - HIGHWAY SPEEDS - 4X2 MODELS ONLY
|
|
| 02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE
TIPS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE
CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME
DISLODGED
|
|
| 02-19-3 |
| • DRIVEABILITY - IDLE - HIGH IDLE SPEEDS
- THROTTLE STICKS AFTER STEADY STATE DRIVING IN
EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT
THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
|
| • 4.6L - IDLE - HIGH IDLE SPEEDS -
THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME
COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH
12/31/01 EQUIPPED WITH 4.6L ENGINE
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING
OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP
"WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT
OR TWO-WAY RADIO SPEAKER
|
| • RADIO - ENTERTAINMENT OR TWO-WAY
COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS
CAUSED BY FUEL PUMP
|
| • NOISE - "WHINING"/"BUZZING" - COMES
THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER
AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE
|
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED
APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS -
GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL -
FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE
FROM PROPYLENE GLYCOL
|
| • ENGINE COOLANT - PROPYLENE
GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON
PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE
CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL
MODELS ONLY - STICKING OR BINDING IGNITION LOCK
CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
| • ELECTRICAL - STICKING OR BINDING
IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING
IGNITION SWITCH
|
|
| 01-21-12 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE
STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD
AMBIENT TEMPERATURES - VEHICLES BUILT 12/2/1997
THROUGH 7/15/1999 EQUIPPED WITH 5.4L ENGINE
|
| • ENGINE - 5.4L - PCV SYSTEM ICING -
VEHICLES BUILT 12/2/1997 THROUGH 7/15/1999 ONLY
|
|
| 01-21-10 |
| • ENGINE - 4.6L - OIL LEAK FROM HEAD
GASKET AREA - ROMEO BUILT ENGINES ONLY
|
|
| 01-21-8 |
| • DRIVEABILITY - NO CRANK, NO START -
CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE
STARTER SOLENOID
|
| • STARTING - NO CRANK, NO START -
CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE
STARTER SOLENOID
|
|
| 01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD
LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP
SWITCH
|
|
| 01-21-5 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE
STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD
AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 11/01/01
EQUIPPED WITH 5.4L ENGINE
|
| • ENGINE - 5.4L - PCV SYSTEM ICING -
VEHICLES BUILT THROUGH 11/01/01
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF
SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART
- SERVICE TIPS
|
|
| 01-20-1 |
| • IDLE - HIGH IDLE AFTER STEADY STATE
DRIVING IN EXTREME COLD AMBIENT TEMPERATURES -
VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH
1/24/2000
|
| • ENGINE - 4.2L - PCV SYSTEM ICING -
AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT
TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE
BUILT THROUGH 1/24/2000
|
|
| 01-19-2 |
| • BRAKES - REAR DRUM - GRABBING DURING
FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
|
|
| 01-18-2 |
| • BODY - COSMETIC CRACK IN OUTER DOOR
PANEL - LOWER REAR CORNER OF WINDOW OPENING -
INSPECTION AND REPAIR PROCEDURE
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN
BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED
WITH BI-FUEL ENGINE ONLY
|
|
| 01-13-6 |
| • DRIVEABILITY - CNG BI-FUEL - PARAMETER
IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION
- VEHICLES EQUIPPED WITH 2.0L OR 5.4L CNG BI-FUEL
ENGINE ONLY
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR
KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT
IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE
PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER
IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION
- VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE
ONLY
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN
SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE
TIPS - OBD II VEHICLES ONLY
|
|
| 01-9-3 |
| • VIBRATION - FROM DRIVELINE - 4X2
VEHICLES WITH 4R70W AND 139 INCH WHEELBASE
|
| • TRANSMISSION - 4R70W - FLUID LEAK FROM
EXTENSION HOUSING SEAL - 4X2 VEHICLES WITH 139 INCH
WHEELBASE
|
|
| 01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II
DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL
VEHICLES ONLY
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT
STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN
BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-8-2 |
| • DRIVEABILITY - NO START - BI-FUEL
LIGHT ON THEN OFF - REVISED DIAGNOSTIC PROCEDURE -
BI-FUEL VEHICLES ONLY
|
|
| 01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT
INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4
VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| 01-1-11 |
| • WATER LEAK - SLIDING REAR WINDOW -
VEHICLES BUILT THROUGH 4/1999
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER
START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN
-12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996
THROUGH 7/31/2000
|
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS
AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS
THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT
3/1/1996 THROUGH 7/31/2000
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER
KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT
PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
| • ELECTRICAL - COMPUVALVE REPLACEMENT
PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
| • ENGINE - COMPUVALVE REPLACEMENT
PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| 00-23-8 |
| • DRIVEABILITY - NO CRANK/NO START -
MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES
BELOW -12 DEGREES C (10 DEGREES F)
|
| • ELECTRICAL - NO CRANK/NO START -
MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES
BELOW -12 DEGREES C (10 DEGREES F)
|
|
| 00-18-9 |
| • MIRRORS - SIDE VIEW SIGNAL MIRRORS -
DELAMINATION OF SIGNAL MIRROR CHROME PLATING - MIRROR
GLASS BLACK SPOTS
|
|
| 00-12-3 |
| • SPARK KNOCK - LIGHT-TO-MODERATE
ACCELERATION - 5.4L VEHICLES ONLY
|
|
| 00-10-4 |
| • IDLE - ROUGH IDLE SPEED - BI-FUEL
VEHICLES ONLY
|
| • STALL - DURING IDLE SPEEDS - BI-FUEL
VEHICLES ONLY
|
|
| 00-9-5 |
| • INNER FENDER WELL - DENTED OR DINGED
FROM STONES BEING THROWN INTO WHEELWELL
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT
RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC
TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR
END TANK
|
|
| 00-6-11 |
| • CALIBRATION - RECALIBRATION OF
POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT -
SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| 00-1-7 |
| • DETONATION - MIL ILLUMINATED -
DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR
P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE
BUILT BEFORE 11/1/1997
|
| • HESITATION/STUMBLE - MIL ILLUMINATED -
DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR
P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE
BUILT BEFORE 11/1/1997
|
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL
ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133,
P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH
5.4L ENGINE BUILT BEFORE 11/1/1997
|
| • ROUGH IDLE - MIL ILLUMINATED -
DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR
P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE
BUILT BEFORE 11/1/1997
|
| • STALL/NEAR STALL - AT IDLE AND/OR LOW
SPEEDS - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES
(DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY -
VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS)
P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES
WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS
STAMPED ON ROTOR - F-150 4X2 ONLY
|
| • BRAKES - INCORRECT WORKSHOP MANUAL
ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-25-5 |
| • BRAKES - REAR BRAKE DRAG AND/OR
PREMATURE WEAR OF THE REAR BRAKE LININGS
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK
COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) -
DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO
DRIVEABILITY CONCERNS
|
|
| 99-20-7 |
| • COOLING SYSTEM - 3.8L - UNDETERMINED
LOSS OF COOLANT
|
| • COOLING SYSTEM - 4.2L - UNDETERMINED
LOSS OF COOLANT
|
| • ENGINE - 3.8L - ENGINE OIL
CONTAMINATED WITH COOLANT
|
| • ENGINE - 4.2L - ENGINE OIL
CONTAMINATED WITH COOLANT
|
|
| 99-18-8 |
| • INDUCTION BACKFIRE - ON ACCELERATION -
ALL AMBIENT TEMPERATURES - VEHICLES WITH 4.2L ENGINE -
CANADIAN VEHICLES ONLY
|
|
| 99-18-5 |
| • TRANSMISSION CONTROL INDICATOR LAMP
(TCIL) - TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE
(DTC) P0782 STORED IN MEMORY - VEHICLES BUILT BETWEEN
3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION
|
| • TRANSMISSION - 4R70W - DELAYED OR NO
2-3 UPSHIFT - VEHICLES BUILT BETWEEN 3/15/1997 AND
12/31/1998
|
|
| 99-16-4 |
| • IGNITION KEY - HARD TO REMOVE FROM
IGNITION CYLINDER
|
| • IGNITION KEY - HARD TO TURN
|
|
| 99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH
AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| 99-14-10 |
| • INDUCTION BACKFIRE - VEHICLES IN
MEXICO ONLY WITH 4.2L ENGINE
|
| • ENGINE - 4.2L - INDUCTION BACKFIRE -
VEHICLES IN MEXICO ONLY
|
|
| 99-14-4 |
| • NOISE - "MOANING" AT 1100 RPM WITH A/C
COMPRESSOR ENGAGED - VEHICLES WITH 4.2L ENGINE
|
|
| 99-14-3 |
| • NOISE - "MOANING" FROM FRONT
DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT
THROUGH 4/15/1999
|
| • AXLE - "MOANING" NOISE FROM FRONT
DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT
THROUGH 4/15/1999
|
|
| 99-13-13 |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - ABS
LAMP ILLUMINATED - 4X2 ONLY
|
| • ANTI-LOCK BRAKE SYSTEM (ABS) - FALSE
ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
| • ANTI-LOCK BRAKE SYSTEM (ABS) -
INCREASED BRAKE PEDAL EFFORT AT LOW SPEEDS - 4X2 ONLY
|
| • LAMP - ANTI-LOCK BRAKE LAMP
ILLUMINATION - INCREASED BRAKE PEDAL EFFORT AND/OR
FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
|
| 99-12-8 |
| • AIR CONDITIONING - "WHISTLING" NOISE
HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64
KM/H (40 MPH)
|
| • NOISE - "WHISTLING" HEARD WHILE
DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
|
|
| 99-11-1 |
| • NOISE - TSB SPECIAL FOR
NOISE/VIBRATION/HARSHNESS
|
| • VIBRATION - TSB SPECIAL FOR
NOISE/VIBRATION/HARSHNESS
|
|
| 99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL
REPLACEMENT - SERVICE TIP
|
|
| 99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) -
SERVICE TIPS
|
|
| 99-5-4 |
| • FRAME - FRAME SERVICE KITS - NEW
SERVICE PARTS RELEASED FOR REPAIRING FRAME DAMAGE
|
|
| 99-5-3 |
| • TRANSMISSION - CHECKING TRANSMISSION
FLUID LEVEL COLD - SERVICE TIP
|
|
| 99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL
MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| 99-3-2 |
| • TRANSMISSION - M5OD - VEHICLE WILL NOT
GO INTO REVERSE - VEHICLES BUILT THROUGH 11/1/1998
|
|
| 99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING -
SERVICE TIP
|
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| 99-2-2 |
| • NOISE - "BUZZING" - UNDERHOOD WHEN AIR
SUSPENSION IS IN OPERATION
|
|
| 98-5A-5 |
| • BRAKES - AVAILABILITY OF HUB-MOUNT
BRAKE ROTOR MACHINING EQUIPMENT
|
| • BRAKE ROTOR MACHINING - AVAILABILITY
OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
|
|
| 98-26-6 |
| • ROOF - DEPRESSION IN ROOF - REARWARD
OF FRONT DOORS - SUPERCAB ONLY
|
|
| 98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS
TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| 98-25-9 |
| • INTERIOR TRIM - REPAIRS TO VINYL
COVERED SURFACES - SERVICE TIP
|
|
| 98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE
RELEASED FOR SERVICE
|
|
| 98-23-25 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL
LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC)
P0455 STORED IN MEMORY - VEHICLES BUILT THROUGH
11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L
ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) - MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE
CODE (DTC) P0455 STORED IN MEMORY - VEHICLES BUILT
THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND
5.4L ENGINE
|
|
| 98-23-21 |
| • SUSPENSION - FRONT OR REAR -
SIDE-TO-SIDE LEVELING PROCEDURES AND ATTITUDE SERVICE
KITS FOR F-53 RV BASIC STRIPPED CHASSIS
|
|
| 98-23-14 |
| • FEAD - BELT TENSIONER WEAR - VEHICLES
WITH 7.3L DI TURBO ENGINE
|
|
| 98-23-13 |
| • HESITATION/STUMBLE - POOR SEAL ON
INJECTOR O-RINGS - 7.3L DI TURBO
|
| • IDLE - ROUGH - POOR SEAL ON INJECTOR
O-RINGS - 7.3L DI TURBO
|
| • LACK OF POWER/POOR PERFORMANCE - POOR
SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO
|
| • STALLS - POOR SEAL ON INJECTOR O-RINGS
- 7.3L DI TURBO
|
| • OIL - EXCESSIVE OIL CONSUMPTION - POOR
SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO
|
|
| 98-23-12 |
| • TRANSMISSION - 4R44E - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
| • TRANSMISSION - 4R55E - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
| • TRANSMISSION - 4R70W - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
| • TRANSMISSION - 5R55E - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
| • TRANSMISSION - AX4N - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
| • TRANSMISSION - AX4S - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
| • TRANSMISSION - E4OD - DIAGNOSTIC
TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705
STORED IN MEMORY
|
|
| 98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR
CONTAMINATION - SERVICE TIP
|
|
| 98-21-21 |
| • IDLE - FAST IDLE SPEED AND/OR
DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY -
VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
|
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL
ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC
TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES
BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED AND/OR FAST IDLE SPEED WITH
DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY -
VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
|
|
| 98-21-20 |
| • STEERING - STEERING WHEEL ALIGNMENT -
CLEAR VISION - VEHICLES WITH MOTORHOME CHASSIS
|
|
| 98-21-17 |
| • BRAKES - PARKING BRAKE CONTROL RUBBER
BUMPER STOP - SERVICE PART NOW AVAILABLE
|
|
| 98-21-10 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE
STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT
TEMPERATURES - VEHICLES BUILT THROUGH 12/1/97 EQUIPPED
WITH 4.6L ENGINE
|
|
| 98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR
MUFFLER HEAT SHIELDS
|
| • NOISE - "BUZZING" OR "RATTLING" -
LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| 98-20-9 |
| • NOISE - "TICKING" OCCURS ON INITIAL
STARTUP WITH SHIFT SELECTOR IN "P" OR "N" POSITION -
VEHICLES WITH E4OD/4R100 TRANSMISSION AND BUILT
THROUGH 6/11/98
|
| • TRANSMISSION - E4OD/4R100 - "TICKING"
NOISE OCCURS ON INITIAL STARTUP WITH SHIFT SELECTOR IN
"P" OR "N" POSITION - VEHICLES BUILT THROUGH 6/11/98
|
|
| 98-20-3 |
| • BODY - ADHESIVES NOT RECOMMENDED FOR
BODY PANEL REPAIRS - SERVICE TIP
|
|
| 98-18-2 |
| • PAINT - EXTERIOR - WORLDWIDE
RECOMMENDED PAINT MATERIALS FOR WARRANTY AND AFTER
WARRANTY REPAIRS
|
|
| 98-16-18 |
| • FLOOR MAT - INSTALLATION OF VINYL
FLOOR MATS - SERVICE TIP
|
|
| 98-16-17 |
| • FLOOR MAT - PRODUCTION FLOOR MAT
INSTALLATION PROCEDURE - SERVICE TIP
|
|
| 98-16-12 |
| • FUEL SYSTEM - FUEL LEAKING FROM SPRING
LOCK COUPLINGS AT FUEL RAIL - AMBIENT TEMPERATURES
BELOW -40 DEGREES CELSIUS (-40 DEGREES FAHRENHEIT)
|
|
| 98-16-10 |
| • SEAT - SEAT BACK RECLINER INOPERATIVE
- MEMORY LATCH DOES NOT ENGAGE
|
|
| 98-16-9 |
| • STEERING - ALIGNMENT - TOE SET
PROCEDURE - SERVICE TIP
|
|
| 98-16-8 |
| • TRANSMISSION - E4OD/4R100 - 1989-99 -
MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE
GASKETS USAGE CHART
|
|
| 98-15-17 |
| • SEAT - CHILD TETHER KIT FOR INSTALLING
CHILD SEAT IN REAR SEAT - SUPER CAB VEHICLES
|
| • CHILD TETHER KIT - SERVICE TIP FOR
INSTALLING CHILD SAFETY SEAT IN REAR SEAT - SUPER CAB
VEHICLES
|
|
| 98-15-12 |
| • EMISSIONS - AVAILABILITY OF
EVAPORATIVE EMISSION CANISTER COMPONENTS
|
|
| 98-15-1 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL
ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS)
P1391, P1393, P1395 AND/OR P1396 STORED IN MEMORY -
F-250 AND F-350 CALIFORNIA ONLY AND ECONOLINE -
VEHICLES WITH 7.3L ENGINE
|
|
| 98-14-5 |
| • STEERING - "CLUNKING" FELT WHILE
ROCKING STEERING WHEEL SIDE-TO-SIDE
|
|
| 98-12-12 |
| • HEATER - "MOAN" AT 1400-1800 RPM OR
"HOOTING" NOISE HEARD AT 1200-2000 RPM ACCELERATION OR
DECELERATION - VEHICLES WITH 4.6L ENGINE
|
| • NOISE - "MOAN" AT 1400-1800 RPM OR
"HOOTING" AT 1200-2000 RPM ACCELERATION OR
DECELERATION - VEHICLES WITH 4.6L ENGINE
|
|
| 98-12-5 |
| • AIR CONDITIONING - FILTERING
REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT - SERVICE
TIPS
|
|
| 98-10-15 |
| • NOISE - "BUZZING" NOISE HEARD UNDER
CERTAIN SPEEDS AND LOADS - VEHICLES BUILT THROUGH
5/15/98 EQUIPPED WITH E4OD OR 4R100 TRANSMISSION AND
"MANUAL SHIFT-ON-THE-FLY," AND 5.4L ENGINE
|
| • TRANSMISSION - E4OD OR 4R100 - NOISE -
"BUZZING" NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS -
VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD AND
4R100 TRANSMISSION AND "MANUAL SHIFT-ON-THE-FLY," AND
5.4L ENGINE
|
|
| 98-9-20 |
| • TRANSMISSION - E4OD - 4-1 DOWNSHIFT
DURING A FORCED 4-2 DOWNSHIFT BETWEEN 88-105 KM/H
(55-65 MPH) - VEHICLES BUILT THROUGH 12/22/97
|
|
| 98-9-15 |
| • BRAKES - 4WABS - ABS LAMP ILLUMINATED
WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN
MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL -
VEHICLES BUILT THROUGH 2/12/98
|
| • LAMP - ABS LAMP ILLUMINATED WITH
DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY
AND/OR CODES NOT LISTED IN WORKSHOP MANUAL - VEHICLES
BUILT THROUGH 2/12/98
|
|
| 98-9-13 |
| • WATER LEAKS - VARIOUS AREAS OF VEHICLE
|
| • ELECTRICAL - ACCESSORIES FUNCTIONING
IMPROPERLY DUE TO WATER LEAKS
|
| • LAMPS - WARNING LAMPS ILLUMINATED DUE
TO WATER LEAKS
|
|
| 98-9-9 |
| • FUEL INJECTORS - NON-WARRANTY
REIMBURSEMENT TESTING INFORMATION
|
|
| 98-6-13 |
| • AIR CONDITIONING - COLD AIR FELT ON
PASSENGER SIDE FLOOR WHILE IN HEAT MODE - F-SERIES AND
EXPEDITION WITHOUT CONSOLE BLOWER OPTION - VEHICLES
BUILT THROUGH 8/31/97
|
|
| 98-5-8 |
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC)
P0503 STORED IN MEMORY - 4X4 VEHICLES ONLY
|
| • TRANSMISSION - SHIFT CONCERNS AND/OR
ERRATIC SPEEDOMETER OPERATION - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED - 4X4 VEHICLES ONLY
|
|
| 98-5-2 |
| • TIRE - TIRE COMPANY TELEPHONE NUMBERS
FOR CUSTOMER ASSISTANCE
|
|
| 98-4-22 |
| • TRANSMISSION - 4R100 - SERVICE
PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS -
VEHICLES WITH 5.4L, 6.8L OR 7.3L ENGINE
|
|
| 98-4-19 |
| • LAMP - FLASHING TRANSMISSION CONTROL
INDICATOR LAMP (TCIL) WITH DIAGNOSTIC TROUBLE CODES
(DTCS) 62, 628 AND/OR 1728 STORED IN MEMORY
|
| • TRANSMISSION - E4OD - FLASHING
TRANSMISSION CONTROL INDICATOR LAMP (TCIL) WITH
DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628 AND/OR 1728
STORED IN MEMORY
|
|
| 98-4-12 |
| • TRANSMISSION - 4R70W - SERVICE
PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS
|
|
| 98-4-4 |
| • PAINT - ANTI-CHIP STONE ABRASION
UNDERCOAT - SERVICE TIP
|
|
| 98-1-13 |
| • BUMPER - RUST STAIN - EDGES OF CENTER
VENT AND FOG LAMP OPENINGS
|
|
| 98-1-8 |
| • FUEL PUMP - FUEL PUMP REPLACEMENT
PROCEDURE - SERVICE TIP
|
|
| 97-26-19 |
| • HESITATION/SURGE - MIL ILLUMINATED -
DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141,
P0153, P0155, P0161, P1130, P1131, P1132, P1137,
P1138, P1150, P1151, P1152, P1157, P1158 STORED IN
MEMORY - VEHICLES BUILT THROUGH 11/97
|
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL
ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133,
P0135, P0141, P0153, P0155, P0161, P1130, P1131,
P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158
STORED - VEHICLES BUILT THROUGH 11/97
|
| • ROUGH IDLE - MIL ILLUMINATED -
DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141,
P0153, P0155, P0161, P1130, P1131, P1132, P1137,
P1138, P1150, P1151, P1152, P1157, P1158 STORED IN
MEMORY - VEHICLES BUILT THROUGH 11/97
|
| • STALL - LOW SPEEDS AND OR IDLE - MIL
ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133,
P0135, P0141, P0153, P0155, P0161, P1130, P1131,
P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158
IN MEMORY - VEHICLES BUILT THROUGH 11/97
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS)
P0133, P0135, P0141, P0153, P0155, P0161, P1130,
P1131, P1132, P1137, P1138, P1150, P1151, P1152,
P1157, P1158 STORED - VEHICLES BUILT THROUGH 11/97
|
|
| 97-26-18 |
| • ROUGH IDLE - 7.3L DIT - NEW CYLINDER
CONTRIBUTION TEST - SERVICE DIAGNOSTIC TIP
|
|
| 97-25-8 |
| • RUNS ROUGH - MALFUNCTION INDICATOR
LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES
(DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY -
VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR
5.4L ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC)
P0300 THROUGH P0308 MAY BE STORED IN MEMORY - VEHICLES
BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L
ENGINE
|
| • ENGINE - ROLLER FINGER FOLLOWERS
DISLODGE - DURING AMBIENT TEMPERTURES LESS THAN -18
DEGREES C (0 DEGREES F) - VEHICLES BUILT THROUGH
11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE
|
|
| 97-24-13 |
| • REMOTE KEYLESS ENTRY (RKE) -
DIAGNOSTIC SERVICE TIPS
|
|
| 97-23-13 |
| • TRANSMISSION - E4OD - NEW DESIGN
TRANSMISSION CASE AND EXTENSION HOUSING -
TRANSMISSIONS BUILT AFTER 7/24/97
|
|
| 97-22-7 |
| • WHEEL - HUB O-RING - SERVICE TIP
|
|
| 97-21-10 |
| • TRANSMISSION - 4R70W - NEW DESIGN
ENHANCEMENTS FOR 1998 VEHICLES
|
| • TRANSMISSION - 4R70W - NEW ONE-WAY
CLUTCH (OWC) TO SERVICE AT THE INTERMEDIATE POSITION
|
|
| 97-19-11 |
| • COOLING SYSTEM - "ON-VEHICLE" HEATER
CORE PRESSURE TEST REQUIRED FOR WARRANTY CLAIM
|
|
| 97-15A-1 |
| • 7.3L DI TURBO POWERSTROKE DIESEL
ENGINE
|
|
| 97-15-5 |
| • AIR CONDITIONING - OIL REFILL CAPACITY
CHART - SERVICE TIP
|
|
