Technical Service Bulletins
Year: 1996 MODEL: F-150 |
|
| 03-21-45 |
| • ENGINE - 7.3L - EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES
|
|
| 03-21-37 |
| • ROUGH IDLE - NEW TOOL FOR TESTING ROUGH IDLE - INJECTOR PERFORMANCE ANALYZER - SERVICE TIP
|
|
| 03-21-31 |
| • ROUGH IDLE - INJECTOR BORE SCUFFING DURING ENGINE BREAK-IN PERIOD - SERVICE TIP
|
|
| 03-21-28 |
| • COOLING SYSTEM - COOLANT LEAK AT REAR OIL COOLER HEADER - VEHICLES WITH 7.3L DIT ENGINE - VEHICLES BUILT FROM 9/1/95 THROUGH 10/31/95
|
|
| 03-21-27 |
| • FUEL SYSTEM - 7.3L DIRECT INJECTION (DI) TURBO DIESEL - NO RETURN FUEL FLOW TO FUEL TANK - BEGINNING WITH VEHICLES BUILT 2/9/94 |
| • LOW PERFORMANCE/LACK OF POWER - 7.3L DIRECT INJECTION (DI) TURBO DIESEL - NO RETURN FUEL FLOW TO FUEL TANK - BEGINNING WITH VEHICLES BUILT 2/9/94 |
|
| 03-21-26 |
| • NOISE - "MOANING" AT 1500-2000 RPM - 4X4 VEHICLES WITH 7.3L DIT ENGINE
|
|
| 03-21-25 |
| • WIRING - AFTERMARKET WIRING ALTERATIONS - SERVICE TIP
|
|
| 03-21-23 |
| • DRIVEABILITY - LOW RPM - NO START - RUNS POORLY - STALL - 7.3L DIT ENGINE
|
|
| 03-21-21 |
| • LEAK - OIL LEAK AT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE
|
|
| 03-21-19 |
| • ENGINE - 7.3L DI - VIBRATION AT 2600-3000 RPM - VEHICLES WITH 4X4 |
| • NOISEVIBRATION - MOANING/VIBRATION AT 2600-3000 RPM - VEHICLES WITH 7.3L DI AND 4X4
|
|
| 03-21-18 |
| • VIBRATION - DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY THROTTLE CONDITIONS - VEHICLES WITH 7.3L DI TURBO ENGINE AND TRANSMISSION BUILT PRIOR TO 11/13/95 (5L13) |
| • TRANSMISSION - E4OD - DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY THROTTLE CONDITIONS - VEHICLES WITH 7.3L DI TURBO ENGINE AND TRANSMISSION BUILT PRIOR TO 11/13/95 (5L13)
|
|
| 03-21-17 |
| • AIR CLEANER - DAMAGED AIR FILTER IN SEVERE DUTY CONDITIONS - VEHICLES WITH 7.3L DIT DIESEL ENGINE BUILT THROUGH 5/8/96 - SERVICE TIP
|
|
| 03-21-16 |
| • TRANSMISSION - E4OD - HARSH SHIFTS - 7.3L DIESEL BUILT BETWEEN 5/15/96 AND 7/8/96 - CALIFORNIA CALIBRATION 6-90P-R11 ONLY
|
|
| 03-21-14 |
| • FEAD BELT - WEARS, SHREDS, AND/OR COMES OFF - VEHICLES WITH 7.3L DIT ENGINE AND 130 AMP ALTERNATOR BUILT 8/94 THROUGH 5/96
|
|
| 03-21-13 |
| • NOISE - "KNOCKING" SOUND - VEHICLES WITH 7.3L DIT ENGINE - CALIFORNIA EMISSION VEHICLES ONLY
|
|
| 03-21-12 |
| • STALL - WHEN REVERSE AND/OR MANUAL LOW ARE SELECTED - (DTC) P1728 - OVERDRIVE CANCEL LAMP ILLUMINATED - 7.3L DIT ENGINE - VEHICLES WITH E40D TRANSMISSION - VEHICLES BUILT PRIOR TO 9/20/95 |
| • TRANSMISSION - E40D - 7.3L DIT ENGINE - OVERDRIVE CANCEL LAMP ILLUMINATED, (DTC) P1728, AND WHEN REVERSE AND/OR MANUAL LOW ARE SELECTED - VEHICLES BUILT PRIOR TO 9/20/95
|
|
| 03-21-11 |
| • HARD START/NO START/LONG CRANK TIME - F-SERIES BUILT FROM 2/9/94 AND ECONOLINE BUILT FROM 8/94 ALL WITH 7.3L DI TURBO DIESEL
|
|
| 03-21-9 |
| • ENGINE - 7.3L DI TURBO - SEALANT - RTV - AVAILABILITY OF NEW SEALANT FOR SERVICING 7.3L DI TURBO ENGINE |
| • SEALANT - RTV - AVAILABILITY OF NEW SEALANT FOR SERVICING 7.3L DI TURBO ENGINE
|
|
| 03-21-8 |
| • WATER IN FUEL LAMP - LAMP ILLUMINATED CONSTANTLY - FUEL DOES NOT DRAIN WHEN FUEL DRAIN VALVE IS OPENED - VEHICLES WITH 7.3L DI TURBO - SERVICE TIP |
| • FUEL - FUEL DOES NOT DRAIN OR DRAINS SLOWLY WHEN FUEL DRAIN VALVE IS OPENED - WATER-IN-FUEL LAMP ON - VEHICLES WITH 7.3L DI TURBO - SERVICE TIP
|
|
| 03-21-3 |
| • DRIVEABILITY - REDUCED POWER - NO START - 7.3L D.I. TURBO - IDM MODULE - NO DIAGNOSTIC TROUBLE CODES
|
|
| 03-21-1 |
| • DRIVEABILITY - LOSS OF POWER - MIL CODES 128 AND 845 (94 MY) OR P0236 AND P0238 (95-97 MY) - 7.3L DIRECT INJECTION TURBO DIESEL - INCORRECT MAP SENSOR
|
|
| 03-19-10 |
| • BRAKES - BRAKE PULL - 4X4 F-250/350
AND 4X4 EXCURSION VEHICLES ONLY
|
|
| 03-14-8 |
| • TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS
|
|
| 03-10-3 |
| • DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
| • DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
|
|
| 03-10-2 |
| • DRIVEABILITY - COMPRESSED NATURAL GAS (CNG) - ROUGH IDLE OR NO START WHEN COLD - VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY
|
|
| 02-21-1 |
| • TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED
|
|
| 02-17-6 |
| • LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK
|
|
| 02-16-4 |
| • FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER |
| • RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP |
| • NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO
|
|
| 02-1-9 |
| • ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
|
|
| 01-24-6 |
| • ENGINE - ENGINE OIL SYSTEM PRIMING
PROCEDURES - SERVICE TIPS
|
|
| 01-23-6 |
| • ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL |
| • ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS
|
|
| 01-21-4 |
| • DRIVEABILITY - BI-FUEL - LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART - SERVICE TIPS
|
|
| 01-15-6 |
| • CLIMATE CONTROL - REPEAT HEATER CORE
FAILURE
|
| • COOLING SYSTEM - REPEAT HEATER CORE
FAILURE
|
|
| 01-15-2 |
| • DRIVEABILITY - BI-FUEL - NO START IN BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY
|
|
| 01-10-12 |
| • WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE
|
|
| 01-10-11 |
| • DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY
|
|
| 01-10-6 |
| • DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS
|
|
| 01-9-7 |
| • DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY
|
|
| 01-7-4 |
| • DRIVEABILITY - BI-FUEL VEHICLE COMMUNICATION LINK (VCL) AND ALTERNATIVE FUEL CONTROL MODULE (AFCM) TERMINOLOGY CLARIFICATION - BI-FUEL VEHICLES ONLY
|
|
| 00-23-10 |
| • TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS
|
|
| 00-23-9 |
| • DRIVEABILITY - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ELECTRICAL - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY |
| • ENGINE - COMPUVALVE REPLACEMENT PROCEDURE - SERVICE TIP - BI-FUEL VEHICLES ONLY
|
|
| 00-13-3 |
| • NGS INFORMATION - NGS TESTER DISPLAYS FALSE HIGH SPARK ADVANCE READINGS - BI-FUEL VEHICLES ONLY - SERVICE TIP
|
|
| 99-24-2 |
| • LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS
|
|
| 99-23-6 |
| • TRANSMISSION - 4R100 - FLEXPLATE REPLACEMENT - VEHICLES WITH 7.3L DIESEL ENGINE - SERVICE TIP
|
|
| 99-15-2 |
| • TRANSMISSION - NEW TRANSMISSION FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA
|
|
| 99-11-1 |
| • NOISE - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS |
| • VIBRATION - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
|
|
| 99-8-15 |
| • INTERIOR TRIM - DOOR TRIM PANEL REPLACEMENT - SERVICE TIP
|
|
| 99-6-5 |
| • WINDNOISE - AROUND SIDE DOOR(S) - SERVICE TIPS
|
|
| 99-4-3 |
| • REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY
|
|
| 99-2-3 |
| • WATER LEAKS - WINDSHIELD SEALING - SERVICE TIP |
| • WINDSHIELD - SEALING - SERVICE TIP
|
|
| 99-1-10 |
| • ENGINE - NEW DESIGN ENGINE BLOCK FOR SERVICE - 7.0L AND 7.5L ENGINES
|
|
| 98-26-2 |
| • FUEL - INFORMATION ON GASOLINE - TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS
|
|
| 98-24-6 |
| • ELECTRICAL - NEW TERMINAL GREASE RELEASED FOR SERVICE
|
|
| 98-23-21 |
| • SUSPENSION - FRONT OR REAR - SIDE-TO-SIDE LEVELING PROCEDURES AND ATTITUDE SERVICE KITS FOR F-53 RV BASIC STRIPPED CHASSIS
|
|
| 98-23-14 |
| • FEAD - BELT TENSIONER WEAR - VEHICLES WITH 7.3L DI TURBO ENGINE
|
|
| 98-23-13 |
| • HESITATION/STUMBLE - POOR SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO |
| • IDLE - ROUGH - POOR SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO |
| • LACK OF POWER/POOR PERFORMANCE - POOR SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO |
| • STALLS - POOR SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO |
| • OIL - EXCESSIVE OIL CONSUMPTION - POOR SEAL ON INJECTOR O-RINGS - 7.3L DI TURBO
|
|
| 98-23-10 |
| • MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP
|
|
| 98-22-6 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) P0125 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.0L ENGINE BUILT THROUGH 8/10/95 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) P0125 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.0L ENGINE BUILT THROUGH 8/10/95
|
|
| 98-21-20 |
| • STEERING - STEERING WHEEL ALIGNMENT - CLEAR VISION - VEHICLES WITH MOTORHOME CHASSIS
|
|
| 98-21-19 |
| • TRANSMISSION - E4OD - ERRATIC 4-3 SHIFT HUNTING - NO 3-4 SHIFT AFTER CRESTING A GRADE - F-53 MODEL VEHICLES EQUIPPED WITH 7.5L ENGINE
|
|
| 98-21-7 |
| • BRAKES - FLUID ON BRAKE SHOES - REAR AXLE SEAL LEAK - F-53 MODEL VEHICLES |
| • AXLE - REAR AXLE SEAL LEAK - F-53 MODEL VEHICLES
|
|
| 98-20-10 |
| • EXHAUST SYSTEM - LOOSE CATALYST OR MUFFLER HEAT SHIELDS |
| • NOISE - "BUZZING" OR "RATTLING" - LOOSE CATALYST OR MUFFLER HEAT SHIELDS
|
|
| 98-16-8 |
| • TRANSMISSION - E4OD/4R100 - 1989-99 - MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART
|
|
| 98-15-12 |
| • EMISSIONS - AVAILABILITY OF EVAPORATIVE EMISSION CANISTER COMPONENTS
|
|
| 98-15-8 |
| • STEERING - SHIMMY - DIAGNOSTIC PROCEDURE - 4X2 AND 4X4 VEHICLES
|
|
| 98-15-6 |
| • EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE
|
|
| 98-12-5 |
| • AIR CONDITIONING - FILTERING REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT - SERVICE TIPS
|
|
| 98-9-9 |
| • FUEL INJECTORS - NON-WARRANTY REIMBURSEMENT TESTING INFORMATION
|
|
| 98-8-10 |
| • TRAILER WIRING - CONVERTING A 4-WAY TRAILER CONNECTOR SYSTEM TO A 7-WAY HEAVY DUTY SYSTEM - SERVICE TIP
|
|
| 98-7-4 |
| • LEAKS - OIL - AVAILABILITY OF NEW SILICONE GASKET AND SEALANT
|
|
| 98-5A-46 |
| • BRAKES - PULL OR DRIFT TO LEFT - NEGATIVE CASTER SPLIT - RADIUS ARM REPLACEMENT - 4X4 MODELS |
| • STEERING - PULL OR DRIFT TO LEFT - NEGATIVE CASTER SPLIT - RADIUS ARM REPLACEMENT - 4X4 MODELS
|
|
| 98-5A-35 |
| • BRAKES - REAR PARKING BRAKE CABLE BINDS - ALL LISTED VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED |
| • VIBRATION/SHUDDER FROM REAR - REAR BRAKES DRAG DUE TO REAR PARKING BRAKE CABLE BINDING - ALL LISTED VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED
|
|
| 98-5A-32 |
| • BRAKES - ON-VEHICLE CALIPER-MOUNT LATHE MACHINING SETUP PROCEDURES
|
|
| 98-5A-27 |
| • BRAKES - LUBRICANT LEAKING FROM REAR AXLE SEAL(S) CONTAMINATING BRAKE SHOES - SUB-ZERO TEMPERATURES - VEHICLES WITH 10.25 INCH RING GEAR FULL-FLOATING REAR AXLE |
| • AXLE - LUBRICANT LEAKING FROM REAR AXLE SEAL(S) - SUB-ZERO TEMPERATURES - VEHICLES WITH 10.25 INCH RING GEAR FULL-FLOATING REAR AXLE
|
|
| 98-5A-25 |
| • BRAKES - REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES - SERVICE TIPS |
| • SHUDDER - REAR - WHEN APPLYING BRAKES - SERVICE TIPS |
| • VIBRATION - REAR - WHEN APPLYING BRAKES - SERVICE TIPS
|
|
| 98-5A-24 |
| • BRAKES - REAR - GRABBING AND/OR "SQUEALING" NOISE DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND/OR WHILE BRAKES ARE COLD - SINGLE REAR WHEEL (SRW) VEHICLES OVER 8500 LBS GVWR |
| • NOISE - GRABBING AND/OR "SQUEALING" NOISE FROM REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND/OR WHILE BRAKES ARE COLD - SINGLE REAR WHEEL (SRW) VEHICLES OVER 8500 LBS GVWR
|
|
| 98-5A-23 |
| • BRAKES - PULL OR DRIFT - DIAGNOSTIC AND SERVICE PROCEDURES - 4X2 AND 4X4 MODELS OVER 8500 LBS GVW |
| • STEERING - PULL OR DRIFT - DIAGNOSTIC AND SERVICE PROCEDURES - 4X2 AND 4X4 MODELS OVER 8500 LBS GVW
|
|
| 98-5A-13 |
| • BRAKES - DISC BRAKE CALIPER SLIDE GREASE - NEW SPECIFICATION - SILICONE BRAKE CALIPER GREASE AND DIELECTRIC COMPOUND ONLY TO BE USED |
| • BRAKES - DRUM - SHOE-TO-BACKING PLATE LUBRICATION - NEW LUBRICANT MATERIAL |
| • BRAKES - PETROLEUM-BASED LUBRICANT MAY CAUSE SWELLING OF RUBBER PARTS - SERVICE TIP |
| • LUBRICANT - SILICONE DIELECTRIC COMPOUND - NEW APPLICATION - SILICONE BRAKE CALIPER GREASE AND DIELECTRIC COMPOUND
|
|
| 98-5A-11 |
| • BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP
|
|
| 98-5A-5 |
| • BRAKES - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT |
| • BRAKE ROTOR MACHINING - AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT
|
|
| 98-5A-4 |
| • BRAKES - PREVENTING BRAKE VIBRATION - SERVICE TIP |
| • WHEELS - PROPER LUG TORQUE PROCEDURES - SERVICE TIP
|
|
| 98-5-2 |
| • TIRE - TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE
|
|
| 98-4-19 |
| • LAMP - FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628 AND/OR 1728 STORED IN MEMORY |
| • TRANSMISSION - E4OD - FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628 AND/OR 1728 STORED IN MEMORY
|
|
| 98-3-18 |
| • DEFROSTER - PERFORMANCE ENHANCEMENT
|
|
| 98-1-15 |
| • FENDERS - RANDOM HAIRLINE CRACKS "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR WHEEL VEHICLES OPERATING IN SEVERE DUTY CONDITIONS
|
|
| 98-1-13 |
| • BUMPER - RUST STAIN - EDGES OF CENTER VENT AND FOG LAMP OPENINGS
|
|
| 97-26-18 |
| • ROUGH IDLE - 7.3L DIT - NEW CYLINDER CONTRIBUTION TEST - SERVICE DIAGNOSTIC TIP
|
|
| 97-24-29 |
| • AXLE - IDENTIFYING FORD DESIGN VS DANA DESIGN 10.25 INCH RING GEAR AXLES - SERVICE TIP
|
|
| 97-24-23 |
| • STALL - ENGINE STALL DURING TRANSMISSION ENGAGEMENT - VEHICLES EQUIPPED WITH E4OD TRANSMISSION |
| • TRANSMISSION - E4OD - ENGINE STALL DURING ENGAGEMENT
|
|
| 97-24-21 |
| • IDLE - ROLLING IDLE SPEED - VEHICLES OVER 8500 LBS EQUIPPED WITH 5.8L ENGINE
|
|
| 97-24-13 |
| • REMOTE KEYLESS ENTRY (RKE) - DIAGNOSTIC SERVICE TIPS
|
|
| 97-23-9 |
| • FUEL PUMP - AVAILABILITY OF NEW TURBINE STYLE FUEL PUMP AND SENDER - F SUPER DUTY MOTORHOME CHASSIS - SERVICE TIP
|
|
| 97-22-17 |
| • CLUTCH - HARD TO DISENGAGE OR FREQUENT REPLACEMENT OF CLUTCH SLAVE CYLINDER - EARLY WEAR-OUT OF SLAVE CYLINDER
|
|
| 97-22-12 |
| • AIR CONDITIONING - FACTORY-INSTALLED A/C PREP PACKAGE - PART IDENTIFICATION, LOCATION AND WARRANTY COVERAGE - SERVICE TIP
|
|
| 97-22-1 |
| • DELTA PRESSURE FEEDBACK EGR (DPFE) - DIAGNOSTIC TIPS
|
|
| 97-20-15 |
| • DRIVESHAFT - U-JOINT - AVAILABILITY OF GREASEABLE SERVICE PARTS |
| • DRIVESHAFT - U-JOINT - IDENTIFICATION OF SERVICE PARTS BY MEASUREMENT |
| • DRIVESHAFT - U-JOINTS - IDENTIFICATION OF SERVICE PARTS BY MEASUREMENT
|
|
| 97-19-20 |
| • TRANSMISSION - E4OD - MAIN REGULATOR BOOSTER VALVE AND SLEEVE SERVICE KIT - SERVICE TIP
|
|
| 97-19-11 |
| • COOLING SYSTEM - "ON-VEHICLE" HEATER CORE PRESSURE TEST REQUIRED FOR WARRANTY CLAIM
|
|
| 97-17-2 |
| • REAR VIEW MIRROR - NEW PROCEDURE FOR PREFERRED REATTACHMENT METHOD
|
|
| 97-17-1 |
| • BODY - SHEET MOLDING COMPOSITE (SMC) - HOOD/FENDER/DECKLID/LIFTGATE - SMALL COSMETIC DAMAGE REPAIR SERVICE TIP
|
|
| 97-15A-1 |
| • 7.3L DI TURBO POWERSTROKE DIESEL ENGINE
|
|
| 97-15-5 |
| • AIR CONDITIONING - OIL REFILL CAPACITY CHART - SERVICE TIP
|
|
| 97-13-22 |
| • NOISE/VIBRATION - WHEN DRIVING IN 4X2 MODE WITH HUBS LOCKED - 4X4 MODELS |
| • DRIVELINE - VIBRATION/NOISE - WHEN DRIVING IN 4X2 MODE WITH HUBS LOCKED - 4X4 MODELS
|
|
| 97-12-13 |
| • TRANSMISSION - C6, E4OD, AOD, 4R70W - LOW TRANSMISSION FLUID LEVEL AND/OR SHIFT AND/OR ENGAGEMENT CONCERNS - 4X4 AND AWD VEHICLES ONLY
|
|
| 97-11-11 |
| • TRANSMISSION - 4R70W - ERRATIC OR PROLONGED 1-2 SHIFT |
| • TRANSMISSION - AODE - ERRATIC OR PROLONGED 1-2 SHIFT
|
|
| 97-10-5 |
| • AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL |
| • AIR CONDITIONING - LACK OF COOLING - INSUFFICIENT AMOUNT OF REFRIGERANT OIL MAY CAUSE COMPRESSOR FAILURE
|
|
| 97-9-15 |
| • NO START - INOPERATIVE FUEL PUMP - VEHICLES BUILT THROUGH 12/12/96 |
| • GAUGES - FUEL GAUGE INOPERATIVE - VEHICLES BUILT THROUGH 12/12/96
|
|
| 97-9-8 |
| • POWERTRAIN CONTROL MODULE - REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP
|
|
| 97-9-5 |
| • LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 |
| • STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96
|
|
| 97-8-6 |
| • MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY
|
|
| 97-7-8 |
| • HEADLAMP - HEADLAMP HOUSING MELTS - AMBULANCE AND EMERGENCY VEHICLES ONLY
|
|
| 97-6-29 |
| • TRANSMISSION - E4OD - HARSH/DELAYED 2-3 UPSHIFTS - VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION - F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350
|
|
| 97-6-28 |
| • NOISE - "RATCHETING" - FRONT AXLE - 4X4 - SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS - BRONCO, F-150 AND F-250 UNDER 8500# GVW |
| • AXLE - 4X4 - "RATCHETING" NOISE - SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS - BRONCO, F-150 AND F-250 UNDER 8500# GVW
|
|
| 97-6-27 |
| • NOISE - "RATCHETING" - FRONT AXLE - 4X4 - SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS - F-250 AND F-350 OVER 8500# GVW |
| • AXLE - 4X4 - "RATCHETING" NOISE - SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS - F-250 AND F-350 OVER 8500# GVW
|
|
| 97-6-17 |
| • STEERING - HIGH EFFORT DURING HIGHWAY DRIVING - F SUPER DUTY MOTORHOME CHASSIS VEHICLES BUILT FROM 7/1/93 THROUGH 8/9/96
|
|
| 97-5-15 |
| • SPEEDOMETER - SPEEDOMETER/ODOMETER INOPERATIVE/ERRATIC AND/OR HARSH TRANSMISSION SHIFTS - F-53 CLASS "A" F-SUPER DUTY MOTORHOME CHASSIS
|
|
| 97-4-8 |
| • ACCESSORY DRIVE BELTS - FEAD BELT COMES OFF - VEHICLES WITH 4.9L ENGINE
|
|
| 97-4-7 |
| • FRAME - RIVET REPLACEMENT WITH BOLTS - SERVICE TIPS
|
|
| 97-3-10 |
| • FRAME - "POPPING/CREAKING" - FASTENER REPLACEMENT |
| • NOISE - "POPPING/CREAKING" - FRONT FRAME OR SUSPENSION BRACKETS
|
|
| 97-3-5 |
| • AIR CONDITIONING - R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS - SERVICE TIP
|
|
| 97-2-15 |
| • ENGINE - 6.9L DIESEL - DIAGNOSTIC GUIDE |
| • ENGINE - 7.3L DI TURBO DIESEL - DIAGNOSTIC GUIDE |
| • ENGINE - 7.3L IDI DIESEL - DIAGNOSTIC GUIDE |
| • ENGINE - 7.3L IDI TURBO DIESEL - DIAGNOSTIC GUIDE
|
|
| 97-2-6 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - GASEOUS FUEL PREP (GFP) VEHICLES - POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING REQUIRED - VEHICLES WITH 2.0L OR 4.9L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - GASEOUS FUEL PREP (GFP) VEHICLES - POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING REQUIRED - VEHICLES WITH 2.0L OR 4.9L ENGINE
|
|
| 97-1-14 |
| • ENGINE COMPARTMENT NOISE - "BUZZING OR KNOCKING" - RIGHT FRONT OF ENGINE - AFTER STARTING - 4.9L ENGINES - F-SERIES BUILT FROM 8/1/94 THROUGH 10/15/95 - ECONOLINE BUILT FROM 8/15/94 THROUGH 10/15/95 |
| • NOISE - "BUZZING OR KNOCKING" - RIGHT FRONT OF ENGINE - AFTER STARTING - 4.9L ENGINES - F-SERIES BUILT FROM 8/1/94 THROUGH 10/15/95 - ECONOLINE BUILT FROM 8/15/94 THROUGH 10/15/95
|
|
| 96-26-12 |
| • TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP |
| • TRANSMISSION - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSMISSION COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP
|
|
| 96-25-21 |
| • STEERING - "CLUNK" NOISE FROM STEERING COLUMN ON ACCELERATING AND BRAKING |
| • NOISE - "CLUNK" - FROM STEERING COLUMN ON ACCELERATING AND BRAKING
|
|
| 96-24-18 |
| • TRANSMISSION - E4OD - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP
|
|
| 96-24-9 |
| • TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP
|
|
| 96-24-6 |
| • WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS
|
|
| 96-23-20 |
| • DRIVELINE - "CLUNKING" OR "GRUNTING" NOISE DURING ACCELERATION OR STOPPING - 4X4 - 1992-96 F-150/F-250 UNDER 8500 GROSS VEHICLE WEIGHT (GVW) AND 1992-95 F-250/F-350 OVER 8500 GVW
|
|
| 96-23-16 |
| • FRONT SUSPENSION - LOW IN FRONT/STRIKE THROUGH ON BUMPS - F-350 4X4 EXCEPT MONOBEAM AND F-250 4X4 OVER 8500 GROSS VEHICLE WEIGHT
|
|
| 96-23-15 |
| • SUSPENSION - EARLY BALL JOINT WEAR - "CLUNK" FROM FRONT END |
| • NOISE - "CLUNKING" NOISE FROM BALL JOINTS - EARLY BALL JOINT WEAR
|
|
| 96-23-1 |
| • STEERING - "CLICKING" NOISE HEARD WHEN TURNING STEERING WHEEL |
| • NOISE - "CLICKING" SOUND HEARD WHEN TURNING STEERING WHEEL
|
|
| 96-22-1 |
| • WINDSHIELD AND INTERIOR GLASS - FOG/FILM
|
|
| 96-21-17 |
| • TRANSMISSION - E4OD - UNIQUE OVERDRIVE RING GEAR, ONE-WAY CLUTCH RETAINING RING AND SHAFT RETAINING RING - SERVICE TIP
|
|
| 96-21-15 |
| • TRANSMISSION - E4OD - NEW DESIGN OVERDRIVE CLUTCH PISTON ASSEMBLY FOR SOME 1996-97 VEHICLES - VEHICLES BUILT FROM 12/5/95 THROUGH 6/15/96
|
|
| 96-21-11 |
| • PROGRAMMABLE SPEEDOMETER/ODOMETER MODULE - POINTER WAVER - SERVICE TIP |
| • SPEEDOMETER - PROGRAMMABLE SPEEDOMETER/ODOMETER MODULE - POINTER WAVER - SERVICE TIP
|
|
| 96-20-13 |
| • STEERING - WANDER, SHIMMY, DRIFT/PULL, ALIGNMENT AND/OR "POP/CLUNK" NOISE IN FRONT AXLE - F-250 4X4 VEHICLES ONLY |
| • NOISE - "POP/CLUNK" FROM FRONT AXLE AREA - F-250 4X4 VEHICLES ONLY
|
|
| 96-20-8 |
| • AIR CONDITIONING - NEW O-RING APPLICATIONS - THICKER O-RINGS FOR SPRING LOCK FITTINGS - SERVICE TIP |
| • AIR CONDITIONING - SPRING LOCK COUPLING CLEANING PROCEDURE - SERVICE TIP
|
|
| 96-20-7 |
| • AIR CONDITIONING - NEW O-RING AVAILABILITY AND APPLICATIONS - SERVICE TIP
|
|
| 96-17-16 |
| • BUMPER - FRONT - PREMATURE SIGNS OF WEAR AND/OR CHROME CRACKING - VEHICLES BUILT THROUGH 2/11/96
|
|
| 96-15-13 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODE (DTC) P0420 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.0L ENGINE |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODE (DTC) P0420 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.0L ENGINE |
| • POWERTRAIN CONTROL MODULE (PCM) - REPROGRAM OR REPLACE - AFFECTED CALIBRATIONS: 6-54K-R06, 6-54E-R10, 6-54J-R11, 6-54M-R11, 6-53F-R10, 6-53E-R10, 6-53G-R10 - VEHICLES WITH 5.0L ENGINE
|
|
| 96-15-6 |
| • AIR CONDITIONING - FILTERING REFRIGERANT - SYSTEM FLUSHING - TRACER DYE - LEAK TESTING - O-RING TOOL - TSB REPUBLICATION TO INCLUDE LATEST MODEL YEAR
|
|
| 96-14-21 |
| • FEAD - "MOAN/WHINE" COMING FROM FRONT OF ENGINE AT IDLE - VEHICLES BUILT FROM 6/95 THROUGH 6/96 WITH 4.9L ENGINE |
| • NOISE - "MOAN/WHINE" COMING FROM FRONT OF ENGINE AT IDLE - VEHICLES BUILT FROM 6/95 THROUGH 6/96 WITH 4.9L ENGINE
|
|
| 96-12-12 |
| • BODY - TAILGATE - "CHUCKING" OR "SQUEAK" AND/OR "RATTLE" WHEN GOING OVER BUMPS |
| • NOISE - "CHUCKING" OR "SQUEAK" AND/OR "RATTLE" WHEN GOING OVER BUMPS
|
|
| 96-12-9 |
| • NOISE - "CHATTER" DURING TIGHT TURNS OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY DRIVING - TRACTION-LOK DIFFERENTIAL - 7.5 AND 8.8 INCH RING GEAR REAR AXLES |
| • AXLE - NEW SERVICE KIT AVAILABLE FOR TRACTION-LOK DIFFERENTIAL - 7.5 AND 8.8 INCH RING GEAR |
| • AXLE - TRACTION-LOK DIFFERENTIAL - 7.5 AND 8.8 INCH RING GEAR - "CHATTER" NOISE DURING TIGHT TURNS OR TURNS AFTER AN EXTENDED PERIOD OF HIGHWAY DRIVING
|
|
| 96-11-13 |
| • ENGINE - 7.3L DIT - 1996 ENGINE CONTENT REVISIONS - SERVICE TIP
|
|
| 96-11-9 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - CODE P1411 STORED IN MEMORY - VEHICLES BUILT THROUGH 12/1/95 - CALIFORNIA EMISSION VEHICLES ONLY |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - CODE P1411 STORED IN MEMORY - VEHICLES WITH 7.5L ENGINE AND BUILT THROUGH 12/1/95 - CALIFORNIA EMISSION VEHICLES ONLY
|
|
| 96-11-4 |
| • TRIM - EXTERIOR - CENTER WHEEL ORNAMENT FALLING OFF - VEHICLES BUILT THROUGH 12/8/95 WITH 16 INCH WHEELS |
| • WHEELS - CENTER WHEEL ORNAMENT FALLING OFF - VEHICLES BUILT THROUGH 12/8/95 WITH 16 INCH WHEELS
|
|
| 96-11-1 |
| • LOCKS - INTRODUCTION OF NEW LOCK DESIGN - SERVICE TIP
|
|
| 96-10-7 |
| • FUEL - CALIFORNIA REFORMULATED GASOLINE (CARFG) - SERVICE TIP
|
|
| 96-10-6 |
| • NEW GENERATION STAR (NGS) TESTER - INCORRECT INFORMATION DISPLAYED DURING DIAGNOSTIC MONITORING TEST RESULTS - VEHICLES WITH ON-BOARD DIAGNOSTICS (OBD) II
|
|
| 96-8-13 |
| • AIR CONDITIONING - INSUFFICIENT COOLING - BLEND DOOR NOT TRAVELING TO FULL COOL POSITION - VEHICLES BUILT FROM 2/5/96 THROUGH 2/14/96
|
|
| 96-7-28 |
| • TRANSMISSION - E4OD - REVERSE CLUTCH PISTON AND PISTON SEAL USAGE - SERVICE TIP
|
|
| 96-7-27 |
| • ENGINE NOISE - "KNOCKING" SOUND - 5.8L - SECONDARY AIR INJECTION (AIR) PUMP |
| • NOISE - "KNOCKING" SOUND - 5.8L - SECONDARY AIR INJECTION (AIR) PUMP
|
|
| 96-7-15 |
| • LOCKS - NEW DESIGN LOCKSETS HAVE BEEN INSTALLED ON CERTAIN TRIAL VEHICLES - LIGHT AND HEAVY TRUCK VEHICLES REFERENCED - SERVICE TIP
|
|
| 96-7-11 |
| • TRANSMISSION - 4R70W - SPECIAL SELECTION PROCEDURE FOR LOW SERVO PISTON - SERVICE TIP |
| • TRANSMISSION - 4R70W - UNIQUE CASE WITH LOW/REVERSE SPACER - SERVICE TIP
|
|
| 96-6-9 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - CODE P1742 STORED IN MEMORY - NO DRIVEABILITY CONCERNS PRESENT - VEHICLES WITH E4OD TRANSMISSIONS BUILT THROUGH 10/15/95 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - CODE P1742 STORED IN MEMORY - NO DRIVEABILITY CONCERNS PRESENT - VEHICLES WITH E4OD TRANSMISSION BUILT THROUGH 10/15/95
|
|
| 96-6-5 |
| • TRANSMISSION - 4R70W - #9 THRUST BEARING - SERVICE TIP
|
|
| 96-5-17 |
| • ENGINE - 4.9L/5.0L/5.8L - "HOOTING" NOISE FROM ENGINE COMPARTMENT - VEHICLES BUILT THROUGH 10/15/95 |
| • NOISE - "HOOTING" FROM ENGINE COMPARTMENT - VEHICLES WITH 4.9L/5.0L/5.8L ENGINE BUILT THROUGH 10/15/95
|
|
| 96-5-16 |
| • MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - CODE P1742 STORED IN MEMORY - NO DRIVEABILITY CONCERNS PRESENT - VEHICLES WITH E4OD TRANSMISSION BUILT THROUGH 10/15/95 |
| • LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - CODE P1742 STORED IN MEMORY - NO DRIVEABILITY CONCERNS PRESENT - VEHICLES WITH E4OD TRANSMISSION BUILT THROUGH 10/15/95
|
|
| 96-3-22 |
| • TRANSMISSION - E4OD - NEW DESIGN ELASTOMERIC GASKETS FOR MAIN CONTROL COVER AND BOTTOM PAN
|
|
| 96-2-4 |
| • AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) - SNOWPLOWING WITH F-150 REGULAR CAB 4X4 VEHICLES |
| • SNOWPLOWING WITH F-150 REGULAR CAB 4X4 VEHICLES EQUIPPED WITH AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) - GENERAL INFORMATION
|
|
| 95-25-13 |
| • TRANSMISSION - E4OD - DIRECT CLUTCH PLATE USAGE CHART - SERVICE TIP
|
|
| 95-24-7 |
| • WINDSHIELD WIPERS - WASHER FLUID RESERVOIR LOOSE - VEHICLES BUILT THROUGH 8/12/95 |
| • COOLING SYSTEM - COOLANT RECOVERY RESERVOIR LOOSE - VEHICLES BUILT THROUGH 8/12/95
|
|
| 95-24-4 |
| • DOOR - REPLACEMENT DOOR HAS LOOSE FITTING DOOR LOCK CYLINDER - SERVICE TIP |
| • LOCK - LOOSE FITTING DOOR LOCK CYLINDER - SERVICE TIP
|
|
| 95-23-14 |
| • TRANSMISSION - E4OD - NEW DESIGN INTERMEDIATE BAND APPLY SERVO ASSEMBLY
|
|
| 95-23-1 |
| • PAINT - 1996 COLOR CHART - AFTERMARKET SUPPLIER CROSS-REFERENCE LIST
|
|
| 95-21-1 |
| • SUPPLEMENTAL RESTRAINT SYSTEM - AIR BAG MODULES - DISCOLORED OR MARRED COVERS - PAINTING RESTRICTIONS
|
|
| 95-19-8 |
| • TRANSMISSION - 4R70W - ENGINE IN LIMITED OPERATING STRATEGY WHEN TRANSMISSION TESTER IS USED - SERVICE TIP
|
|
| 95-18-4 |
| • AIR CONDITIONING - FORD APPROVED FLUSHING PROCEDURES - SERVICE TIP
|
|
| 95-6-16 |
| • COOLING SYSTEM - LEAKING RADIATOR HOSE JOINT - 4.9L/5.0L/5.8L/7.3L DIT/7.5L - UPGRADED HOSE CLAMPS |
| • LEAKS - COOLANT - 4.9L/5.0L/5.8L/7.3L DIT/7.5L - RADIATOR HOSE JOINT - UPGRADED HOSE CLAMPS
|
|
| 06-26-1 |
| • MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS |
|
| 06-14-4 |
| • MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.
|
|
