Technical Service Bulletins
Year: 1998 MODEL: F-150 |
|
| 06-4-2 |
| • BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
|
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-5-6 |
| • ALTERNATIVE FUEL VEHICLE - COMPRESSED NATURAL GAS FUEL TANK INSPECTION
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| 04-1-6 |
| • NOISE - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING |
| • TRANSMISSION - DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER |
| • ENGINE - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-15-13 |
| • STEERING - TIE ROD END INSPECTION PROCEDURE
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-10-4 |
| • DRIVEABILITY - BI-FUEL LPG LOW FLOW INJECTOR SERVICE ASSEMBLY WITH COOLANT LOCK-OFF
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| 03-6-6 |
| • DRIVEABILITY - BI-FUEL - OXYGEN SENSOR DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING
|
|
| 03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED SERVICE PARTS
|
|
| 02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION |
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-11 |
| • RIDE - HARSH RIDE - CAB/BODY OSCILLATION/BOUNCE - HIGHWAY SPEEDS - 4X2 MODELS ONLY
|
|
| 02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE TIPS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-19-3 |
| • DRIVEABILITY - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE |
| • 4.6L - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER |
| • RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP |
| • NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE |
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL |
| • ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-13 |
| • DRIVEABILITY - DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH |
| • ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
|
|
| 01-21-12 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT 12/2/1997 THROUGH 7/15/1999 EQUIPPED WITH 5.4L ENGINE |
| • ENGINE - 5.4L - PCV SYSTEM ICING - VEHICLES BUILT 12/2/1997 THROUGH 7/15/1999 ONLY
|
|
| 01-21-10 |
| • ENGINE - 4.6L - OIL LEAK FROM HEAD GASKET AREA - ROMEO BUILT ENGINES ONLY
|
|
| 01-21-8 |
| • DRIVEABILITY - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID |
| • STARTING - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID
|
|
| 01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
|
|
| 01-21-5 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 11/01/01 EQUIPPED WITH 5.4L ENGINE |
| • ENGINE - 5.4L - PCV SYSTEM ICING - VEHICLES BUILT THROUGH 11/01/01
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART - SERVICE TIPS
|
|
| 01-20-1 |
| • IDLE - HIGH IDLE AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000 |
| • ENGINE - 4.2L - PCV SYSTEM ICING - AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000
|
|
| 01-19-2 |
| • BRAKES - REAR DRUM - GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
|
|
| 01-18-2 |
| • BODY - COSMETIC CRACK IN OUTER DOOR PANEL - LOWER REAR CORNER OF WINDOW OPENING - INSPECTION AND REPAIR PROCEDURE
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY
|
|
| 01-13-6 |
| • DRIVEABILITY - CNG BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 2.0L OR 5.4L CNG BI-FUEL ENGINE ONLY
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-10-1 |
| • DRIVEABILITY - BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY
|
|
| 01-9-3 |
| • VIBRATION - FROM DRIVELINE - 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE |
| • TRANSMISSION - 4R70W - FLUID LEAK FROM EXTENSION HOUSING SEAL - 4X2 VEHICLES WITH 139 INCH WHEELBASE
|
|
| 01-8-8 |
| • DRIVEABILITY - BI-FUEL OBD II DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL VEHICLES ONLY
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-8-2 |
| • DRIVEABILITY - NO START - BI-FUEL LIGHT ON THEN OFF - REVISED DIAGNOSTIC PROCEDURE - BI-FUEL VEHICLES ONLY
|
|
| 01-4-2 |
| • ENGINE - 5.4L - OIL SENDING UNIT INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4 VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY
|
|
| 01-1-11 |
| • WATER LEAK - SLIDING REAR WINDOW - VEHICLES BUILT THROUGH 4/1999
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000 |
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ELECTRICAL - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ENGINE - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| 00-23-8 |
| • DRIVEABILITY - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F) |
| • ELECTRICAL - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F)
|
|
| 00-18-9 |
| • MIRRORS - SIDE VIEW SIGNAL MIRRORS - DELAMINATION OF SIGNAL MIRROR CHROME PLATING - MIRROR GLASS BLACK SPOTS
|
|
| 00-12-3 |
| • SPARK KNOCK - LIGHT-TO-MODERATE ACCELERATION - 5.4L VEHICLES ONLY
|
|
| 00-10-4 |
| • IDLE - ROUGH IDLE SPEED - BI-FUEL VEHICLES ONLY |
| • STALL - DURING IDLE SPEEDS - BI-FUEL VEHICLES ONLY
|
|
| 00-9-5 |
| • INNER FENDER WELL - DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK
|
|
| 00-6-11 |
| • CALIBRATION - RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT - SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| 00-1-7 |
| • DETONATION - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • HESITATION/STUMBLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • ROUGH IDLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • STALL/NEAR STALL - AT IDLE AND/OR LOW SPEEDS - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS STAMPED ON ROTOR - F-150 4X2 ONLY |
| • BRAKES - INCORRECT WORKSHOP MANUAL ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-25-5 |
| • BRAKES - REAR BRAKE DRAG AND/OR PREMATURE WEAR OF THE REAR BRAKE LININGS
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO DRIVEABILITY CONCERNS
|
|
| 99-20-7 |
| • COOLING SYSTEM - 3.8L - UNDETERMINED LOSS OF COOLANT |
| • COOLING SYSTEM - 4.2L - UNDETERMINED LOSS OF COOLANT |
| • ENGINE - 3.8L - ENGINE OIL CONTAMINATED WITH COOLANT |
| • ENGINE - 4.2L - ENGINE OIL CONTAMINATED WITH COOLANT
|
|
| 99-18-8 |
| • INDUCTION BACKFIRE - ON ACCELERATION - ALL AMBIENT TEMPERATURES - VEHICLES WITH 4.2L ENGINE - CANADIAN VEHICLES ONLY
|
|
| 99-18-5 |
| • TRANSMISSION CONTROL INDICATOR LAMP (TCIL) - TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0782 STORED IN MEMORY - VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION |
| • TRANSMISSION - 4R70W - DELAYED OR NO 2-3 UPSHIFT - VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998
|
|
| 99-16-4 |
| • IGNITION KEY - HARD TO REMOVE FROM IGNITION CYLINDER |
| • IGNITION KEY - HARD TO TURN
|
|
| 99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| 99-14-10 |
| • INDUCTION BACKFIRE - VEHICLES IN MEXICO ONLY WITH 4.2L ENGINE |
| • ENGINE - 4.2L - INDUCTION BACKFIRE - VEHICLES IN MEXICO ONLY
|
|
| 99-14-4 |
| • NOISE - "MOANING" AT 1100 RPM WITH A/C COMPRESSOR ENGAGED - VEHICLES WITH 4.2L ENGINE
|
|
| 99-14-3 |
| • NOISE - "MOANING" FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT THROUGH 4/15/1999 |
| • AXLE - "MOANING" NOISE FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT THROUGH 4/15/1999
|
|
| 99-13-13 |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - ABS LAMP ILLUMINATED - 4X2 ONLY |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - INCREASED BRAKE PEDAL EFFORT AT LOW SPEEDS - 4X2 ONLY |
| • LAMP - ANTI-LOCK BRAKE LAMP ILLUMINATION - INCREASED BRAKE PEDAL EFFORT AND/OR FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
|
| 99-12-8 |
| • AIR CONDITIONING - "WHISTLING" NOISE HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH) |
| • NOISE - "WHISTLING" HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
|
|
| 99-11-1 |
| • NOISE - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS |
| • VIBRATION - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
|
|
| 99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL REPLACEMENT - SERVICE TIP
|
|
| 99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) - SERVICE TIPS
|
|
| 99-5-4 |
| • FRAME - FRAME SERVICE KITS - NEW SERVICE PARTS RELEASED FOR REPAIRING FRAME DAMAGE
|
|
| 99-5-3 |
| • TRANSMISSION - CHECKING TRANSMISSION FLUID LEVEL COLD - SERVICE TIP
|
|
| 99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| 99-3-2 |
| • TRANSMISSION - M5OD - VEHICLE WILL NOT GO INTO REVERSE - VEHICLES BUILT THROUGH 11/1/1998
|
|
| 99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING - SERVICE TIP |
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| 99-2-2 |
| • NOISE - "BUZZING" - UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION
|
|
| 98-5A-5 |
| • BRAKES - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT |
| • BRAKE ROTOR MACHINING - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
|
|
| 98-26-6 |
| • ROOF - DEPRESSION IN ROOF - REARWARD OF FRONT DOORS - SUPERCAB ONLY
|
|
| 98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| 98-25-9 |
| • INTERIOR TRIM - REPAIRS TO VINYL COVERED SURFACES - SERVICE TIP
|
|
| 98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE RELEASED FOR SERVICE
|
|
| 98-23-25 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0455 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) - MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0455 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L ENGINE
|
|
| 98-23-12 |
| • TRANSMISSION - 4R44E - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - 4R55E - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - 4R70W - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - 5R55E - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - AX4N - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - AX4S - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - E4OD - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
|
|
| 98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP
|
|
| 98-21-21 |
| • IDLE - FAST IDLE SPEED AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
|
|
| 98-21-17 |
| • BRAKES - PARKING BRAKE CONTROL RUBBER BUMPER STOP - SERVICE PART NOW AVAILABLE
|
|
| 98-21-10 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/1/97 EQUIPPED WITH 4.6L ENGINE
|
|
| 98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR MUFFLER HEAT SHIELDS |
| • NOISE - "BUZZING" OR "RATTLING" - LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| 98-20-9 |
| • NOISE - "TICKING" OCCURS ON INITIAL STARTUP WITH SHIFT SELECTOR IN "P" OR "N" POSITION - VEHICLES WITH E4OD/4R100 TRANSMISSION AND BUILT THROUGH 6/11/98 |
| • TRANSMISSION - E4OD/4R100 - "TICKING" NOISE OCCURS ON INITIAL STARTUP WITH SHIFT SELECTOR IN "P" OR "N" POSITION - VEHICLES BUILT THROUGH 6/11/98
|
|
| 98-20-3 |
| • BODY - ADHESIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS - SERVICE TIP
|
|
| 98-18-2 |
| • PAINT - EXTERIOR - WORLDWIDE RECOMMENDED PAINT MATERIALS FOR WARRANTY AND AFTER WARRANTY REPAIRS
|
|
| 98-16-18 |
| • FLOOR MAT - INSTALLATION OF VINYL FLOOR MATS - SERVICE TIP
|
|
| 98-16-17 |
| • FLOOR MAT - PRODUCTION FLOOR MAT INSTALLATION PROCEDURE - SERVICE TIP
|
|
| 98-16-12 |
| • FUEL SYSTEM - FUEL LEAKING FROM SPRING LOCK COUPLINGS AT FUEL RAIL - AMBIENT TEMPERATURES BELOW -40 DEGREES CELSIUS (-40 DEGREES FAHRENHEIT)
|
|
| 98-16-10 |
| • SEAT - SEAT BACK RECLINER INOPERATIVE - MEMORY LATCH DOES NOT ENGAGE
|
|
| 98-16-9 |
| • STEERING - ALIGNMENT - TOE SET PROCEDURE - SERVICE TIP
|
|
| 98-16-8 |
| • TRANSMISSION - E4OD/4R100 - 1989-99 - MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART
|
|
| 98-15-17 |
| • SEAT - CHILD TETHER KIT FOR INSTALLING CHILD SEAT IN REAR SEAT - SUPER CAB VEHICLES |
| • CHILD TETHER KIT - SERVICE TIP FOR INSTALLING CHILD SAFETY SEAT IN REAR SEAT - SUPER CAB VEHICLES
|
|
| 98-14-5 |
| • STEERING - "CLUNKING" FELT WHILE ROCKING STEERING WHEEL SIDE-TO-SIDE
|
|
| 98-12-12 |
| • HEATER - "MOAN" AT 1400-1800 RPM OR "HOOTING" NOISE HEARD AT 1200-2000 RPM ACCELERATION OR DECELERATION - VEHICLES WITH 4.6L ENGINE |
| • NOISE - "MOAN" AT 1400-1800 RPM OR "HOOTING" AT 1200-2000 RPM ACCELERATION OR DECELERATION - VEHICLES WITH 4.6L ENGINE
|
|
| 98-12-5 |
| • AIR CONDITIONING - FILTERING REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT - SERVICE TIPS
|
|
| 98-10-15 |
| • NOISE - "BUZZING" NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS - VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD OR 4R100 TRANSMISSION AND "MANUAL SHIFT-ON-THE-FLY," AND 5.4L ENGINE |
| • TRANSMISSION - E4OD OR 4R100 - NOISE - "BUZZING" NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS - VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD AND 4R100 TRANSMISSION AND "MANUAL SHIFT-ON-THE-FLY," AND 5.4L ENGINE
|
|
| 98-9-20 |
| • TRANSMISSION - E4OD - 4-1 DOWNSHIFT DURING A FORCED 4-2 DOWNSHIFT BETWEEN 88-105 KM/H (55-65 MPH) - VEHICLES BUILT THROUGH 12/22/97
|
|
| 98-9-15 |
| • BRAKES - 4WABS - ABS LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL - VEHICLES BUILT THROUGH 2/12/98 |
| • LAMP - ABS LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL - VEHICLES BUILT THROUGH 2/12/98
|
|
| 98-9-13 |
| • WATER LEAKS - VARIOUS AREAS OF VEHICLE |
| • ELECTRICAL - ACCESSORIES FUNCTIONING IMPROPERLY DUE TO WATER LEAKS |
| • LAMPS - WARNING LAMPS ILLUMINATED DUE TO WATER LEAKS
|
|
| 98-9-9 |
| • FUEL INJECTORS - NON-WARRANTY REIMBURSEMENT TESTING INFORMATION
|
|
| 98-6-13 |
| • AIR CONDITIONING - COLD AIR FELT ON PASSENGER SIDE FLOOR WHILE IN HEAT MODE - F-SERIES AND EXPEDITION WITHOUT CONSOLE BLOWER OPTION - VEHICLES BUILT THROUGH 8/31/97
|
|
| 98-5-8 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) P0503 STORED IN MEMORY - 4X4 VEHICLES ONLY |
| • TRANSMISSION - SHIFT CONCERNS AND/OR ERRATIC SPEEDOMETER OPERATION - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - 4X4 VEHICLES ONLY
|
|
| 98-5-2 |
| • TIRE - TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE
|
|
| 98-4-22 |
| • TRANSMISSION - 4R100 - SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS - VEHICLES WITH 5.4L, 6.8L OR 7.3L ENGINE
|
|
| 98-4-19 |
| • LAMP - FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628 AND/OR 1728 STORED IN MEMORY |
| • TRANSMISSION - E4OD - FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628 AND/OR 1728 STORED IN MEMORY
|
|
| 98-4-12 |
| • TRANSMISSION - 4R70W - SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS
|
|
| 98-4-4 |
| • PAINT - ANTI-CHIP STONE ABRASION UNDERCOAT - SERVICE TIP
|
|
| 98-1-13 |
| • BUMPER - RUST STAIN - EDGES OF CENTER VENT AND FOG LAMP OPENINGS
|
|
| 98-1-8 |
| • FUEL PUMP - FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP
|
|
| 97-26-19 |
| • HESITATION/SURGE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/97 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED - VEHICLES BUILT THROUGH 11/97 |
| • ROUGH IDLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/97 |
| • STALL - LOW SPEEDS AND OR IDLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 IN MEMORY - VEHICLES BUILT THROUGH 11/97 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED - VEHICLES BUILT THROUGH 11/97
|
|
| 97-26-18 |
| • ROUGH IDLE - 7.3L DIT - NEW CYLINDER CONTRIBUTION TEST - SERVICE DIAGNOSTIC TIP
|
|
| 97-25-8 |
| • RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY - VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY - VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE |
| • ENGINE - ROLLER FINGER FOLLOWERS DISLODGE - DURING AMBIENT TEMPERTURES LESS THAN -18 DEGREES C (0 DEGREES F) - VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE
|
|
| 97-24-13 |
| • REMOTE KEYLESS ENTRY (RKE) - DIAGNOSTIC SERVICE TIPS
|
|
| 97-23-13 |
| • TRANSMISSION - E4OD - NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING - TRANSMISSIONS BUILT AFTER 7/24/97
|
|
| 97-22-7 |
| • WHEEL - HUB O-RING - SERVICE TIP
|
|
| 97-21-10 |
| • TRANSMISSION - 4R70W - NEW DESIGN ENHANCEMENTS FOR 1998 VEHICLES |
| • TRANSMISSION - 4R70W - NEW ONE-WAY CLUTCH (OWC) TO SERVICE AT THE INTERMEDIATE POSITION
|
|
| 97-19-11 |
| • COOLING SYSTEM - "ON-VEHICLE" HEATER CORE PRESSURE TEST REQUIRED FOR WARRANTY CLAIM
|
|
| 97-15-5 |
| • AIR CONDITIONING - OIL REFILL CAPACITY CHART - SERVICE TIP
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-15-8 |
| • KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
| 07-16-17 |
| • SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION - 3.8L, 3.9L, AND 4.2L - SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC) |
|
| 07-21-2 |
| • 4.6L 2V, 5.4L 2V, OR 6.8L 2V - SPARK PLUG THREAD REPAIR PROCEDURE - NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY |
|
| 9-22-8 |
| • STAINLESS STEEL EXHAUST STUDS - 5.4L AND 6.8L 2V ENGINES |
|
