2004 FORD F-150 Recalls
Recall information provided by National Highway Traffic Safety Administration
-
FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING
Running Sequence Number: 66721
Campaign Number: 11V385000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: 11S21
Component Name: FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING
Manufacturer: FORD MOTOR COMPANY
Begin Date of Manufacturing: 06-20-1995
End Date of Manufacturing: 08-04-2004
Vehicle, Equipment or Tire Report: V
Potential Number of Units Affected: 1100000
Date Owner Notified: 09-12-2011
INFLUENCED_BY: ODI
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 07-29-2011
Record Creation Date: 08-01-2011
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
Consequence: AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
Remedy: FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Notes: FORD'S RECALL CAMPAIGN NUMBER IS 11S21.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP: //WWW.SAFERCAR.GOV .
Recall Component ID: 000042797000215106000000148
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
AIR BAGS: FRONTAL: DRIVER SIDE: INFLATOR MODULE
Running Sequence Number: 78380
Campaign Number: 11V107000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: 11S18
Component Name: AIR BAGS: FRONTAL: DRIVER SIDE: INFLATOR MODULE
Manufacturer: FORD MOTOR COMPANY
Begin Date of Manufacturing: 11-01-2004
End Date of Manufacturing: 01-24-2006
Vehicle, Equipment or Tire Report: V
Potential Number of Units Affected: 1325000
Date Owner Notified: 03-23-2011
INFLUENCED_BY: ODI
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 02-23-2011
Record Creation Date: 02-23-2011
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
Consequence: THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
Remedy: FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Notes: FORD'S RECALL CAMPAIGN NUMBER IS 11S18.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP: //WWW.SAFERCAR.GOV .
Recall Component ID: 000039697000215106000000259
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING: HEADLIGHTS
Running Sequence Number: 85826
Campaign Number: 09E025000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING: HEADLIGHTS
Manufacturer: DOPE, INC.
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 42540
Date Owner Notified: 07-28-2009
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 05-11-2009
Record Creation Date: 05-11-2009
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP: //WWW.SAFERCAR.GOV .
Recall Component ID: 000031517000215106000000217
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING
Running Sequence Number: 83451
Campaign Number: 09E012000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING
Manufacturer: SABERSPORT
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 16270
Date Owner Notified: 05-11-2009
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 04-07-2009
Record Creation Date: 04-07-2009
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP: //WWW.SAFERCAR.GOV .
Recall Component ID: 000030698000215106000000216
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING: HEADLIGHTS
Running Sequence Number: 88970
Campaign Number: 07E089000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING: HEADLIGHTS
Manufacturer: SPYDER, INC.
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 238
Date Owner Notified: 11-21-2007
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 10-25-2007
Record Creation Date: 10-30-2007
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Remedy: SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET SPYDER HEADLAMP ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F150 PICKUP TRUCKS MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000025191000215106000000217
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING: HEADLIGHTS
Running Sequence Number: 72837
Campaign Number: 07E080000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING: HEADLIGHTS
Manufacturer: SONAR AUTO PARTS CO., LTD.
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 700
Date Owner Notified: 12-14-2007
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 09-25-2007
Record Creation Date: 09-25-2007
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Remedy: SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET SONAR HEADLAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000024933000215106000000217
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING: HEADLIGHTS
Running Sequence Number: 88905
Campaign Number: 07E075000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING: HEADLIGHTS
Manufacturer: EAGLE EYES TRAFFIC INDUSTRIAL CO. LTD
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 2388
Date Owner Notified: 11-06-2007
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 09-14-2007
Record Creation Date: 09-18-2007
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000024853000215106000000217
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EQUIPMENT: ELECTRICAL
Running Sequence Number: 72489
Campaign Number: 07E066000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EQUIPMENT: ELECTRICAL
Manufacturer: CEQUENT ELECTRICAL PRODUCTS
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 175
Date Owner Notified: 09-05-2007
INFLUENCED_BY: MFR
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 08-28-2007
Record Creation Date: 08-29-2007
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Remedy: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000024610000215106000000338
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
VEHICLE SPEED CONTROL
Running Sequence Number: 90322
Campaign Number: 07V336000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: 05S28
Component Name: VEHICLE SPEED CONTROL
Manufacturer: FORD MOTOR COMPANY
Begin Date of Manufacturing: 11-05-2002
End Date of Manufacturing: 05-18-2004
Vehicle, Equipment or Tire Report: V
Potential Number of Units Affected: 3600000
Date Owner Notified: 08-13-2007
INFLUENCED_BY: ODI
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 08-03-2007
Record Creation Date: 08-03-2007
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes: FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000024331000215106000000294
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING
Running Sequence Number: 38121
Campaign Number: 06E064000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING
Manufacturer: TRADESONIC
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 4029
Date Owner Notified: N/A
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 07-17-2006
Record Creation Date: 07-17-2006
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Notes: THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000022846000215106000000216
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING
Running Sequence Number: 50891
Campaign Number: 06E060000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING
Manufacturer: AAI MOTORSPORTS USA, LLC
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 87745
Date Owner Notified: 08-01-2006
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 06-29-2006
Record Creation Date: 06-29-2006
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Remedy: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes: THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000022816000215106000000216
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
FUEL SYSTEM, GASOLINE
Running Sequence Number: 47859
Campaign Number: 06E056000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: FUEL SYSTEM, GASOLINE
Manufacturer: UFI FILTERS USA
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 58640
Date Owner Notified: 08-04-2006
INFLUENCED_BY: MFR
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 06-13-2006
Record Creation Date: 06-23-2006
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Consequence: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Notes: THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000022804000215106000000144
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING: HEADLIGHTS
Running Sequence Number: 38534
Campaign Number: 06E052000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING: HEADLIGHTS
Manufacturer: SABRY LEE, INC.
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 14616
Date Owner Notified: 06-14-2006
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 06-12-2006
Record Creation Date: 06-12-2006
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000022780000215106000000217
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
EXTERIOR LIGHTING: HEADLIGHTS
Running Sequence Number: 61877
Campaign Number: 06E023000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: N/A
Component Name: EXTERIOR LIGHTING: HEADLIGHTS
Manufacturer: ANZO USA, INC.
Begin Date of Manufacturing: N/A
End Date of Manufacturing: N/A
Vehicle, Equipment or Tire Report: E
Potential Number of Units Affected: 292000
Date Owner Notified: 05-09-2006
INFLUENCED_BY: OVSC
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 03-13-2006
Record Creation Date: 03-14-2006
Regulation Part Number: 571
Federal Motor Safety Standard Number: 108
Summary: CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP: //WWW.SAFERCAR.GOV.
Recall Component ID: 000022608000215106000000217
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING
Running Sequence Number: 34495
Campaign Number: 04V443000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: 04S21
Component Name: FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING
Manufacturer: FORD MOTOR COMPANY
Begin Date of Manufacturing: 03-04-2004
End Date of Manufacturing: 06-21-2004
Vehicle, Equipment or Tire Report: V
Potential Number of Units Affected: 1689
Date Owner Notified: 09-17-2004
INFLUENCED_BY: MFR
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 09-13-2004
Record Creation Date: 09-15-2004
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 04S21.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Recall Component ID: 000021418000215106000000148
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number:
-
FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY
Running Sequence Number: 41880
Campaign Number: 04V200000
Make: FORD
Model: F-150
Year: 2004
MFR Campaingn Number: 04S14
Component Name: FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY
Manufacturer: FORD MOTOR COMPANY
Begin Date of Manufacturing: 07-18-2003
End Date of Manufacturing: 08-29-2003
Vehicle, Equipment or Tire Report: V
Potential Number of Units Affected: 371
Date Owner Notified: 05-06-2004
INFLUENCED_BY: MFR
Manufacturers of Recalled Vehicles: Ford Motor Company
Report Received Date: 04-26-2004
Record Creation Date: 04-27-2004
Regulation Part Number: N/A
Federal Motor Safety Standard Number: N/A
Summary: CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
Consequence: IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
Remedy: DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Notes: FORD RECALL NO. 04S14.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Recall Component ID: 000021095000215106000000146
Manufacturer-Supplied Component Name: N/A
Manufacturer-Supplied Component Description: N/A
Manufacturer-Supplied Component Part Number: