Technical Service Bulletins
Year: 1997 MODEL: F-150 |
|
| 05-26-10 |
| • CLUNK OR BUMP WHEN STARTING FROM A STOP
|
|
| 05-23-3 |
| • REAR AXLE NOISE REPAIR
|
|
| 05-22-8 |
| • WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING
|
|
| 05-5-4 |
| • USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE
|
|
| 05-4-17 |
| • INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR FLOW
|
|
| 04-24-14 |
| • GENERAL PCM PROGRAMMING PROCEDURES
|
|
| 04-20-6 |
| • TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS
|
|
| 04-18-11 |
| • BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE - REPAIR PROCEDURE
|
|
| 04-5-7 |
| • BODY - FRONT WINDOW(S) - POP/THUMP NOISE AT END OF WINDOW TRAVEL AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION
|
|
| 03-23-2 |
| • BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS
|
|
| 03-21-27 |
| • FUEL SYSTEM - 7.3L DIRECT INJECTION (DI) TURBO DIESEL - NO RETURN FUEL FLOW TO FUEL TANK - BEGINNING WITH VEHICLES BUILT 2/9/94 |
| • LOW PERFORMANCE/LACK OF POWER - 7.3L DIRECT INJECTION (DI) TURBO DIESEL - NO RETURN FUEL FLOW TO FUEL TANK - BEGINNING WITH VEHICLES BUILT 2/9/94
|
|
| 03-21-25 |
| • WIRING - AFTERMARKET WIRING ALTERATIONS - SERVICE TIP
|
|
| 03-21-23 |
| • DRIVEABILITY - LOW RPM - NO START - RUNS POORLY - STALL - 7.3L DIT ENGINE
|
|
| 03-21-21 |
| • LEAK - OIL LEAK AT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE
|
|
| 03-21-20 |
| • ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP
|
|
| 03-20-6 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER |
| • ENGINE - DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES - 4.6L AND 5.4L ENGINE - ROUGH IDLE, HARD START OR NO START WHEN COLD - LOSS OF POWER - LEAN FUEL DTC'S - RESTRICTED CATALYTIC CONVERTER
|
|
| 03-20-3 |
| • DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457
|
|
| 03-18-3 |
| • DRIVEABILITY - DEDICATED COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY
|
|
| 03-18-1 |
| • ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS
|
|
| 03-15-13 |
| • STEERING - TIE ROD END INSPECTION PROCEDURE
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| 03-4-2 |
| • FUEL - BI-FUEL - CNG FUEL LEAK AT FILL VALVE - E-SERIES AND F-SERIES CNG FILL VALVE - REVISED SERVICE PARTS
|
|
| 02-22-1 |
| • DRIVEABILITY - SURGE/ROLLING IDLE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION |
| • ENGINE - GEAR DRIVEN SYNCHRONIZERS - INCORRECT INSTALLATION - CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION
|
|
| 02-21-13 |
| • ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS
|
|
| 02-21-11 |
| • RIDE - HARSH RIDE - CAB/BODY OSCILLATION/BOUNCE - HIGHWAY SPEEDS - 4X2 MODELS ONLY
|
|
| 02-21-4 |
| • ROOF DITCH MATERIAL CRACKING - SERVICE TIPS
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-19-3 |
| • DRIVEABILITY - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE |
| • 4.6L - IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER |
| • RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP |
| • NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-11-4 |
| • ENGINE - NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS
|
|
| 02-3-5 |
| • BODY - "SQUEAK" OR BIND FROM TAILGATE |
| • NOISE - "SQUEAK" OR BIND FROM TAILGATE
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL |
| • ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-8 |
| • DRIVEABILITY - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID |
| • STARTING - NO CRANK, NO START - CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID
|
|
| 01-21-6 |
| • ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH
|
|
| 01-21-5 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 11/01/01 EQUIPPED WITH 5.4L ENGINE |
| • ENGINE - 5.4L - PCV SYSTEM ICING - VEHICLES BUILT THROUGH 11/01/01
|
|
| 01-20-1 |
| • IDLE - HIGH IDLE AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000 |
| • ENGINE - 4.2L - PCV SYSTEM ICING - AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES - VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THROUGH 1/24/2000
|
|
| 01-19-2 |
| • BRAKES - REAR DRUM - GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD
|
|
| 01-18-2 |
| • BODY - COSMETIC CRACK IN OUTER DOOR PANEL - LOWER REAR CORNER OF WINDOW OPENING - INSPECTION AND REPAIR PROCEDURE
|
|
| 01-16-6 |
| • LAMP - 4X4 "LOW RANGE" LIGHT DIMLY LIT |
| • SWITCHES - TRANSFER CASE MODE SWITCH - 4X4 HI/LOW SWITCH SHORTED OUT |
| • WINDSHIELD WIPERS - INTERMITTENT WIPERS ERRATIC OR INOPERABLE |
| • TRANSFER CASE - WATER PRESENT IN TRANSFER CASE
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY
|
|
| 01-9-3 |
| • VIBRATION - FROM DRIVELINE - 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE |
| • TRANSMISSION - 4R70W - FLUID LEAK FROM EXTENSION HOUSING SEAL - 4X2 VEHICLES WITH 139 INCH WHEELBASE
|
|
| 01-8-7 |
| • DRIVEABILITY - BI-FUEL - INTERMITTENT STARTING OR DRIVEABLITY WIRE HARNESS SERVICE TIPS - IN BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY
|
|
| 01-7-4 |
| • DRIVEABILITY - BI-FUEL VEHICLE COMMUNICATION LINK (VCL) AND ALTERNATIVE FUEL CONTROL MODULE (AFCM) TERMINOLOGY CLARIFICATION - BI-FUEL VEHICLES ONLY
|
|
| 01-1-11 |
| • WATER LEAK - SLIDING REAR WINDOW - VEHICLES BUILT THROUGH 4/1999
|
|
| 00-26-1 |
| • ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000 |
| • NOISE - FROM ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ELECTRICAL - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ENGINE - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| 00-23-8 |
| • DRIVEABILITY - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F) |
| • ELECTRICAL - NO CRANK/NO START - MOISTURE FREEZES IN STARTER SOLENOID IN TEMPERATURES BELOW -12 DEGREES C (10 DEGREES F)
|
|
| 00-9-5 |
| • INNER FENDER WELL - DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL
|
|
| 00-9-1 |
| • LEAK - TRANSMISSION FLUID LEAKS AT RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK
|
|
| 00-6-11 |
| • CALIBRATION - RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT - SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY
|
|
| 00-1-7 |
| • DETONATION - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • HESITATION/STUMBLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • ROUGH IDLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • STALL/NEAR STALL - AT IDLE AND/OR LOW SPEEDS - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0171 AND/OR P1131 STORED IN MEMORY - VEHICLES WITH 5.4L ENGINE BUILT BEFORE 11/1/1997
|
|
| 99-25-6 |
| • BRAKES - INCORRECT ROTOR THICKNESS STAMPED ON ROTOR - F-150 4X2 ONLY |
| • BRAKES - INCORRECT WORKSHOP MANUAL ROTOR DISCARD THICKNESS SPECIFICATION
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-4 |
| • MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO DRIVEABILITY CONCERNS
|
|
| 99-20-7 |
| • COOLING SYSTEM - 3.8L - UNDETERMINED LOSS OF COOLANT |
| • COOLING SYSTEM - 4.2L - UNDETERMINED LOSS OF COOLANT |
| • ENGINE - 3.8L - ENGINE OIL CONTAMINATED WITH COOLANT |
| • ENGINE - 4.2L - ENGINE OIL CONTAMINATED WITH COOLANT
|
|
| 99-18-8 |
| • INDUCTION BACKFIRE - ON ACCELERATION - ALL AMBIENT TEMPERATURES - VEHICLES WITH 4.2L ENGINE - CANADIAN VEHICLES ONLY
|
|
| 99-18-5 |
| • TRANSMISSION CONTROL INDICATOR LAMP (TCIL) - TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0782 STORED IN MEMORY - VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION |
| • TRANSMISSION - 4R70W - DELAYED OR NO 2-3 UPSHIFT - VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998
|
|
| 99-16-4 |
| • IGNITION KEY - HARD TO REMOVE FROM IGNITION CYLINDER |
| • IGNITION KEY - HARD TO TURN
|
|
| 99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| 99-14-4 |
| • NOISE - "MOANING" AT 1100 RPM WITH A/C COMPRESSOR ENGAGED - VEHICLES WITH 4.2L ENGINE
|
|
| 99-14-3 |
| • NOISE - "MOANING" FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT THROUGH 4/15/1999 |
| • AXLE - "MOANING" NOISE FROM FRONT DIFFERENTIAL WHILE IN 2-WHEEL DRIVE - VEHICLES BUILT THROUGH 4/15/1999
|
|
| 99-13-13 |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - ABS LAMP ILLUMINATED - 4X2 ONLY |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY |
| • ANTI-LOCK BRAKE SYSTEM (ABS) - INCREASED BRAKE PEDAL EFFORT AT LOW SPEEDS - 4X2 ONLY |
| • LAMP - ANTI-LOCK BRAKE LAMP ILLUMINATION - INCREASED BRAKE PEDAL EFFORT AND/OR FALSE ABS CYCLING AT LOW SPEEDS - 4X2 ONLY
|
|
| 99-12-8 |
| • AIR CONDITIONING - "WHISTLING" NOISE HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH) |
| • NOISE - "WHISTLING" HEARD WHILE DRIVING WITH A/C OFF AT SPEEDS ABOVE 64 KM/H (40 MPH)
|
|
| 99-11-1 |
| • NOISE - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS |
| • VIBRATION - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
|
|
| 99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL REPLACEMENT - SERVICE TIP
|
|
| 99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) - SERVICE TIPS
|
|
| 99-5-4 |
| • FRAME - FRAME SERVICE KITS - NEW SERVICE PARTS RELEASED FOR REPAIRING FRAME DAMAGE
|
|
| 99-5-3 |
| • TRANSMISSION - CHECKING TRANSMISSION FLUID LEVEL COLD - SERVICE TIP
|
|
| 99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| 99-3-2 |
| • TRANSMISSION - M5OD - VEHICLE WILL NOT GO INTO REVERSE - VEHICLES BUILT THROUGH 11/1/1998
|
|
| 99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING - SERVICE TIP |
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| 99-2-2 |
| • NOISE - "BUZZING" - UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION
|
|
| 98-26-6 |
| • ROOF - DEPRESSION IN ROOF - REARWARD OF FRONT DOORS - SUPERCAB ONLY
|
|
| 98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| 98-25-9 |
| • INTERIOR TRIM - REPAIRS TO VINYL COVERED SURFACES - SERVICE TIP
|
|
| 98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE RELEASED FOR SERVICE
|
|
| 98-23-25 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0455 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) - MIL LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0455 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/30/97 EQUIPPED WITH E4OD TRANSMISSION AND 5.4L ENGINE
|
|
| 98-23-12 |
| • TRANSMISSION - 4R44E - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - 4R55E - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - 4R70W - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - 5R55E - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - AX4N - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - AX4S - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY |
| • TRANSMISSION - E4OD - DIAGNOSTIC TROUBLE CODES (DTCS) P0705, P0708, P1704 AND/OR P1705 STORED IN MEMORY
|
|
| 98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP
|
|
| 98-23-1 |
| • GENERIC ELECTRONIC MODULE (GEM) - WATER INTRUSION INTO GEM MODULE - SERVICE TIP
|
|
| 98-21-21 |
| • IDLE - FAST IDLE SPEED AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND/OR FAST IDLE SPEED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1506 STORED IN MEMORY - VEHICLES BUILT WITH 4.6L, 5.4L, OR 6.8L ENGINE
|
|
| 98-21-17 |
| • BRAKES - PARKING BRAKE CONTROL RUBBER BUMPER STOP - SERVICE PART NOW AVAILABLE
|
|
| 98-21-10 |
| • IDLE - HIGH IDLE SPEEDS - THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES - VEHICLES BUILT THROUGH 12/1/97 EQUIPPED WITH 4.6L ENGINE
|
|
| 98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR MUFFLER HEAT SHIELDS |
| • NOISE - "BUZZING" OR "RATTLING" - LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| 98-18-2 |
| • PAINT - EXTERIOR - WORLDWIDE RECOMMENDED PAINT MATERIALS FOR WARRANTY AND AFTER WARRANTY REPAIRS
|
|
| 98-16-18 |
| • FLOOR MAT - INSTALLATION OF VINYL FLOOR MATS - SERVICE TIP
|
|
| 98-16-17 |
| • FLOOR MAT - PRODUCTION FLOOR MAT INSTALLATION PROCEDURE - SERVICE TIP
|
|
| 98-16-12 |
| • FUEL SYSTEM - FUEL LEAKING FROM SPRING LOCK COUPLINGS AT FUEL RAIL - AMBIENT TEMPERATURES BELOW -40 DEGREES CELSIUS (-40 DEGREES FAHRENHEIT)
|
|
| 98-16-10 |
| • SEAT - SEAT BACK RECLINER INOPERATIVE - MEMORY LATCH DOES NOT ENGAGE
|
|
| 98-16-9 |
| • STEERING - ALIGNMENT - TOE SET PROCEDURE - SERVICE TIP
|
|
| 98-16-8 |
| • TRANSMISSION - E4OD/4R100 - 1989-99 - MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART
|
|
| 98-15-17 |
| • SEAT - CHILD TETHER KIT FOR INSTALLING CHILD SEAT IN REAR SEAT - SUPER CAB VEHICLES |
| • CHILD TETHER KIT - SERVICE TIP FOR INSTALLING CHILD SAFETY SEAT IN REAR SEAT - SUPER CAB VEHICLES
|
|
| 98-14-5 |
| • STEERING - "CLUNKING" FELT WHILE ROCKING STEERING WHEEL SIDE-TO-SIDE
|
|
| 98-12-12 |
| • HEATER - "MOAN" AT 1400-1800 RPM OR "HOOTING" NOISE HEARD AT 1200-2000 RPM ACCELERATION OR DECELERATION - VEHICLES WITH 4.6L ENGINE |
| • NOISE - "MOAN" AT 1400-1800 RPM OR "HOOTING" AT 1200-2000 RPM ACCELERATION OR DECELERATION - VEHICLES WITH 4.6L ENGINE
|
|
| 98-12-5 |
| • AIR CONDITIONING - FILTERING REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT - SERVICE TIPS
|
|
| 98-10-15 |
| • NOISE - "BUZZING" NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS - VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD OR 4R100 TRANSMISSION AND "MANUAL SHIFT-ON-THE-FLY," AND 5.4L ENGINE |
| • TRANSMISSION - E4OD OR 4R100 - NOISE - "BUZZING" NOISE HEARD UNDER CERTAIN SPEEDS AND LOADS - VEHICLES BUILT THROUGH 5/15/98 EQUIPPED WITH E4OD AND 4R100 TRANSMISSION AND "MANUAL SHIFT-ON-THE-FLY," AND 5.4L ENGINE
|
|
| 98-9-20 |
| • TRANSMISSION - E4OD - 4-1 DOWNSHIFT DURING A FORCED 4-2 DOWNSHIFT BETWEEN 88-105 KM/H (55-65 MPH) - VEHICLES BUILT THROUGH 12/22/97
|
|
| 98-9-15 |
| • BRAKES - 4WABS - ABS LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL - VEHICLES BUILT THROUGH 2/12/98 |
| • LAMP - ABS LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B1342 STORED IN MEMORY AND/OR CODES NOT LISTED IN WORKSHOP MANUAL - VEHICLES BUILT THROUGH 2/12/98
|
|
| 98-9-13 |
| • WATER LEAKS - VARIOUS AREAS OF VEHICLE |
| • ELECTRICAL - ACCESSORIES FUNCTIONING IMPROPERLY DUE TO WATER LEAKS |
| • LAMPS - WARNING LAMPS ILLUMINATED DUE TO WATER LEAKS
|
|
| 98-9-9 |
| • FUEL INJECTORS - NON-WARRANTY REIMBURSEMENT TESTING INFORMATION
|
|
| 98-8-10 |
| • TRAILER WIRING - CONVERTING A 4-WAY TRAILER CONNECTOR SYSTEM TO A 7-WAY HEAVY DUTY SYSTEM - SERVICE TIP
|
|
| 98-6-13 |
| • AIR CONDITIONING - COLD AIR FELT ON PASSENGER SIDE FLOOR WHILE IN HEAT MODE - F-SERIES AND EXPEDITION WITHOUT CONSOLE BLOWER OPTION - VEHICLES BUILT THROUGH 8/31/97
|
|
| 98-6-11 |
| • HESITATION/SURGE - INCORRECT AIR CLEANER AND MASS AIR FLOW (MAF) SENSOR |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171 AND/OR P0174 STORED IN MEMORY |
| • REDUCED POWER - INCORRECT AIR CLEANER AND MASS AIR FLOW (MAF) SENSOR |
| • STALL - INCORRECT AIR CLEANER AND MASS AIR FLOW (MAF) SENSOR |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171 AND/OR P0174 STORED IN MEMORY
|
|
| 98-5A-11 |
| • BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP
|
|
| 98-5A-5 |
| • BRAKES - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT |
| • BRAKE ROTOR MACHINING - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
|
|
| 98-5A-4 |
| • BRAKES - PREVENTING BRAKE VIBRATION - SERVICE TIP |
| • WHEELS - PROPER LUG TORQUE PROCEDURES - SERVICE TIP
|
|
| 98-5-8 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) P0503 STORED IN MEMORY - 4X4 VEHICLES ONLY |
| • TRANSMISSION - SHIFT CONCERNS AND/OR ERRATIC SPEEDOMETER OPERATION - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - 4X4 VEHICLES ONLY
|
|
| 98-5-2 |
| • TIRE - TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE
|
|
| 98-3-18 |
| • DEFROSTER - PERFORMANCE ENHANCEMENT
|
|
| 98-1-13 |
| • BUMPER - RUST STAIN - EDGES OF CENTER VENT AND FOG LAMP OPENINGS
|
|
| 97-26-19 |
| • HESITATION/SURGE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/97 |
| • MALFUNCTION INDICATOR LAMP (MIL) - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED - VEHICLES BUILT THROUGH 11/97 |
| • ROUGH IDLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED IN MEMORY - VEHICLES BUILT THROUGH 11/97 |
| • STALL - LOW SPEEDS AND OR IDLE - MIL ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 IN MEMORY - VEHICLES BUILT THROUGH 11/97 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0133, P0135, P0141, P0153, P0155, P0161, P1130, P1131, P1132, P1137, P1138, P1150, P1151, P1152, P1157, P1158 STORED - VEHICLES BUILT THROUGH 11/97
|
|
| 97-26-13 |
| • WHEELS - RIGHT REAR WHEEL AND WHEEL COVER DISCOLORED AND/OR PITTED FROM EXHAUST |
| • EXHAUST - EXHAUST FLOWS ON RIGHT REAR WHEEL - RIGHT REAR WHEEL AND/OR WHEEL COVER DISCOLORED AND/OR PITTED
|
|
| 97-25-8 |
| • RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY - VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0308 MAY BE STORED IN MEMORY - VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE |
| • ENGINE - ROLLER FINGER FOLLOWERS DISLODGE - DURING AMBIENT TEMPERTURES LESS THAN -18 DEGREES C (0 DEGREES F) - VEHICLES BUILT THROUGH 11/26/97 EQUIPPED WITH 4.6L OR 5.4L ENGINE
|
|
| 97-25-5 |
| • BLOWER MOTOR - "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS |
| • NOISE - "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS
|
|
| 97-24-23 |
| • STALL - ENGINE STALL DURING TRANSMISSION ENGAGEMENT - VEHICLES EQUIPPED WITH E4OD TRANSMISSION |
| • TRANSMISSION - E4OD - ENGINE STALL DURING ENGAGEMENT
|
|
| 97-24-21 |
| • IDLE - ROLLING IDLE SPEED - VEHICLES OVER 8500 LBS EQUIPPED WITH 5.8L ENGINE
|
|
| 97-24-13 |
| • REMOTE KEYLESS ENTRY (RKE) - DIAGNOSTIC SERVICE TIPS
|
|
| 97-23-13 |
| • TRANSMISSION - E4OD - NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING - TRANSMISSIONS BUILT AFTER 7/24/97
|
|
| 97-22-17 |
| • CLUTCH - HARD TO DISENGAGE OR FREQUENT REPLACEMENT OF CLUTCH SLAVE CYLINDER - EARLY WEAR-OUT OF SLAVE CYLINDER
|
|
| 97-22-7 |
| • WHEEL - HUB O-RING - SERVICE TIP
|
|
| 97-22-1 |
| • DELTA PRESSURE FEEDBACK EGR (DPFE) - DIAGNOSTIC TIPS
|
|
| 97-20-15 |
| • DRIVESHAFT - U-JOINT - AVAILABILITY OF GREASEABLE SERVICE PARTS |
| • DRIVESHAFT - U-JOINT - IDENTIFICATION OF SERVICE PARTS BY MEASUREMENT |
| • DRIVESHAFT - U-JOINTS - IDENTIFICATION OF SERVICE PARTS BY MEASUREMENT
|
|
| 97-19A-1 |
| • EVAPORATIVE EMISSIONS
|
|
| 97-19-20 |
| • TRANSMISSION - E4OD - MAIN REGULATOR BOOSTER VALVE AND SLEEVE SERVICE KIT - SERVICE TIP
|
|
| 97-19-19 |
| • AIR CONDITIONING - NO AIRFLOW FROM FLOOR |
| • HEATER - NO AIRFLOW FROM FLOOR
|
|
| 97-19-11 |
| • COOLING SYSTEM - "ON-VEHICLE" HEATER CORE PRESSURE TEST REQUIRED FOR WARRANTY CLAIM
|
|
| 97-17-25 |
| • TRANSMISSION - E4OD - NEW DESIGN REVERSE CLUTCH ASSEMBLY - TRANSMISSION BUILT FROM 3/26/97
|
|
| 97-17-23 |
| • NOISE - "BUZZING" OR "GROWLING" NOISE FROM TRANSFER CASE SHIFT LEVER - VEHICLES BUILT THROUGH 9/1/97 |
| • TRANSFER CASE - "BUZZING" OR "GROWLING" NOISE FROM TRANSFER CASE SHIFT LEVER - VEHICLES BUILT THROUGH 9/1/97
|
|
| 97-17-2 |
| • REAR VIEW MIRROR - NEW PROCEDURE FOR PREFERRED REATTACHMENT METHOD
|
|
| 97-16-11 |
| • AIR CONDITIONING - CONDENSATE DRIPS ONTO PASSENGER FLOOR DURING HUMID CONDITIONS
|
|
| 97-15-24 |
| • NOISE - "BOOMING" - VIBRATION OR BOOM
OFF IDLE AT ENGINE SPEEDS BETWEEN 650 RPMS AND 1100
RPMS AT VERY LOW VEHICLE SPEEDS
|
| • VIBRATION - VIBRATION OR BOOM OFF IDLE
AT ENGINE SPEEDS BETWEEN 650 RPMS AND 1100 RPMS AT
VERY LOW VEHICLE SPEEDS
|
|
| 97-15-5 |
| • AIR CONDITIONING - OIL REFILL CAPACITY
CHART - SERVICE TIP
|
|
| 97-13-23 |
| • TRANSMISSION - E4OD - INCORRECT
SEPARATOR PLATE - 4X4 VEHICLES BUILT FROM 4/18/97
THROUGH 4/21/97
|
| • TRANSMISSION - E4OD - SLIP/BUMP 1-2
UPSHIFTS - 4X4 VEHICLES BUILT FROM 4/18/97 THROUGH
4/21/97
|
|
| 97-13-21 |
| • NOISE - "CLUNKING" OR "GRUNTING" FROM
DRIVELINE DURING ACCELERATION OR BRAKING - 4X4
VEHICLES BUILT THROUGH 5/15/97
|
| • DRIVELINE - NOISE - "CLUNKING" OR
"GRUNTING" FROM DRIVELINE DURING ACCELERATION OR
BRAKING - 4X4 VEHICLES BUILT THROUGH 5/15/97
|
|
| 97-13-20 |
| • ENGINE - 7.3L DIT - 1997 ENGINE
CONTENT REVISIONS - SERVICE TIP
|
|
| 97-13-18 |
| • RADIO - "WHINING" IN AM RADIO BAND
WHILE DRIVING - VEHICLES BUILT THROUGH 5/30/97
|
| • NOISE - "WHINING" IN AM RADIO BAND -
VEHICLES BUILT THROUGH 5/30/97
|
|
| 97-12-13 |
| • TRANSMISSION - C6, E4OD, AOD, 4R70W -
LOW TRANSMISSION FLUID LEVEL AND/OR SHIFT AND/OR
ENGAGEMENT CONCERNS - 4X4 AND AWD VEHICLES ONLY
|
|
| 97-12-9 |
| • ENGINE MISFIRE - MIL LAMP ILLUMINATION
- DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0306
STORED IN MEMORY - NO DRIVEABILITY CONCERNS PRESENT -
VEHICLES BUILT THROUGH 4/15/97
|
| • HARD START - AT ALL AMBIENT
TEMPERATURES - VEHICLES WITH 4.2L ENGINE
|
| • INDUCTION BACKFIRE - AFTER COLD START
- AT ALL AMBIENT TEMPERATURES - VEHICLES WITH 4.2L
ENGINE
|
| • MALFUNCTION INDICATOR LAMP (MIL)
ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS) P0300
THROUGH P0306 STORED IN MEMORY - NO DRIVEABILITY
CONCERNS PRESENT - VEHICLES BUILT THROUGH 4/15/97
|
| • STALL - ROUGH IDLE -
HESITATION/STUMBLE - AFTER COLD START - AT ALL AMBIENT
TEMPERATURES - VEHICLES WITH 4.2L ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS)
P0300 THROUGH P0306 STORED IN MEMORY - NO DRIVEABILITY
CONCERNS PRESENT - VEHICLES BUILT THROUGH 4/15/97
|
|
| 97-11-21 |
| • NOISE - FIRST GEAR "TICKING" NOISE -
E4OD TRANSMISSIONS - 4X4 VEHICLES WITH 5.4L ENGINE AND
TRANSMISSION BUILT PRIOR TO 3/11/97 AND 4X2 VEHICLES
WITH TRANSMISSION BUILT PRIOR TO 4/8/97 - SERVICE TIP
|
| • E4OD - FIRST GEAR "TICKING" NOISE -
4X4 VEHICLES WITH 5.4L ENGINE AND TRANSMISSION BUILT
PRIOR TO 3/11/97 AND 4X2 VEHICLES WITH TRANSMISSION
BUILT PRIOR TO 4/8/97 - SERVICE TIP
|
|
| 97-11-11 |
| • TRANSMISSION - 4R70W - ERRATIC OR
PROLONGED 1-2 SHIFT
|
| • TRANSMISSION - AODE - ERRATIC OR
PROLONGED 1-2 SHIFT
|
|
| 97-11-5 |
| • REMOTE ANTI-THEFT PERSONALITY (RAP)
TRANSMITTERS - REPROGRAMMING INFORMATION
|
|
| 97-10-10 |
| • AXLE - FRONT - LUBRICANT LEAKING FROM
FRONT AXLE TUBE VENT HOSE
|
|
| 97-10-5 |
| • AIR CONDITIONING - COMPRESSOR FAILURE
- INSUFFICIENT AMOUNT OF REFRIGERANT OIL
|
| • AIR CONDITIONING - LACK OF COOLING -
INSUFFICIENT AMOUNT OF REFRIGERANT OIL MAY CAUSE
COMPRESSOR FAILURE
|
|
| 97-9-17 |
| • CLIMATE CONTROL - LOSS OF TEMPERATURE
CONTROL - VEHICLES BUILT THROUGH 2/18/97
|
|
| 97-9-8 |
| • POWERTRAIN CONTROL MODULE - REPROGRAM
POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES -
SERVICE TIP
|
|
| 97-9-1 |
| • PAINT - "RAPGARD" PAINT PROTECTION -
SERVICE TIP
|
|
| 97-8-6 |
| • MALFUNCTION INDICATOR LAMP (MIL) -
DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302,
P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED
IN MEMORY
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATES - DIAGNOSTIC TROUBLE CODES (DTCS)
P0300, P0301, P0302, P0303, P0304, P0305, P0306,
P0307, AND/OR P0308 STORED IN MEMORY
|
|
| 97-6-29 |
| • TRANSMISSION - E4OD - HARSH/DELAYED
2-3 UPSHIFTS - VEHICLES WITH 7.3L DIESEL AND 49-STATE
CALIBRATION - F-SERIES BUILT THROUGH 2/3/97 AND ALL
1996 E-350
|
|
| 97-4-10 |
| • TRANSMISSION - E4OD - COOLER BYPASS
VALVE SERVICE DURING TRANSMISSION OVERHAUL - SERVICE
TIP
|
|
| 97-4-7 |
| • FRAME - RIVET REPLACEMENT WITH BOLTS -
SERVICE TIPS
|
|
| 97-3-5 |
| • AIR CONDITIONING - R-134A TRACER DYE
INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK
COUPLERS - SERVICE TIP
|
|
| 96-26-18 |
| • FUEL - LOCKING GASOLINE CAPS - NEW
PART AVAILABILITY
|
| • LOCKING FUEL CAPS - NEW PART
AVAILABILITY
|
|
| 96-26-12 |
| • TRANSAXLE - TORQUE CONVERTER
REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE
COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP
|
| • TRANSMISSION - TORQUE CONVERTER
REPLACEMENT GUIDELINES AND TORQUE
CONVERTER/TRANSMISSION COOLING SYSTEM CLEANING
PROCEDURES - SERVICE TIP
|
|
| 96-25-25 |
| • NOISE - "RATTLE" - SUMMARY OF CONCERNS
- SERVICE TIPS
|
| • NOISE - "SQUEAK" - SUMMARY OF CONCERNS
- SERVICE TIPS
|
|
| 96-25-23 |
| • RUNS ROUGH - MALFUNCTION INDICATOR
LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300
THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT
THROUGH 10/14/96 WITH 4.6L ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ON - RUNS ROUGH - DIAGNOSTIC TROUBLE CODES
(DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES
BUILT THROUGH 10/14/96 WITH 4.6L ENGINE
|
|
| 96-25-21 |
| • STEERING - "CLUNK" NOISE FROM STEERING
COLUMN ON ACCELERATING AND BRAKING
|
| • NOISE - "CLUNK" - FROM STEERING COLUMN
ON ACCELERATING AND BRAKING
|
|
| 96-25-18 |
| • DOOR - POWER POINT ACCESS DOOR BREAKS
- VEHICLES BUILT THROUGH 8/31/96
|
|
| 96-24-10 |
| • TRANSMISSION - E4OD - 4R70W - 4R44E -
5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR -
DIAGNOSIS SERVICE TIP
|
|
| 96-24-9 |
| • TORQUE CONVERTER - LEAK TEST PROCEDURE
- SERVICE TIP
|
|
| 96-24-6 |
| • WIRING - ELECTRICAL DIODE
IDENTIFICATION AND SERVICE REPLACEMENTS
|
|
| 96-22-10 |
| • WINDSHIELD WASHERS - WASHER HOSE TOO
SHORT AND/OR IS TRAPPED BY THE HOOD - VEHICLES BUILT
THROUGH 4/15/96
|
|
| 96-22-5 |
| • MASS AIR FLOW SENSOR - REPLACEMENT AS
AN ASSEMBLY - SERVICE TIP
|
|
| 96-22-1 |
| • WINDSHIELD AND INTERIOR GLASS -
FOG/FILM
|
|
| 96-21-15 |
| • TRANSMISSION - E4OD - NEW DESIGN
OVERDRIVE CLUTCH PISTON ASSEMBLY FOR SOME 1996-97
VEHICLES - VEHICLES BUILT FROM 12/5/95 THROUGH 6/15/96
|
|
| 96-21-14 |
| • LEAK - 4R70W TRANSMISSION - EXTENSION
HOUSING GASKET
|
|
| 96-21-13 |
| • NOISE - "CLICKING" AND "GRINDING"
DURING 4X4 ENGAGEMENT
|
| • NOISE - "CLICKING" WHILE DRIVING
STRAIGHT OR DURING LEFT HAND TURN - 4X2
|
| • AXLE - "CLICKING" AND "GRINDING" NOISE
DURING 4X4 ENGAGEMENT
|
| • AXLE - NON-ENGAGEMENT OF FRONT AXLE
|
|
| 96-21-7 |
| • WEATHERSTRIP - LOOSE OR DETACHED -
FRONT DOOR OUTER
|
|
| 96-20-12 |
| • DOORS/TAILGATE - NEW SERVICE PART
RELEASED FOR DOOR LOCK ROD MECHANISM - VEHICLES BUILT
THROUGH 7/15/96
|
|
| 96-20-8 |
| • AIR CONDITIONING - NEW O-RING
APPLICATIONS - THICKER O-RINGS FOR SPRING LOCK
FITTINGS - SERVICE TIP
|
| • AIR CONDITIONING - SPRING LOCK
COUPLING CLEANING PROCEDURE - SERVICE TIP
|
|
| 96-17-18 |
| • LAMPS - INTERIOR - INTERMITTENT OR
INOPERATIVE - FUSE 14 "OPEN" - VEHICLES BUILT THROUGH
5/14/96
|
| • LOCKS - POWER DOOR - INTERMITTENT OR
INOPERATIVE - FUSE 14 "OPEN" - VEHICLES BUILT THROUGH
5/14/96
|
| • WINDOW - POWER - INTERMITTENT OR
INOPERATIVE - FUSE 14 "OPEN" - VEHICLES BUILT THROUGH
5/14/96
|
|
| 96-17-16 |
| • BUMPER - FRONT - PREMATURE SIGNS OF
WEAR AND/OR CHROME CRACKING - VEHICLES BUILT THROUGH
2/11/96
|
|
| 96-17-9 |
| • MALFUNCTION INDICATOR LAMP (MIL)
ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS) P0300,
P0301, P0302, P0303, P0304, P0305, P0306, P0307, OR
P0308 IN MEMORY - NO DRIVEABILITY CONCERNS PRESENT -
VEHICLES BUILT WITH 3.8L, 4.2L, OR 4.6L ENGINE
|
| • LAMP - MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODES (DTCS)
P0300, P0301, P0302, P0303, P0304, P0305, P0306,
P0307, OR P0308 IN MEMORY - NO DRIVEABILITY CONCERNS -
VEHICLES BUILT WITH 3.8L, 4.2L, OR 4.6L ENGINE
|
|
| 96-16-6 |
| • INSTRUMENT CLUSTER - RECALIBRATING
SPEEDOMETER FOR TIRE SIZE CHANGE
|
| • INSTRUMENT CLUSTER - SERVICE TIPS
|
|
| 96-14-9 |
| • FRONT END ACCESSORY DRIVE (FEAD)
"SQUEAL/HOOT" - DURING COLD START-UP AFTER COLD SOAK
BELOW -18 DEGREES C (0 DEGREES F)
|
| • NOISE - "SQUEAL/HOOT" FROM FRONT END
ACCESSORY DRIVE (FEAD) AREA - DURING COLD START-UP
AFTER COLD SOAK BELOW -18 DEGREES C (0 DEGREES F)
|
|
| 96-13-8 |
| • BLOWER MOTOR - INOPERATIVE OR NOISY
OPERATION - VEHICLES BUILT THROUGH 2/9/96
|
|
| 96-12-16 |
| • LAMP - ABS MALFUNCTION INDICATOR LAMP
(MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTC)
C1145, C1148, C1155, C1158, C1233, C1234 - 4X2 WITH
4-WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) - VEHICLES
BUILT THROUGH 2/26/96
|
|
| 96-12-9 |
| • NOISE - "CHATTER" DURING TIGHT TURNS
OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY DRIVING -
TRACTION-LOK DIFFERENTIAL - 7.5 AND 8.8 INCH RING GEAR
REAR AXLES
|
| • AXLE - NEW SERVICE KIT AVAILABLE FOR
TRACTION-LOK DIFFERENTIAL - 7.5 AND 8.8 INCH RING GEAR
|
| • AXLE - TRACTION-LOK DIFFERENTIAL - 7.5
AND 8.8 INCH RING GEAR - "CHATTER" NOISE DURING TIGHT
TURNS OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY
DRIVING
|
|
| 96-8-16 |
| • NOISE - "WHISTLE" WHILE DRIVING WITH
BLOWER MOTOR OPERATING - VEHICLES BUILT THROUGH
1/20/96
|
|
| 96-8-6 |
| • ENGINE - 4.6L - DIFFERENCES BETWEEN
ROMEO AND WINDSOR BUILT ENGINES - SERVICE TIP
|
|
| 07-1-7 |
| • MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS
|
|
| 06-21-19 |
| • HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
|
|
| 06-18-16 |
| • IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP
|
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
| 07-16-17 |
| • SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION - 3.8L, 3.9L, AND 4.2L - SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC) |
|
